Modeling and control of a 50KW electric vehicle fast charger

2010 IEEE 26th Convention of Electrical and Electronics Engineers in Israel, IEEEI 2010

Volumn , Issue , 2010, Pages 188-192

  Kuperman, Alon ^a   Levy, Udi ^b   Goren, Joseph ^b   Zafranski, Aryeh ^b   Savernin, Alex ^b   Peled, Ilan ^c  

^a ARIEL UNIVERSITY   (Israel)

^b Gamatronic Electronic Industries Ltd   (Israel)

^c Better Place Inc   (Israel)

Author keywords

[No Author keywords available]

Indexed keywords

ACTIVE POWER FILTER; BATTERY MANAGEMENT SYSTEM; CONSTANT CURRENT AND CONSTANT VOLTAGES; CONTROL CIRCUITRY; CONTROL LOOP; CONTROLLED RECTIFIER; DC CONTROL; ELECTRONIC INDUSTRIES; FULL BRIDGE RECTIFIER; GRID CODES; INDEPENDENT CONTROL; INPUT AND OUTPUTS; MODELING AND CONTROL; OUTPUT STAGES; POWER FACTORS; POWER FILTERS; SINGLE STAGE; THREE PHASE; TWO STAGE; VEHICLE BATTERY;

AUTOMOBILE ELECTRONIC EQUIPMENT; AUTOMOBILES; BRIDGE CIRCUITS; DC POWER TRANSMISSION; DC-DC CONVERTERS; ELECTRIC POWER FACTOR; ELECTRIC RECTIFIERS; ELECTRIC VEHICLES; ENGINEERS;

ACTIVE FILTERS;

EID: 78651252157     PISSN: None     EISSN: None     Source Type: Conference Proceeding    
DOI: 10.1109/EEEI.2010.5661955     Document Type: Conference Paper

References (37)

