Numerical simulation of roughness effects on flow and heat transfer in microchannels at slip flow regime

International Communications in Heat and Mass Transfer

Volumn 36, Issue 1, 2009, Pages 69-77

  Khadem, M H ^a   Shams, M ^a   Hossainpour, S ^b  

^a K N TOOSI UNIVERSITY OF TECHNOLOGY   (Iran)

^b SAHAND UNIVERSITY OF TECHNOLOGY   (Iran)

Author keywords

Microchannel; Poiseuille number; Relative roughness; Slip flow

Indexed keywords

COMPUTER SIMULATION; FLOW OF FLUIDS; FLOW OF WATER; FLOW SIMULATION; HEAT EXCHANGERS; HEAT TRANSFER; MATHEMATICAL MODELS; NUSSELT NUMBER; THERMOANALYSIS; TRACE ELEMENTS;

FLUID FLOWS; FRICTION FACTORS; KNUDSEN NUMBERS; MICROELEMENTS; NEGATIVE INFLUENCES; NUMERICAL RESULTS; NUMERICAL SIMULATIONS; ON FLOWS; POISEUILLE NUMBER; RELATIVE ROUGHNESS; ROUGHNESS DISTRIBUTIONS; ROUGHNESS EFFECTS; SLIP FLOW; SLIP FLOW REGIMES; TEMPERATURE JUMPS; WALL ROUGHNESSES; WALL SURFACES;

MICROCHANNELS;

EID: 58149131194     PISSN: 07351933     EISSN: None     Source Type: Journal    
DOI: 10.1016/j.icheatmasstransfer.2008.10.009     Document Type: Article

References (30)

1. Ji Y., Yuan K., and Chung J.N. Numerical simulation of wall roughness on gaseous flow and heat transfer in a microchannel. Int. J. Heat Mass Transfer 49 (2006) 1329-1339
2. Kandlikar S.G., Joshi S., and Tian S. Effect of channel roughness on heat transfer and fluid flow characteristics at low Reynolds numbers in small diameter tubes. Proceedings of NHTC_01 35th National Heat Transfer Conference, Anaheim, CA (June 2001) 1-10
3. Mala G.M., and Li D. Flow characteristics of water in microtubes. Int. J. Heat Mass Transfer 20 (1999) 142-148
4. Wu P.Y., and Little W.A. Measurement of friction factor for the flow of gases in very fine channels used for microminiature Joule-Thomson refrigerator. Cryogenics 23 (1983) 273-277
5. Wu P.Y., and Little W.A. Measurement of the heat transfer characteristics of gas flow in fine channel heat exchangers used for microminiature refrigerators. Cryogenics 24 (1984) 415-420
6. S.B. Choi, R.F. Barron, and R.O. Warrington, Fluid Flow and Heat Transfer in Microtubes.
7. Usami M., Fujimoto T., and Kato S. Mass-flow reduction of rarefied flow roughness of a slit surface. Trans. Jpn. Soc. Mech. Eng., B 54 (1988) 1042-1050
8. Sun H., and Faghri M. Effect of surface roughness on nitrogen flow in a microchannel using the direct simulation Monte Carlo method, umer. Heat Transfer Part A 43 (2003) 1-8
9. Karniadakis G.E., and Beskok A. Micro Flows, Fundamental and emulation (2002), Springer, Berlin
10. Croce G., and D' Agaro P. Numerical analysis of roughness effects on microtubes heat transfer. Superlattices Microdt. 35 (2004) 601-616
11. Croce G., and D' Agaro P. Numerical analysis of roughness effects on microchannel heat transfer and pressure drop in laminar flow. J. Phys. D 38 (2005) 1518-1530
12. Mala G.M., and Li D. Flow characteristics of water in microtubes. Int. J. Heat and fluid flow 20 (1998) 142-148
13. Kleinstreuer C., and Koo J. Computational analysis of water roughness effects for liquid flow in micro-conduit. ASME J. Fluid Eng. 126 (2004) 1-9
14. Koo J., and Kleistreure C. Analysis of surface roughness effect on heat transfer in micro-coduit. Int. J. Heat and Mass Transfer 48 (2005) 2625-2634
15. Rawool A.S., Mitra S.K., and Kandlikar S.G. Numerical simulation of flow through microchannels with designed roughness. Microfluid Nanofluid 2 (2006) 215-221
16. Hu Y., Werner C., and Li D. Influence of three dimensional roughness on pressure driven flow through microchannels. ASME J. Fluid Eng. 125 (2003) 871-879
17. Turner E., Sun H., Faghri M., and Gregory O.J. Effect of surface roughness on gaseous flow through micro channels, 2000 IMECE, TD 366 (2) (2000) 291-298
18. Sugiyama W., Sawada T., and Nakamori K. Rarefied gas flow between two flat plates with two dimensional surface roughness. Vacuum 47 (1996) 791-794
19. Sugiyama, Sawada T., Yabuki M., and Chiba Y. Effects of surface roughness on gas flow conductance in channels estimated by conical roughness model. Appl. Surf. Sci. 169-170 (2001) 787-791
20. Valses R., Miana J., Pelegay L., Nunez L., and Putz T. Numerical investigation of the influence of roughness on the laminar incompressible fluid flow through annular microchannels. Int. J. Heat Mass Transfer 50 (2007) 1865-1878
21. Ji Y., Yuan K., and Chung J.N. Numerical simulation of wall roughness on gaseous flow and heat transfer in a microchannel. Int. J. Heat Mass Transfer 49 (2006) 1329-1339
22. Hyung-il C., Dong-ho L., and Dohyung L. 'Complex microscale flow simulations using Langmuir slip condition'. Numer. Heat Transf., Part A: Appl. 48 5 (2005) 407-425
23. Beskok A., and Karniadakis G.E. A model for flows in channels, pipes and ducts at micro and nanoscales. Microscale Thermophys. Eng. 3 (1999) 43-77
24. Porodnov B.T., Suetin P.E., Borisov S.F., and Akinshin V.D. Experimental investigation of rarefied gas flow in different channels. J. Fluid Mech. 64 (1974) 417-437
25. Arkilic E.B., Breuer K., and Schmidt M.A. Gaseous slip flow in long micro-channels. J. MicroElectroMech. Syst. 6 (1997) 167
26. Maurer J., Tabeling P., Joseph P., and Willaime H. Second-order slip laws in micro-channels for helium and nitrogen. Phys. Fluids 15 (2003) 2613-2621
27. Colin S., Lalonde P., and Caen R. Validation of second order slip flow model in rectangular microchannels. Heat Transfer Eng. 25 3 (2004) 23-30
28. Ewart T., Perrier P., Graur I., and Gilbert J. Tangential momemtum accommodation in microtube. Microfluid Nanofluid 3 (2007) 689-695
29. Beskok A., and Karniadakis G.E. A model for flows in channels, pipes and ducts at micro and nanoscales. Microscale Thermophys. Eng. 3 (1999) 43-77
30. Hadjiconstantinou N.G., and Simek O. Constant-wall-temperature Nusselt number in micro and nano-channels. ASME J. Heat Transfer 124 (2002) 356-364