Acetylene sensor based on Pt/ZnO thick films as prepared by flame spray pyrolysis

Sensors and Actuators, B: Chemical

Volumn 152, Issue 2, 2011, Pages 155-161

  Tamaekong, Nittaya ^a   Liewhiran, Chaikarn ^a   Wisitsoraat, Anurat ^b   Phanichphant, Sukon ^a  

^a CHIANG MAI UNIVERSITY   (Thailand)

^b NATIONAL ELECTRONICS AND COMPUTER TECHNOLOGY CENTER   (Thailand)

Author keywords

Acetylene (C2H 2); Flame spray pyrolysis; Gas sensor; Pt ZnO nanoparticles

Indexed keywords

FLAME CONDITIONS; FLAME SPRAY PYROLYSIS; GAS SENSING; GAS SENSOR; HEXAGONAL PARTICLES; LOW DETECTION LIMIT; OPERATING TEMPERATURE; PARTICLE PROPERTIES; PLATINUM ACETYLACETONATE; PT NANOPARTICLES; PT/ZNO NANOPARTICLES; SEM; SENSING CHARACTERISTICS; SENSING FILMS; SINGLE-STEP; TEM; XRD; ZNO; ZNO NANOPARTICLES; ZNO NANOROD; ZNO PARTICLES;

ACETYLENE; AROMATIC HYDROCARBONS; CARBON FILMS; CARBON MONOXIDE; FLAME SPRAYING; GAS DETECTORS; LIGHTING; METHANE; NANOPARTICLES; NANORODS; PLATINUM; PROTECTIVE COATINGS; SENSORS; SPRAY GUNS; TEMPERATURE; THICK FILMS; XYLENE; ZINC OXIDE;

SPRAY PYROLYSIS;

EID: 79952453662     PISSN: 09254005     EISSN: None     Source Type: Journal    
DOI: 10.1016/j.snb.2010.11.058     Document Type: Article

References (38)

