Modeling and control of the PFC stage for a 50KW EV fast battery charger

Proceedings of the World Congress on Engineering 2011, WCE 2011

Volumn 2, Issue , 2011, Pages 1348-1352

  Kuperman, A ^a   Levy, U ^b   Goren, J ^b   Zafranski, A ^b   Savernin, A ^b  

^a ARIEL UNIVERSITY   (Israel)

^b Gamatronic Electronic Industries Ltd   (Israel)

Author keywords

Active power filter; Analog control; Electric vehicle; Power factor correction

Indexed keywords

ACTIVE POWER FILTER; ANALOG CONTROLS; BATTERY CHARGERS; CONSTANT POWER LOAD; CONTROL CIRCUITRY; CONTROL LOOP; CONTROLLED RECTIFIER; ELECTRONIC INDUSTRIES; FULL BRIDGE RECTIFIER; GRID CODES; MODELING AND CONTROL; OUTPUT STAGES; POWER FACTOR CORRECTIONS; POWER FACTORS; POWER FILTERS; SINGLE STAGE; THREE PHASE; TWO STAGE;

ANALOG CIRCUITS; BRIDGE CIRCUITS; DC POWER TRANSMISSION; DC-DC CONVERTERS; ELECTRIC LOAD FORECASTING; ELECTRIC POWER FACTOR CORRECTION; ELECTRIC RECTIFIERS; ELECTRIC VEHICLES;

ACTIVE FILTERS;

EID: 80755156260     PISSN: None     EISSN: None     Source Type: Conference Proceeding    
DOI: None     Document Type: Conference Paper

References (36)

