Light-induced Vocincrease and decrease in high-efficiency amorphous silicon solar cells

Journal of Applied Physics

Volumn 116, Issue 9, 2014, Pages

  Stuckelberger, M ^a   Riesen, Y ^a   Despeisse, M ^a   Schuttauf J W ^a   Haug, F J ^a   Ballif, C ^a  

^a EPFL   (Switzerland)

Author keywords

[No Author keywords available]

Indexed keywords

EFFICIENCY; OPEN CIRCUIT VOLTAGE; SILICON CARBIDE; SILICON SOLAR CELLS; SUBSTRATES;

ABSORBER LAYERS; AMORPHOUS SILICON (A-SI:H); HIGH-EFFICIENCY; LIGHT SOAKING; LIGHT-INDUCED CHANGES; QUASI-FERMI LEVEL; ROUGH SUBSTRATES; SUBSTRATE ROUGHNESS;

AMORPHOUS SILICON;

EID: 84914159150     PISSN: 00218979     EISSN: 10897550     Source Type: Journal    
DOI: 10.1063/1.4894457     Document Type: Article

References (54)

1. D. Staebler and C. Wronski, " Reversible conductivity changes in discharge-produced amorphous Si," Appl. Phys. Lett. 31, 292-294 (1977). 10.1063/1.89674
2. P. Roca i Cabarrocas, A. Fontcuberta i Morral, and Y. Poissant, " Growth and optoelectronic properties of polymorphous silicon thin films," Thin Solid Films 403-404, 39-46 (2002). 10.1016/S0040-6090(01)01656-X
3. Y. Poissant, P. Chatterjee, and P. Roca i Cabarrocas, " Analysis and optimization of the performance of polymorphous silicon solar cells: Experimental characterization and computer modeling," J. Appl. Phys. 94, 7305-7316 (2003). 10.1063/1.1623610
4. M. Fehr, A. Schnegg, B. Rech, O. Astakhov, F. Finger, R. Bittl, C. Teutloff, and K. Lips, " Metastable defect formation at microvoids identified as a source of light-induced degradation in a-Si:H," Phys. Rev. Lett. 112, 066403 (2014). 10.1103/PhysRevLett.112.066403
5. T. Matsui, H. Sai, K. Saito, and M. Kondo, " High-efficiency thin-film silicon solar cells with improved light-soaking stability," Prog. Photovoltaics Res. Appl. 21, 1363-1369 (2013). 10.1002/pip.2300
6. T. Matsui, H. Sai, T. Suezaki, M. Matsumoto, K. Saito, I. Yoshida, and M. Kondo, " Development of highly stable and efficient amorphous silicon based solar cells," in Proceedings of the 28th EU PVSEC (2013), pp. 2213-2217.
7. Thin-film Silicon Solar Cells, edited by A. Shah (CRC Press, 2010).
8. I. A. Yunaz, K. Hashizume, S. Miyajima, A. Yamada, and M. Konagai, " Fabrication of amorphous silicon carbide films using VHF-PECVD for triple-junction thin-film solar cell applications," Sol. Energy Mater. Sol. Cells 93, 1056-1061 (2009). 10.1016/j.solmat.2008.11.048
9. S. Inthisang, K. Sriprapha, S. Miyajima, A. Yamada, and M. Konagai, " Hydrogenated amorphous silicon oxide solar cells fabricated near the phase transition between amorphous and microcrystalline structures," Jpn. J. Appl. Phys., Part 1 48, 122402 (2009). 10.1143/JJAP.48.122402
10. L. Ding, M. Stuckelberger, M. Morales Masis, S. Nicolay, and C. Ballif, " Stability of the opto-electrical properties of Zinc Oxide electrodes in thin-film silicon solar cells under light soaking," (unpublished).
11. P. Lechner, R. Geyer, A. Haslauer, and T. Roehrl, " Long-term performance of ASI tandem junction thin film solar modules," in Proceedings of the 25th EU PVSEC (2010), pp. 3283-3287.
12. M. Isomura, H. Yamamoto, M. Kondo, and A. Matsuda, " The light-induced increase in open circuit voltage of amorphous silicon solar cells," in Proceedings of the 2nd World Conference And Exhibition On Photovoltaic Solar Energy Conversion (1998), pp. 925-928.
13. E. M. El Mhamdi, J. Holovsky, B. Demaurex, C. Ballif, and S. De Wolf, " Is light-induced degradation of a-Si:H/c-Si interfaces reversible?," Appl. Phys. Lett. 104, 252108 (2014). 10.1063/1.4885501
14. T. Shimizu, " Staebler-Wronski effect in hydrogenated amorphous silicon and related alloy films," Jpn. J. Appl. Phys., Part 1 43, 3257-3268 (2004). 10.1143/JJAP.43.3257
15. S. B. Zhang and H. M. Branz, " Hydrogen above saturation at silicon vacancies: H-pair reservoirs and metastability sites," Phys. Rev. Lett. 87, 105503 (2001). 10.1103/PhysRevLett.87.105503
16. A. Smets, W. Kessels, and M. van de Sanden, " Vacancies and voids in hydrogenated amorphous silicon," Appl. Phys. Lett. 82, 1547-1549 (2003). 10.1063/1.1559657