1. S. Choopun, N. Hongsith, P. Mangkorntong, and N. Mangkorntong Zinc oxide nanobelts by RF sputtering for ethanol sensor Physica E 39 2007 53 56 (Pubitemid 46963114)
2. Y. Wang, G. Ouyang, L.L. Wang, L.M. Tang, D.S. Tang, and Q.S. Chang Size- and composition-induced band-gap change of nanostructured compound of II-VI semiconductors Chem. Phys. Lett. 463 2008 383 386
3. C. Liewhiran, S. Seraphin, and S. Phanichphant Synthesis of nano-sized ZnO powders by thermal decomposition of zinc acetate using Broussonetia papyrifera (L.) Vent pulp as a dispersant Curr. Appl. Phys. 6 2006 499 502 (Pubitemid 43817779)
4. C. Liewhiran, and S. Phanichphant Influence of thickness on ethanol sensing characteristics of doctor-bladed thick film from flame-made ZnO nanoparticles Sensors 7 2007 185 201
5. C. Liewhiran, and S. Phanichphant Improvement of flame-made nanoparticulate thick film morphology for ethanol sensing Sensors 7 2007 650 675
6. M. Purica, E. Budianu, E. Rusu, M. Danila, and R. Gavrila Optical and structural investigation of ZnO thin films prepared by chemical vapor deposition (CVD) Thin Solid Films 403-404 2002 485 488 (Pubitemid 34100396)
7. Y. Liu, J. Dong, P.J. Hesketh, and M. Liu Synthesis and gas sensing properties of ZnO single crystal flakes J. Mater. Chem. 15 2005 2316 2320 (Pubitemid 40891945)
8. J. Xu, Y. Chen, Y. Li, and J. Shen Gas sensing properties of ZnO nanorods prepared by hydrothermal method J. Mater. Sci. 40 2005 2919 2921 (Pubitemid 40925002)
9. P. Feng, Q. Wan, and T.H. Wang Contact-controlled sensing properties of flowerlike ZnO nanostructure Appl. Phys. Lett. 87 2005 213111 213113
10. H. Xu, X. Liu, D. Cui, M. Li, and M. Jiang A novel method for improving the performance of ZnO gas sensors Sens. Actuators B: Chem. 114 2006 301 307 (Pubitemid 43276193)
11. A.R. Raju, and C.N.R. Rao Gas-sensing characteristics of ZnO and copperimpregnated ZnO Sens. Actuators B: Chem. 3 1991 305 310
12. B. Baruwati, D.K. Kumar, and S.V. Manorama Hydrothermal synthesis of highly crystalline ZnO nanoparticles: a competitive sensor for LPG and EtOH Sens. Actuators B: Chem. 119 2006 676 682 (Pubitemid 44403043)
13. B.B. Rao Zinc oxide ceramic semi-conductor gas sensor for ethanol vapour Mater. Chem. Phys. 64 2000 62 65 (Pubitemid 30556659)
14. X.L. Cheng, H. Zhao, L.H. Huo, S. Gao, and J.G. Zhao ZnO nanoparticulate thin film: preparation, characterization and gas-sensing property Sens. Actuators B: Chem. 102 2004 248 252
15. X. Zhou, T. Jiang, J. Zhang, X. Wang, and Z. Zhu Humidity sensor based on quartz tuning fork coated with sol-gel-derived nanocrystalline zinc oxide thin film Sens. Actuators B: Chem. 123 2006 299 305 (Pubitemid 46497705)
16. C. Ge, C. Xie, and S. Cai Preparation and gas-sensing properties of Ce-doped ZnO thin film sensors by dip-coating Mater. Sci. Eng. B 137 2007 53 58 (Pubitemid 46205189)
17. C. Xiangfeng, J. Dongli, A.B. Djurišic, and Y.H. Leung Gas-sensing properties of thick film based on ZnO nano-tetrapods Chem. Phys. Lett. 401 2005 426 429 (Pubitemid 40038282)
18. K. Arshak, and I. Gaidan Development of a novel gas sensor based on oxide thick films Mater. Sci. Eng. B 118 2005 44 49 (Pubitemid 40390860)
19. N.J. Dayan, R.N. Karekar, R.C. Aiyer, and S.R. Sainkar Effect of film thickness and curing temperature on the sensitivity of ZnO:Sb thick-film hydrogen sensor J. Mater. Sci. - Mater. Electron. 8 1997 277 279 (Pubitemid 127506279)
20. 3 Jpn. J. Appl. Phys. I 41 2002 4655 4658
21. Y.L. Lee, C.Y. Sheu, and R.H. Hsiao Gas sensing characteristics of copper phthalocyanine films; effects of film thickness and sensing temperature Sens. Actuators B: Chem. 99 2004 281 287
22. F.H. Babari, and M. Orvatinia Analysis of thickness dependence of the sensitivity in thin film resistive gas sensors Sens. Actuators B: Chem. 89 2003 256 261
23. H. Geistlinger Electron theory of thin-film gas sensors Sens. Actuators B: Chem. 17 1993 47 60
24. M.A.R. López, M. Peiteado, J.F. Fernández, A.C. Caballero, J. Holc, S. Drnovsek, D. Kuscer, S. Macek, and M. Kosec Thick film ZnO based varistors prepared by screen printing J. Eur. Ceram. Soc. 26 2006 2985 2989 (Pubitemid 44138657)
25. J.F. Chang, H.H. Kuo, I.C. Leu, and M.H. Hon The effects of thickness and operation temperature on ZnO:Al thin film CO gas sensor Sens. Actuators B: Chem. 84 2002 258 264 (Pubitemid 34704176)
26. S. Christoulakis, M. Suchea, E. Koudoumas, M. Katharakis, N. Katsarakis, and G. Kiriakidis Thickness influence on surface morphology and ozone sensing properties of nanostructured ZnO transparent thin films grown by PLD Appl. Surf. Sci. 252 2006 5351 5354 (Pubitemid 43833383)
27. 2 response on film thickness Sens. Actuators B: Chem. 77 2001 116 121 (Pubitemid 32544340)
28. L. Maedler, H.K. Kammler, R. Mueller, and S.E. Pratsinis Controlled synthesis of nanostructured particles by flame spray pyrolysis J. Aerosol. Sci. 33 2002 369 389 (Pubitemid 33122023)
29. C. Liewhiran, and S. Phanichphant Effects of palladium loading on the response of a thick film flame-made ZnO gas sensor for detection of ethanol vapor Sensors 7 2007 1159 1184
30. P. Pawinrat, O. Mekasuwandumrong, and J. Panpranot Synthesis of Au-ZnO and Pt-ZnO nanocomposites by one-step flame spray pyrolysis and its application for photocatalytic degradation of dyes Catal. Commun. 10 2009 1380 1385
31. J.H. Murray, M. Lutz, and E.P. Sotiris Nanorods of ZnO made by flame spray pyrolysis Chem. Mater. 1 2006 572 578
32. C. Liewhiran, and S. Phanichphant Doctor-bladed thick films of flame-made Pd/ZnO nanoparticles for ethanol sensing Curr. Appl. Phys. 8 2008 336 339 (Pubitemid 351172973)
33. E.H. Kisi, and M.M. Elcombe Parameters for the wurtzite structure of ZnS and ZnO using powderneutron diffraction Acta Crystallogr. Sect. C: Cryst. Struct. Commun. 45 1989 1867 1870
34. 3) powders Mod. Phys. Lett. B 11 1997 1169 1174 (Pubitemid 127467862)
35. H.E. Swanson, and E. Tatge Standard X-ray diffraction powder patterns. National Bureau of Standards 1953, 359, 1-1 Z. Angew. Phys. 8 1956 202 205
36. S.R. Morrison Selectivity in semiconductor gas sensors Sens. Actuator B: Chem. 12 1987 425 440
37. 2 surface as selective gas sensors Thin Solid Films 272 1996 15 17 (Pubitemid 126366625)
38. 2 films with Pd and PdO deposits Sens. Actuators 17 1989 355 359