In situ sensors for CIGS deposition and manufacture

Materials Research Society Symposium Proceedings

Volumn 865, Issue , 2005, Pages 499-510

  Repins, I L ^a   Gomez, N ^a   Simpson, L ^a   Joshi, B ^a  

^a ITN Energy Systems   (United States)

Author keywords

[No Author keywords available]

Indexed keywords

EVAPORATION; OPTIMIZATION; PROCESS CONTROL; SENSORS; DEPOSITION;

CIGS DEPOSITION; INDUSTRIAL ENVIRONMENTS; CO-EVAPORATED; DEVICE EFFICIENCY; IN-SITU SENSORS; PHOTOVOLTAICS; SITU DIAGNOSTICS; STATE OF THE ART;

COPPER COMPOUNDS; MANUFACTURE;

EID: 30544448312     PISSN: 02729172     EISSN: None     Source Type: Conference Proceeding    
DOI: 10.1557/proc-865-f15.3     Document Type: Conference Paper

References (34)

1. 2 Thin-film Solar Cells. Progress in Photovoltaics: Research and Applications 2003; 11: 225-230.
2. Gogol CA, Cipro C. Current Industrial Practices - Technical Note: Composition Control of High Temperature Superconducting Materials. Surface and Coatings Technology 1989; 37: 339-348.
3. Gogol CA, Reagan HS. A performance comparison of vacuum deposition monitors employing atomic absorption (AA) and electron impact emission spectroscopy. Journal of Vacuum Science and Technology 1982; A1(2): 252-256.
4. 2 Films By Inline Evaporation. Twenty-Eighth IEEE Photovoltaic Specialists Conference, 2000; 499-504.
5. Stolt L, Hedstrom J, Sigurd D. Coevaporation with rate control system based on quadrupole mass spectrometer, Journal of Vacuum Science and Technology 1985; 3: 403-407.
6. L.M. Maissel, R. Glang, Handbook of Thin Film Technology, McGraw-Hill, New York, 1970, pp. 1-103 ff.
7. G. Neuer, L. Fiessler, M. Groll, E. Schreiber, "Critical analysis of the different methods of multiwave length pyrometry," Temperature, its Measurement and Control in Science and Industry, Vol. 6, Edited by J.F. Schooley, American Institute of Physics, New York, 1992, pp. 787-790.
8. I.L. Repins, D. Fisher, W.K. Batchelor, L. Woods, M.E. Beck, "A Non-Contact Low-Cost Sensor for Improved Repeatability in Co-Evaporation of High-Quality CIGS", Progress in Photovoltaics, in press, 2005.
9. L. Simpson "Trajectory Oriented and Fault Tolerant Based, Intelligent Process Control for Flexible CIGS PV Module Manufacturing," Final report for National Renwable Energy Laboratory PVMat contract ZDO-2-30628-07, (2005).
10. th Symposium on Temperature: Its Measurement and Control in Science and Industry, (2004).
11. 2 Thin Film Composition", Thin Solid Films 408, pp. 64-72, 2002.
12. I.L. Eisgruber, J.R. Engel, R.E. Treece, R.E. Hollingsworth, J. Britt, "In situ Measurements of Cu(In,Ga)Se2 Composition by X-Ray Fluorescence", IEEE Photovoltaics Specialists Conference Record, 28, pp. 505-508, 2000.
13. 2 by In-Line Evaporation (Composition Monitoring Method Using Heat Radiation). Solar Energy Materials and Solar Cells 2001; 67: 203-207.
14. 2 Thin Film Preparation. Thin Solid Films 1995; 258: 313-316.
15. 2 Thin Films. Materials Research Society Symposium Proceedings 1996; 67: 267-278.
16. 3 precursor films. Applied Physics Letters 1994; 65(2): 198-200.
17. 2 Growth Using "End Point Detection. Proceedings of the 28th IEEE Photovoltaics Specialists Conference, 2000; 509-512.