17. A. Smets, C. Wronski, M. Zeman, and M. van de Sanden, " The Staebler-Wronski effect: New physical approaches and insights as a route to reveal its origin," Mater. Res. Soc. Symp. Proc. 1245, 1245-A14-02 (2010). 10.1557/PROC-1245-A14-02
18. P. St'ahel, A. Hadjadj, P. Sládek, and P. Roca i Cabarrocas, " Metastability in boron doped a-Si:H and a-SiC:H materials: Correlation with solar cell parameters," in Proceedings of the 14th EU PVSEC (1997), pp. 640-643.
19. P. Roca i Cabarrocas, P. Stáhel, S. Hamma, and Y. Poissant, " Stable single junction p-i-n solar cells with efficiencies approaching 10%," in Proceedings of the 2nd World Conference and Exhibition on Photovoltaic Solar Energy Conversion (1998), pp. 355-358.
20. K. Lord, B. Yan, J. Yang, and S. Guha, " Light-induced increase in the open-circuit voltage of thin-film heterogeneous silicon solar cells," Appl. Phys. Lett. 79, 3800-3802 (2001). 10.1063/1.1420778
21. J. Yang, K. Lord, B. Yan, A. Banerjee, and S. Guha, " Correlation of the open-circuit voltage enhancement of heterogeneous silicon solar cells and the Staebler-Wronski effect," in Proceedings of the 29th IEEE PVSC (2002), pp. 1094-1097.
22. B. Yan, J. Yang, G. Yue, K. Lord, and S. Guha, " On the mechanism of light-induced open-circuit voltage increase in mixed-phase hydrogenated silicon solar cells," in Proceedings of the 3rd World Conference on Photovoltaic Solar Energy Conversion (2003).
23. G. Yue, B. Yan, J. Yang, K. Lord, and S. Guha, " Kinetics of light-induced effects in mixed-phase hydrogenated silicon solar cells," Mater. Res. Soc. Symp. Proc. 762, A12.2 (2003). 10.1557/PROC-762-A12.2
24. E. Johnson, A. Abramov, Y. Soro, M. Gueunier-Farret, J. Méot, J. P. Kleider, and P. Roca i Cabarrocas, " Application of high deposition rate (9A/s) pm-Si:H to photovoltaic modules," in Proceedings of the 23rd EU PVSEC (2008), pp. 2339-2342.
25. E. Johnson, F. Dadouche, M. Gueunier-Farret, J. Kleider, and P. Roca i Cabarrocas, " Open-circuit voltage increase dynamics in high and low deposition rate polymorphous silicon solar cells," Phys. Status Solidi A 207, 691-694 (2010). 10.1002/pssa.200982723
26. T. Matsui, paper presented at MRS Spring Conference, San Francisco, 22 April 2014.
27. B. Rech, C. Beneking, S. Wieder, and H. Wagner, " Initial and stabilized open-circuit voltage of a-Si:H solar cells: A discussion on the basis of dark I-V curves," in Proceedings of the 14th EU PVSEC (1997), pp. 574-577.
28. M. Stuckelberger, paper presented at MRS Spring Conference, San Francisco, 22 April 2014.
29. M. Stuckelberger, M. Despeisse, G. Bugnon, J.-W. Schüttauf, F.-J. Haug, and C. Ballif, " Comparison of amorphous silicon absorber materials: Light-induced degradation and solar cell efficiency," J. Appl. Phys. 114, 154509 (2013). 10.1063/1.4824813
30. M. Stuckelberger, N. Almat, A. Billet, Y. Riesen, L. Egger, A. Walter, J.-W. Schüttauf, F.-J. Haug, and C. Ballif, " Properties and light-induced degradation of optimized p-type amorphous silicon-carbide layers," (unpublished).
31. M. Python, E. Vallat-Sauvain, J. Bailat, D. Dominé, L. Fesquet, A. Shah, and C. Ballif, " Relation between substrate surface morphology and microcrystalline silicon solar cell performance," J. Non-Cryst. Solids 354, 2258-2262 (2008). 10.1016/j.jnoncrysol.2007.09.084
32. S. Nicolay, M. Benkhaira, L. Ding, J. Escarre, G. Bugnon, F. Meillaud, and C. Ballif, " Control of CVD-deposited ZnO films properties through water/DEZ ratio: Decoupling of electrode morphology and electrical characteristics," Sol. Energy Mater. Sol. Cells 105, 46-52 (2012). 10.1016/j.solmat.2012.05.016
33. L. Fanni, B. A. Aebersold, D. T. L. Alexander, L. Ding, M. Morales Masis, S. Nicolay, and C. Ballif, " c-texture versus a-texture low pressure metalorganic chemical vapor deposition ZnO films: lower resistivity despite smaller grain size," Thin Solid Films 565, 1-6 (2014). 10.1016/j.tsf.2014.06.033
34. P. Cuony, M. Marending, D. Alexander, M. Boccard, G. Bugnon, M. Despeisse, and C. Ballif, " Mixed-phase p-type silicon oxide containing silicon nanocrystals and its role in thin-film silicon solar cells," Appl. Phys. Lett. 97, 213502 (2010). 10.1063/1.3517492
