Measurement of the temperature non-uniformity in a microchannel heat sink using microscale laser-induced fluorescence

International Journal of Heat and Mass Transfer

Volumn 53, Issue 15-16, 2010, Pages 3275-3283

  Chamarthy, Pramod ^a   Garimella, Suresh V ^a   Wereley, Steven T ^a  

^a PURDUE UNIVERSITY   (United States)

Author keywords

Laser induced fluorescence thermometry; Microchannel heat sink; Microfluidics; Non intrusive temperature measurement; Temperature dependent dyes

Indexed keywords

LASER INDUCED FLUORESCENCE; MICRO CHANNEL HEAT SINKS; MICROCHANNEL HEAT SINK; NON-INTRUSIVE; NON-INTRUSIVE TEMPERATURE MEASUREMENT; TEMPERATURE DEPENDENT;

FLUORESCENCE; HEAT SINKS; LASER OPTICS; MICROCHANNELS; MICROFLUIDICS; TEMPERATURE MEASUREMENT; TEMPERATURE SENSORS; THERMOMETERS; UNCERTAINTY ANALYSIS; VISUALIZATION;

MEASUREMENTS;

EID: 77953294022     PISSN: 00179310     EISSN: None     Source Type: Journal    
DOI: 10.1016/j.ijheatmasstransfer.2010.02.052     Document Type: Article

References (43)