1. B. Kennedy, D. Patterson and S. Camilleri, "Use of lithium-ion batteries in electric vehicles," J. Pow. Sources, vol. 90, pp. 156 - 162, 2000.
2. R. Gitzendanner, F. Puglia, C. Martin, D. Carmen, E. Jones and S. Eaves, "High power and high energy lithium-ion batteries for underwater vehicles," J. Pow. Sources, vol. 136, pp. 416 - 418, 2004.
3. G-C. Hsieh, L-R. Chen and K-S. Huang, "Fuzzy-controlled Li-Ion battery charge system with active state-of-charge controller," IEEE Trans. Ind. Elec., vol. 48(3), pp. 585 - 593, 2001.
4. M. Chen and G. Rincon-Mora, "Accurate, compact, and powerefficient Li-Ion battery charger circuit," IEEE Trans. Circ. Sys. II: Expr. Briefs, vol. 53(11), pp. 1180 - 1184, 2006. (Pubitemid 44824330)
5. K. Tsang and W. Chan, "A simple and low-cost charger for lithiumion batteries," J. Pow. Sources, vol. 191, pp. 633 - 635, 2009.
6. J-J Chen, F-C. Yang, C-C. Lai, Y-S. Hwang and R-G. Lee, "A highefficiency multimode Li-Ion battery charger with variable current source and controlling previous stage supply voltage," IEEE Trans. Ind. Elec., vol. 56(7), pp. 2469 - 2478, 2009.
7. D. Thimmesch, "An SCR inverter with an integral battery charger for electric vehicles," IEEE Trans. Ind. Appl., vol. IA-21(4), pp. 1023 -1029, 1985. (Pubitemid 16479570)
8. J. Bendien, G. Fregien and J. van Wyk, "High-efficiency on-board battery charger with transformer isolation, sinusoidal input current and maximum power factor," IEE Proc. B, vol. 133(4), pp. 197 - 204, 1986. (Pubitemid 16591938)
9. S-K. Sul and S-J. Lee, "An integral battery charger for four-wheel drive electric vehicle," IEEE Trans. Ind. Appl., vol. IA-21(4), pp. 1023 - 1029, 1995.
10. B. Masserant and T. Stuart, "A maximum power transfer battery charger for electric vehicles," IEEE Trans. Aerosp. Elec. Sys., vol. 33(3), pp. 930 - 938, 1997. (Pubitemid 127762801)
11. D. Jackson, A. Schultz, S. Leeb, A. Mitwalli, G. Verghese and S. Shaw, "A multirate digital controller for a 1.5KW electric vehicle battery charger," IEEE Trans. Pow. Elec., vol. 12(6), pp. 1000 - 1006, 1997. (Pubitemid 127765100)
12. L. Solero, "Nonconventional on-board charger for electric vehicle propulsion batteries," IEEE Trans. Veh. Tech., vol. 50(1), pp. 144 -149, 2001. (Pubitemid 32444223)
13. M. Egan, D. O'Sullivan, J. Hayes, M. Willers and C. Henze, "Powerfactor-corrected single-stage inductive charger for electric vehicle batteries," IEEE Trans. Ind. Elec., vol. 54(2), pp. 1217 - 1226, 2007. (Pubitemid 46591042)
14. G. Pellegrino, E. Armando and P. Guglielmi, "An integral battery charger with power factor correction for electric scooter," IEEE Trans. Pow. Elec., vol. 25(3), pp. 751 - 759, 2010.
15. N. Kutkut, D. Divan, D. Novotny and R. Marion, "Design considerations and topology selection for a 120KW IGBT converter for EV fast charging," IEEE Trans. Pow. Elec., vol. 13(1), pp. 169 -178, 1998. (Pubitemid 128742345)
16. C-H. Lin, C-Y. Hsieh and K-H. Chen, "A Li-Ion battery charger with smooth control circuit and built-in resistance compensator for achieving stable and fast charging," IEEE Trans. Circ. Sys. I: Reg. Pap., vol. 57(2), pp. 506 - 517, 2010.
17. J. Orr, A. Emanuel and K. Oberg, "Current harmonics generated by a cluster of electric vehicle battery chargers," IEEE Trans. PAS, vol. PAS-101(3), pp. 691 - 700, 1982.
18. J. Orr, A. Emanuel and D. Pileggi, "Current harmonics, voltage distortion and powers associated with battery chargers," IEEE Trans. PAS, vol. PAS-101(8), pp. 2703 - 2710, 1982.
19. J. Orr, A. Emanuel and D. Pileggi, "Current harmonics, voltage distortion and powers associated with battery chargers distributed on the residential power system," IEEE Trans. Ind. Appl., vol. IA-20(4), pp. 727 - 734, 1984. (Pubitemid 14649250)
20. S. Rahman and G. Shrestha, "An investigation into the impact of electric vehicle load on the electric utility distribution system," IEEE Trans. Pow. Del., vol. 8(2), pp. 591 - 597, 1993. (Pubitemid 23680137)
21. P. Staats, W. Grady, A. Arapostathis and R. Thallam, "A statistical method for predicting the net harmonic currents generated by a concentration of electric vehicle battery chargers," IEEE Trans. Pow. Del., vol. 12(3), pp. 1258 - 1266, 1997.
22. P. Staats, W. Grady, A. Arapostathis and R. Thallam, "A statistical analysis of the effect of electric vehicle battery charging on distribution system harmonic voltages," IEEE Trans. Pow. Del., vol. 13(2), pp. 640 - 646, 1998.
23. J. Gomez and M. Morcos, "Impact of EV battery chargers on the power quality of distribution systems," IEEE Trans. Pow. Del., vol. 18(3), pp. 975 - 981, 2003.
24. G. Gong, M. Heldwein, U. Drofenik, J. Minibock, K. Mino and J. Kolar, "Comparative evaluation of three-phase high-power-factor ACDC converter concepts for application in future more electric aircraft," IEEE Trans. Ind. Elec., vol. 52(3), pp. 727 - 737, 2005. (Pubitemid 40871109)
25. B-R. Lin and T-Y. Yang, "Three-phase AC/DC converter with high power factor," IEE Proc. Electr. Power Appl., vol. 152(3), pp. 757 -764, 2005. (Pubitemid 40718438)
26. M. Hartmann, S. Round, H. Ertl and J. Kolar, "Digital current controller for a 1MHz, 10KW three-phase VIENNA rectifier," IEEE Trans. Pow. Elec., vol. 24(11), pp. 2496 - 2508, 2009.
27. K. Raggl, T. Nussbaumer, G. Doerig, J. Biela and J. Kolar, "Comprehensive design and optimization of a high-power-density single-phase boost PFC," IEEE Trans. Ind. Elec., vol. 56(7), pp. 2574- 2587, 2009.
28. J. Hahn, P. Enjeti and I. Pitel, "A new three phase power factor correction (PFC) scheme using two single phase PFC modules," IEEE Trans. Ind. Appl., vol. 38(1), pp. 123 - 130, 2002. (Pubitemid 34491226)
29. H. Akagi, A. Nabae and S. Atoh, "Control strategy of active power filters using multiple voltage source PWM converters," IEEE Trans. Ind. Appl., vol. IA-22(3), pp. 460 - 465, 1986. (Pubitemid 16614280)
30. J. Nastran, R. Cajhen, M. Seliger and P. Jereb, "Active power filter for nonlinear AC loads," IEEE Trans. Pow. Elec., vol. 9(1), pp. 92 -96, 1994.
31. D. Pedder, A. Brown, J. Ross and A. Williams, "A parallel-connected active filter for the reduction of supply current distortion," IEEE Trans. Ind. Elec., vol. 47(5), pp. 1108 - 1117, 2000.
32. S. Kim, M. Todorovic and P. Enjeti, "Three-phase active harmonic rectifier (AHR) to improve utility input current THD in telecommunication power distribution system," IEEE Trans. Ind. Appl., vol. 39(5), pp. 1414 - 1421, 2003.
33. H-L. Jou, J-C. Wu and H-Y. Chu, "New single-phase active power filter," IEE Proc. Electr. Pow. Appl., vol. 141(3), pp.129 - 134, 1994.
34. C. Hsu and H. Wu, "A new single-phase active power filter with reduced energy-storage capacity," IEE Proc. Electr. Pow. Appl., vol. 143(1), pp. 25 - 30, 1996. (Pubitemid 126759816)
35. H. Komurcugil and O. Kukrer, "A new control strategy for single phase shunt active power filters using a Lyapunov function," IEEE Trans. Ind. Elec., vol. 53(1), pp. 305 - 312, 2006. (Pubitemid 43245298)
36. th IEEE Convention in Israel, Eilat, Israel, 2010.