1. B. Kennedy, D. Patterson and S. Camilleri, "Use of lithium-ion batteries in electric vehicles," J. Pow. Sources, vol. 90, pp. 156-162, 2000.
2. R. Gitzendanner, F. Puglia, C. Martin, D. Carmen, E. Jones and S. Eaves, "High power and high energy lithium-ion batteries for underwater vehicles," J. Pow. Sources, vol. 136, pp. 416-418, 2004.
3. G-C. Hsieh, L-R. Chen and K-S. Huang, "Fuzzy-controlled Li-Ion battery charge system with active state-of-charge controller," IEEE Trans. Ind. Elec., vol. 48(3), pp. 585-593, 2001.
4. M. Chen and G. Rincon-Mora, "Accurate, compact, and power-efficient Li-Ion battery charger circuit," IEEE Trans. Circ. Sys. II: Expr. Briefs, vol. 53(11), pp. 1180-1184, 2006.
5. K. Tsang and W. Chan, "A simple and low-cost charger for lithium-ion batteries," J. Pow. Sources, vol. 191, pp. 633-635, 2009.
6. J-J Chen, F-C. Yang, C-C. Lai, Y-S. Hwang and R-G. Lee, "A high-efficiency multimode Li-Ion battery charger with variable current source and controlling previous stage supply voltage," IEEE Trans. Ind. Elec., vol. 56(7), pp. 2469-2478, 2009.
7. D. Thimmesch, "An SCR inverter with an integral battery charger for electric vehicles," IEEE Trans. Ind. Appl., vol. IA-21(4), pp. 1023-1029, 1985.
8. J. Bendien, G. Fregien and J. van Wyk, "High-efficiency on-board battery charger with transformer isolation, sinusoidal input current and maximum power factor," IEE Proc. B, vol. 133(4), pp. 197-204, 1986.
9. S-K. Sul and S-J. Lee, "An integral battery charger for four-wheel drive electric vehicle," IEEE Trans. Ind. Appl., vol. IA-21(4), pp. 1023-1029, 1995.
10. B. Masserant and T. Stuart, "A maximum power transfer battery charger for electric vehicles," IEEE Trans. Aerosp. Elec. Sys., vol. 33(3), pp. 930-938, 1997.
11. D. Jackson, A. Schultz, S. Leeb, A. Mitwalli, G. Verghese and S. Shaw, "A multirate digital controller for a 1.5KW electric vehicle battery charger," IEEE Trans. Pow. Elec., vol. 12(6), pp. 1000-1006, 1997.
12. L. Solero, "Nonconventional on-board charger for electric vehicle propulsion batteries," IEEE Trans. Veh. Tech., vol. 50(1), pp. 144-149, 2001.
13. M. Egan, D. O'Sullivan, J. Hayes, M. Willers and C. Henze, "Power-factor-corrected single-stage inductive charger for electric vehicle batteries," IEEE Trans. Ind. Elec., vol. 54(2), pp. 1217-1226, 2007.
14. G. Pellegrino, E. Armando and P. Guglielmi, "An integral battery charger with power factor correction for electric scooter," IEEE Trans. Pow. Elec., vol. 25(3), pp. 751-759, 2010.
15. N. Kutkut, D. Divan, D. Novotny and R. Marion, "Design considerations and topology selection for a 120KW IGBT converter for EV fast charging," IEEE Trans. Pow. Elec., vol. 13(1), pp. 169-178, 1998.
16. C-H. Lin, C-Y. Hsieh and K-H. Chen, "A Li-Ion battery charger with smooth control circuit and built-in resistance compensator for achieving stable and fast charging," IEEE Trans. Circ. Sys. I: Reg. Pap., vol. 57(2), pp. 506-517, 2010.
17. J. Orr, A. Emanuel and K. Oberg, "Current harmonics generated by a cluster of electric vehicle battery chargers," IEEE Trans. PAS, vol. PAS-101(3), pp. 691-700, 1982.
18. J. Orr, A. Emanuel and D. Pileggi, "Current harmonics, voltage distortion and powers associated with battery chargers," IEEE Trans. PAS, vol. PAS-101(8), pp. 2703-2710, 1982.
19. J. Orr, A. Emanuel and D. Pileggi, "Current harmonics, voltage distortion and powers associated with battery chargers distributed on the residential power system," IEEE Trans. Ind. Appl.,, vol. IA-20(4), pp. 727-734, 1984.
20. S. Rahman and G. Shrestha, "An investigation into the impact of electric vehicle load on the electric utility distribution system," IEEE Trans. Pow. Del., vol. 8(2), pp. 591-597, 1993.
21. P. Staats, W. Grady, A. Arapostathis and R. Thallam, "A statistical method for predicting the net harmonic currents generated by a concentration of electric vehicle battery chargers," IEEE Trans. Pow. Del., vol. 12(3), pp. 1258-1266, 1997.
22. P. Staats, W. Grady, A. Arapostathis and R. Thallam, "A statistical analysis of the effect of electric vehicle battery charging on distribution system harmonic voltages," IEEE Trans. Pow. Del., vol. 13(2), pp. 640-646, 1998.
23. J. Gomez and M. Morcos, "Impact of EV battery chargers on the power quality of distribution systems," IEEE Trans. Pow. Del., vol. 18(3), pp. 975-981, 2003.
24. G. Gong, M. Heldwein, U. Drofenik, J. Minibock, K. Mino and J. Kolar, "Comparative evaluation of three-phase high-power-factor AC-DC converter concepts for application in future more electric aircraft," IEEE Trans. Ind. Elec., vol. 52(3), pp. 727-737, 2005.
25. B-R. Lin and T-Y. Yang, "Three-phase AC/DC converter with high power factor," IEE Proc. Electr. Power Appl., vol. 152(3), pp. 757-764, 2005.
26. M. Hartmann, S. Round, H. Ertl and J. Kolar, "Digital current controller for a 1MHz, 10KW three-phase VIENNA rectifier," IEEE Trans. Pow. Elec., vol. 24(11), pp. 2496-2508, 2009.
27. K. Raggl, T. Nussbaumer, G. Doerig, J. Biela and J. Kolar, "Comprehensive design and optimization of a high-power-density single-phase boost PFC," IEEE Trans. Ind. Elec., vol. 56(7), pp. 2574-2587, 2009.
28. J. Hahn, P. Enjeti and I. Pitel, "A new three phase power factor correction (PFC) scheme using two single phase PFC modules," IEEE Trans. Ind. Appl., vol. 38(1), pp. 123-130, 2002.
29. H. Akagi , A. Nabae and S. Atoh, "Control strategy of active power filters using multiple voltage source PWM converters," IEEE Trans. Ind. Appl., vol. IA-22(3), pp. 460-465, 1986.
30. J. Nastran, R. Cajhen, M. Seliger and P. Jereb, "Active power filter for nonlinear AC loads," IEEE Trans. Pow. Elec., vol. 9(1), pp. 92-96, 1994.
31. D. Pedder, A. Brown, J. Ross and A. Williams, "A parallel-connected active filter for the reduction of supply current distortion," IEEE Trans. Ind. Elec., vol. 47(5), pp. 1108-1117, 2000.
32. S. Kim, M. Todorovic and P. Enjeti, "Three-phase active harmonic rectifier (AHR) to improve utility input current THD in telecommunication power distribution system," IEEE Trans. Ind. Appl., vol. 39(5), pp. 1414-1421, 2003.
33. H-L. Jou, J-C. Wu and H-Y. Chu, "New single-phase active power filter," IEE Proc. Electr. Pow. Appl., vol. 141(3), pp.129-134, 1994.
34. C. Hsu and H. Wu, "A new single-phase active power filter with reduced energy-storage capacity," IEE Proc. Electr. Pow. Appl., vol. 143(1), pp. 25-30, 1996.
35. H. Komurcugil and O. Kukrer, "A new control strategy for single phase shunt active power filters using a Lyapunov function," IEEE Trans. Ind. Elec., vol. 53(1), pp. 305-312, 2006.
36. C. Chang and M. Knights, "Interleaving technique in distributed power conversion systems," IEEE Trans. Circ. Sys. I: Fund. Theory Appl., vol. 42(5), pp. 245-251, 1995.
37. D. Perreault and J. Kassakian, "Distributed interleaving of paralleled power converters," IEEE Trans. Circ. Sys. I: Fund. Theory Appl., vol. 44(8), pp. 728-734, 1997.