1. Wang P., and Bar-Cohen A. On-chip hot spot cooling using silicon thermoelectric microcoolers. J. Appl. Phys. 102 3 (2007) 034503
2. Kandlikar S.G., and Bapat A.V. Evaluation of jet impingement, spray and microchannel chip cooling options for high heat flux removal. Heat Transfer Eng. 28 11 (2007) 911-923
3. Garimella S.V. Advances in mesoscale thermal management technologies for microelectronics. Microelectron. J. 37 11 (2006) 1165-1185
4. Tuckerman D.B., and Pease R.F.W. High-performance heat sinking for VLSI. Electron Device Lett. 2 5 (1981) 126-129
5. Sobhan C.B., and Garimella S.V. A comparative analysis of studies on heat transfer and fluid flow in microchannels. Microscale Thermophys. Eng. 5 4 (2001) 293-311
6. Garimella S.V., and Sobhan C.B. Transport in microchannels - a critical review. Ann. Rev. Heat Transfer 13 (2003) 1-50 [Chapter 1]
7. Lee P.S., Garimella S.V., and Liu D. Investigation of heat transfer in rectangular microchannels. Int. J. Heat Mass Transfer 48 9 (2005) 1688-1704
8. Liu D., Lee P.S., and Garimella S.V. Nucleate boiling in microchannels. J. Heat Transfer Trans. ASME 127 8 (2005) 803
9. Jang S.P., Kim S.J., and Paik K.W. Experimental investigation of thermal characteristics for a microchannel heat sink subject to an impinging jet, using a micro-thermal sensor array. Sensors Actuators A Phys. 105 2 (2003) 211-224
10. Lee P.-S., and Garimella S.V. Saturated flow boiling heat transfer and pressure drop in silicon microchannel arrays. Int. J. Heat Mass Transfer 51 3-4 (2000) 789-806
11. Chen T., and Garimella S.V. Measurements and high-speed visualizations of flow boiling of a dielectric fluid in a silicon microchannel heat sink. Int. J. Multiph. Flow 32 8 (2006) 957-971
12. Harirchian T., and Garimella S.V. Microchannel size effects on local flow boiling heat transfer to a dielectric fluid. Int. J. Heat Mass Transfer 51 15-16 (2008) 3724-3735
13. Jiang L.N., Wang Y.L., Wong M., and Zohar Y. Fabrication and characterization of a microsystem for a micro-scale heat transfer study. J. Micromech. Microeng. 9 4 (1999) 422-428
14. Sammarco T.S., and Burns M.A. Thermocapillary pumping of discrete drops in microfabricated analysis devices. AIChE J. 45 2 (1999) 350-366
15. Tsai J.H., and Lin L.W. Transient thermal bubble formation on polysilicon micro-resisters. ASME J. Heat Transfer 124 2 (2002) 375-382
16. Nozaki T., Mochizuki T., Kaji N., and Mori Y.H. Application of liquid-crystal thermometry to drop temperature measurements. Exp. Fluids 18 3 (1995) 137-144
17. Richards C.D., and Richards R.F. Transient temperature measurements in a convectively cooled droplet. Exp. Fluids 25 5-6 (1998) 392-400
18. Hetsroni G., Gurevich M., Mosyak A., Pogrebnyak E., Rozenblit R., and Yarin L.P. Boiling in capillary tubes. Int. J. Multiph. Flow 29 10 (2003) 1551-1563
19. Hetsroni G., Mosyak A., and Segal Z. Nonuniform temperature distribution in electronic devices cooled by flow in parallel microchannels. IEEE Trans. Component Packaging Technol. 24 1 (2001) 16-23
20. Hetsroni G., Rozenblit R., and Yarin L.P. A hot-foil infrared technique for studying the temperature field of a wall. Meas. Sci. Technol. 7 10 (1996) 1418-1427
21. Buffone C., and Sefiane K. IR measurements of interfacial temperature during phase change in a confined environment. Exp. Thermal Fluid Sci. 29 1 (2004) 65-74
22. Dhavaleswarapu H., Garimella S.V., and Murthy J.Y. Microscale temperature measurements near the triple line of an evaporating thin liquid film. ASME J. Heat Transfer 131 (2009) 061501
23. Koochesfahani M. Special feature: molecular tagging velocimetry. Meas. Sci. Technol. 11 9 (2000) 1235-1300
24. Hu H., Koochesfahani M., and Lum C. Molecular tagging thermometry with adjustable temperature sensitivity. Exp. Fluids 40 5 (2006) 753-763
25. Thomsen S.L., and Maynes D. Spatially resolved temperature measurements in a liquid using laser induced phosphorescence. ASME J. Fluids Eng. 123 2 (2001) 293-302
26. Goss L.P., Smith A.A., and Post M.E. Surface thermometry by laser-induced fluorescence. Rev. Sci. Instrum. 60 12 (1989) 3702-3706
27. Chan C., and Daily J.W. Measurement of temperature in flames using laser-induced fluorescence spectroscopy of OH. Appl. Optics 19 12 (1980) 1963-1968
28. Omenetto N., Benetti P., and Rossi G. Flame temperature measurements by means of atomic fluorescence spectrometry. Spectrochim. Acta B At. Spectrosc. B 27 10 (1972) 453
29. Hishida K., and Sakakibara J. Combined planar laser-induced fluorescence-particle image velocimetry technique for velocity and temperature fields. Exp. Fluids 29 (2000) S129-S140
30. Lavieille P., Lemoine F., Lavergne G., Virepinte J.F., and Lebouche M. Temperature measurements on droplets in monodisperse stream using laser-induced fluorescence. Exp. Fluids 29 5 (2000) 429-437
31. Sakakibara J., Hishida K., and Maeda M. Measurements of thermally stratified pipe-flow using image-processing techniques. Exp. Fluids 16 2 (1993) 82-96
32. Lavieille P., Lemoine F., Lavergne G., and Lebouche M. Evaporating and combusting droplet temperature measurements using two-color laser-induced fluorescence. Exp. Fluids 31 1 (2001) 45-55
33. Coolen M.C.J., Kieft R.N., Rindt C.C.M., and van Steenhoven A.A. Application of 2-D LIF temperature measurements in water using a Nd:YAG laser. Exp. Fluids 27 5 (1999) 420-426
34. Sakakibara J., and Adrian R.J. Whole field measurement of temperature in water using two-color laser induced fluorescence. Exp. Fluids 26 1-2 (1999) 7-15
35. Lavieille P., Delconte A., Blondel D., Lebouche M., and Lemoine F. Non-intrusive temperature measurements using three-color laser-induced fluorescence. Exp. Fluids 36 5 (2004) 706-716
36. Coppeta J., and Rogers C. Dual emission laser induced fluorescence for direct planar scalar behavior measurements. Exp. Fluids 25 1 (1998) 1-15
37. Kim H.J., Kihm K.D., and Allen J.S. Examination of ratiometric laser induced fluorescence thermometry for microscale spatial measurement resolution. Int. J. Heat Mass Transfer 46 21 (2003) 3967-3974
38. Kim H.J., and Kihm K.D. Two-color (Rh-B & Rh-110) laser induced fluorescence (LIF) thermometry with sub-millimeter measurement resolution. ASME J. Heat Transfer 124 4 (2002) 596
39. Ross D., Gaitan M., and Locascio L.E. Temperature measurement in microfluidic systems using a temperature-dependent fluorescent dye. Anal. Chem. 73 17 (2001) 4117-4123
40. Guilbault G.G. Practical Fluorescence; Theory, Methods, and Techniques (1973), M. Dekker, New York vol. xi, 664 p.
41. B.J. Jones, S.V. Garimella, Infrared micro-particle image velocimetry in a silicon microchannel heat sink, in: 13th International Heat Transfer Conference EXP-07, Sydney, Australia, 2006.
42. P.S. Lee, Heat transport in silicon microchannel arrays, in: Department of Mechanical Engineering, Purdue University, West Lafayette, 2007.
43. Jones B.J., Lee P.S., and Garimella S.V. Infrared micro-particle image velocimetry measurements and predictions of flow distribution in a microchannel heat sink. Int. J. Heat Mass Transfer 51 7-8 (2008) 1877-1887