18. K. Sakurai, R. Hunger, R. Scheer, C.A. Kaufmann, A. Yamada, T. Baba, Y. Kimura, K. Matsubara, P. Fons, H. Nakanishi, S. Niki, "In situ Diagnostic Methods for Thin-Film Fabrication: Utilization of Heat Radiation and Light Scattering," Progress in Photovoltaics, 12, 2004, 219-234.
19. R. Scheer, Ch. Pietzker, D. Braunig, "Laser Light Scattering in situ Studies on the Growth of Chalcopyrite Thin Films," Materials Research Society Proceedings, 668, (2001), pp.H7.3.1-H7.3.5.
20. L. J. Simpson et.al., Mat. Res. Soc. Symp. Vol 616, 9 (2000). "A Parallel Detecting Spectroscopic Ellipsometer for Intelligent Process Control of Continuously Deposited CIGS Films"
21. US patent 6,384,916 Bl, Parallel Detecting, Spectroscopic Ellipsometer/polarimeter (2002).
22. I.L. Repins, B.J. Stanbery, D. L. Young, S.S. Li, W. K. Metzger, C.L. Perkins, W.N. Shafarman, M. E. Beck, L. Chen, V. K. Kapur, D. Tarrant, M.D. Gonzalez, D.G. Jensen, T.J. Anderson, X. Wang, L.L. Kerr, B. Keyes, S. Asher, A. Delahoy, B. Von Reedern, "Comparison of Device Performance and Measured Transport Parameters in Widely-Varying Cu(InGa)(Se,S) Solar Cells," Progress in Photovoltaics, (2005), publication pending.
23. D.G. Jensen, "Correlation Between Modeled and Experimental Device Performance Results for CIGS Solar Cells," IEEE Photovoltaics Specialists Conference Record, 31, 2005.
24. 2 Thin Film Evolution During Growth - A Photoluminescence Study. Conference Record of the IEEE Photovoltaic Specialists Conference 2002: 29: 511-514.
25. Ohnesorge B, Weigand R, Bacher G, Forchel A, Riedl W, Karg FH. Minority-carrier lifetime and efficiency of Cu(In,Ga)Se2 solar cells. Applied Physics Letters 1998; 73(9): 1224-1226.
26. 2-based heterojunction solar cells. Part II. Defect Spectroscopy. Journal of Applied Physics 2000: 87(1): 594-602.
27. J. H. Scofield, S. Asher, D. Albin, J. Tuttle, M. Contreras, D. Niles, R. Reedy A. Tennant, R. Noufi, "Sodium Diffusion, Selenization, and Microstructure Effects Associated with Various Molybdenum Back Contact Layers for CIS Based Solar Cells," Conference Record of the IEEE Photovoltaic Specialists Conference 1994: 24: 167-164.
28. J. L. Alleman, H. Al-Thani, R. Noufi, H. Moutinho, M. M. Al-Jassim, F. Hasoon, "Dependence of the Characteristics of Mo Films on Sputter Conditions", NCPV Program Review Meeting, 2000, pp. 239-240.
29. th IEEE Photovoltaics Specialists Conference, 2000, pp. 638-642.
30. 2 Thin Films," IEEE Photovoltaics Specialists Conference Record, 31, 2005.
31. 2-Based Solar Cells: Processing of Novel Absorber Structures", IEEE Photovoltaic Specialists Conference Record, 24, 1994, pp.68-75.
32. K. Ramanathan, J. Keane, R. Noufi, "Properties of High-Efficiency CIGS Thin-Film Solar Cells," IEEE Photovoltaics Specialists Conference Record, 31, 2005.
33. I.L. Eisgruber, J.R. Engel, R.E. Hollingsworth, P.K. Bhat, R. Wendt, "Intelligent Process Control of Indium Tin Oxide Sputter Deposition Using Optical Emission Spectroscopy", Journal of Vacuum Science and Technology A, 17(1), pp. 190-197, 1999.
34. 2 Solar Cells," IEEE Photovoltaic Specialists Conference Record, 25, 1996.