35. G. Jellison and F. Modine, " Parameterization of the optical functions of amorphous materials in the interband region," Appl. Phys. Lett. 69, 371-373 (1996). 10.1063/1.118064
36. G. Jellison and F. Modine, " Erratum: "Parameterization of the optical functions of amorphous materials in the interband region" [Appl. Phys. Lett. 69, 371 (1996)]," Appl. Phys. Lett. 69, 2137 (1996). 10.1063/1.118155
37. INDEOtec, Switzerland, last accessed July 20, 2014.
38. IEC, "IEC (International Electrotechnical Commission) 60904-9 Ed.2: Photovoltaic devices-Part 9: Solar simulator performance requirements" (2007).
39. IEC, "IEC (International Electrotechnical Commission) 60904-3 Ed.2: Photovoltaic devices-Part 3: Measurement principles for terrestrial photovoltaic (PV) solar devices with reference spectral irradiance data" (2006).
40. M. Stuckelberger, B. Perruche, M. Bonnet-Eymard, Y. Riesen, M. Despeisse, F.-J. Haug, and C. Ballif, " Class AAA LED-based solar simulator for steady-state measurements and light soaking," IEEE J. Photovoltaics 4, 1282-1287 (2014). 10.1109/JPHOTOV.2014.2335738
41. B. E. Pieters, J. Krc, and M. Zeman, " Advanced numerical simulation tool for solar cells-ASA5," in Proceedings of the Conference Record on 4th WCPEC (2006), Vol. 2, pp. 1513-1516.
42. M. Stuckelberger, A. Billet, L. Ding, F.-J. Haug, and C. Ballif, " Light-induced degradation kinetics of boron-doped zinc oxide," (unpublished).
43. A. Boccara, D. Fournier, and J. Badoz, " Thermo-optical spectroscopy: Detection by the "mirage effect," " Appl. Phys. Lett. 36, 130-132 (1980). 10.1063/1.91395
44. J. Holovský, M. Schmid, M. Stuckelberger, M. Despeisse, C. Ballif, A. Poruba, and M. Vaněček, " Time evolution of surface defect states in hydrogenated amorphous silicon studied by photothermal and photocurrent spectroscopy and optical simulation," J. Non-Cryst. Solids 358, 2035-2038 (2012). 10.1016/j.jnoncrysol.2011.12.031
45. T. Matsui, private communication (2014).
46. A. Smets and M. van de Sanden, " Relation of the Si-H stretching frequency to the nanostructural Si-H bulk environment," Phys. Rev. B 76, 073202 (2007). 10.1103/PhysRevB.76.073202
47. M. Stuckelberger, " Amorphous silicon: Impact of process conditions on material properties and solar cell efficiency," Ph.D. thesis, Ecole Polytechnique Fédérale de Lausanne, Switzerland (unpublished).
48. M. Fischer, R. Quax, M. Zeman, and A. Smets, " Degradation kinetics of amorphous silicon solar cells processed at high pressure and its relation to the nanostructure," in Proceedings of the IEEE Photovoltaic Specialists Conference, Tampa, FL, 2013.
49. M. Stuckelberger, A. Billet, Y. Riesen, M. Boccard, M. Despeisse, J.-W. Schüttauf, F.-J. Haug, and C. Ballif, " Comparison of amorphous silicon absorber materials: kinetics of light-induced degradation," Prog. Photovoltaics Res. Appl. (submitted).
50. M. Stuckelberger, Y. Riesen, B. Perruche, M. Despeisse, N. Wyrsch, and C. Ballif, " Charge collection in amorphous silicon solar cells: cell analysis and simulation of high-efficiency pin devices," J. Non-Cryst. Solids 358, 2187-2189 (2012). 10.1016/j.jnoncrysol.2011.11.013
51. N. Beck, N. Wyrsch, C. Hof, and A. Shah, " Mobility lifetime product-A tool for correlating a-Si:H film properties and solar cell performances," J. Appl. Phys. 79, 9361-9368 (1996). 10.1063/1.362614
52. M. Stuckelberger, A. Shah, J. Krc, M. Despeisse, F. Meillaud, and C. Ballif, " Internal electric field and fill factor of amorphous silicon solar cells," in Proceedings of the 35th IEEE Photovoltaic Specialists Conference (2010), pp. 001569-001574.
53. M. Stuckelberger, A. Billet, A. Walter, J.-W. Schüttauf, F.-J. Haug, and C. Ballif, " Impact of substrate roughness on charge collection in amorphous silicon solar cells," (unpublished).
54. M. Zeman, J. van den Heuvel, M. Kroon, J. Willemen, B. Pieters, J. Krc, and S. Solntsev, Advanced Semiconductor Analysis (ASA), user's manual, version 6.0 (2013).