Effect of various sonication modes on permeation flux in cross flow ultrafiltration membrane

Journal of Environmental Chemical Engineering

Volumn 2, Issue 4, 2014, Pages 2289-2294

  Hashemi Shahraki, Masoud ^a   Maskooki, Abdolmajid ^a   Faezian, Ali ^a  

^a RESEARCH INSTITUTE OF FOOD SCIENCE AND TECHNOLOGY RIFST   (Iran)

Author keywords

Flat sheet membrane; Fouling; Sonication mode; Ultrafiltration membrane; Ultrasonic

Indexed keywords

ULTRASONICS;

CROSS-FLOW ULTRAFILTRATION; FLAT SHEET MEMBRANES; PERMEATION FLUXES; ULTRA-FILTRATION MEMBRANES;

FOULING;

EID: 84908374423     PISSN: None     EISSN: 22133437     Source Type: Journal    
DOI: 10.1016/j.jece.2014.10.005     Document Type: Article

References (26)

1. M.O. Lamminen, H.W. Walker, and L.K. Weavers Mechanisms and factors influencing the ultrasonic cleaning of particle-fouled ceramic membranes J. Membr. Sci. 237 1 2004 213 223 10.1016/j.memsci.2004.02.031
2. Z. Cai, J. Kim, and M.M. Benjamin NOM removal by adsorption and membrane filtration using heated aluminum oxide particles Environ. Sci. Technol. 42 2 2008 619 623 10.1021/es7021285 18284172
3. N. Lee, G. Amy, J.-P. Croué, and H. Buisson Identification and understanding of fouling in low-pressure membrane (MF/UF) filtration by natural organic matter (NOM) Water Res. 38 20 2004 4511 4523 10.1016/j.watres.2004.08.013 15556226
4. J.P. Chen, S.L. Kim, and Y.P. Ting Optimization of membrane physical and chemical cleaning by a statistically designed approach J. Membr. Sci. 219 1 2003 27 45 10.1016/S0376-7388(03)00174-1
5. L. Shu, W. Xing, and N. Xu Effect of ultrasound on the treatment of emulsification wastewater by ceramic membranes Chin. J. Chem. Eng. 15 6 2007 855 860 10.1016/S1004-9541(08)60014-2
6. A. Brou, L. Ding, P. Boulnois, and M.Y. Jaffrin Dynamic microfiltration of yeast suspensions using rotating disks equipped with vanes J. Membr. Sci. 197 1 2002 269 282 10.1016/S0376-7388(01)00642-1
7. M.K. Jørgensen, M.T. Pedersen, M.L. Christensen, and T.R. Bentzen Dependence of shear and concentration on fouling in a membrane bioreactor with rotating membrane discs AIChE J. 60 2 2014 706 715 10.1002/aic.14302
8. T. Jiang, H. Zhang, F. Yang, D. Gao, and H. Du Relationships between mechanically induced hydrodynamics and membrane fouling in a novel rotating membrane bioreactor Desalin. Water Treat. 51 13-15 2013 2850 2861 10.1080/19443994.2012.750794
9. O.A. Akoum, M.Y. Jaffrin, L. Ding, P. Paullier, and C. Vanhoutte An hydrodynamic investigation of microfiltration and ultrafiltration in a vibrating membrane module J. Membr. Sci. 197 1 2002 37 52 10.1016/S0376-7388(01)00602-0
10. M.Y. Jaffrin Dynamic shear-enhanced membrane filtration: a review of rotating disks, rotating membranes and vibrating systems J. Membr. Sci. 324 1 2008 7 25 10.1016/j.memsci.2008.06.050
11. Z.F. Cui, S. Chang, and A.G. Fane The use of gas bubbling to enhance membrane processes J. Membr. Sci. 221 1 2003 1 35 10.1016/S0376-7388(03)00246-1
12. D. Chen, L.K. Weavers, and H.W. Walker Ultrasonic control of ceramic membrane fouling by particles: effect of ultrasonic factors Ultrason. Sonochem. 13 5 2006 379 387 10.1016/j.ultsonch.2005.07.004 16162417
13. J. Li, R.D. Sanderson, and E.P. Jacobs Ultrasonic cleaning of nylon microfiltration membranes fouled by Kraft paper mill effluent J. Membr. Sci. 205 1-2 2002 247 257 10.1016/S0376-7388(02)00121-7
14. P. Pirkonen Ultrasound in filtration and sludge dewatering Adv. Sonochem. 6 2001 221 246 10.1016/S1569-2868(01)80010-3
15. T. Kobayashi, T. Kobayashi, Y. Hosaka, and N. Fujii Ultrasound-enhanced membrane-cleaning processes applied water treatments: influence of sonic frequency on filtration treatments Ultrasonics 41 3 2003 185 190 10.1016/S0041-624X(02)00462-6 12726939
16. H. Kyllönen, P. Pirkonen, and M. Nyström Membrane filtration enhanced by ultrasound: a review Desalination 181 1 2005 319 335
17. S. Muthukumaran, S.E. Kentish, G.W. Stevens, and M. Ashokkumar Application of ultrasound in membrane separation processes: a review Rev. Chem. Eng. 22 3 2006 155 194 10.1515/REVCE.2006.22.3.155
18. A. Maskooki, T. Kobayashi, S.A. Mortazavi, and A. Maskooki Effect of low frequencies and mixed wave of ultrasound and EDTA on flux recovery and cleaning of microfiltration membranes Sep. Purif. Technol. 59 1 2008 67 73 10.1016/j.seppur.2007.05.028
19. J.-Y. Lu, X. Du, and G. Lipscomb Cleaning membranes with focused ultrasound beams for drinking water treatment Ultrasonics Symposium (IUS), 2009 IEEE International 2009 IEEE
20. Y. Hakata, F. Roddick, and L. Fan Impact of ultrasonic pre-treatment on the microfiltration of a biologically treated municipal effluent Desalination 283 2011 75 79 10.1016/j.desal.2011.03.032
21. A. Mirzaie, and T. Mohammadi Effect of ultrasonic waves on flux enhancement in microfiltration of milk J. Food Eng. 108 1 2012 77 86 10.1016/j.jfoodeng.2011.07.026
22. Y. Gao, D. Chen, L.K. Weavers, and H.W. Walker Ultrasonic control of UF membrane fouling by natural waters: effects of calcium, pH, and fractionated natural organic matter J. Membr. Sci. 401 2012 232 240 10.1016/j.memsci.2012.02.009
23. M. Cai, S. Zhao, and H. Liang Mechanisms for the enhancement of ultrafiltration and membrane cleaning by different ultrasonic frequencies Desalination 263 1 2010 133 138 10.1016/j.desal.2010.06.049
24. M.-W. Wan, F. Reguyal, C. Futalan, H.-L. Yang, and C.-C. Kan Ultrasound irradiation combined with hydraulic cleaning on fouled polyethersulfone and polyvinylidene fluoride membranes Environ. Technol. 34 21 2013 2929 2937 10.1080/09593330.2012.701235 24617052
25. S. Muthukumaran, S. Kentish, S. Lalchandani, M. Ashokkumar, R. Mawson, G.W. Stevens, and F. Grieser The optimisation of ultrasonic cleaning procedures for dairy fouled ultrafiltration membranes Ultrason. Sonochem. 12 1 2005 29 35 10.1016/j.ultsonch.2004.05.007 15474949
26. A. Maskooki, S.A. Mortazavi, and A. Maskooki Cleaning of spiralwound ultrafiltration membranes using ultrasound and alkaline solution of EDTA Desalination 264 1 2010 63 69 10.1016/j.desal.2010.07.005