A review of waste heat recovery on two-stroke IC engine aboard ships

Renewable and Sustainable Energy Reviews

Volumn 19, Issue , 2013, Pages 385-401

  Shu, Gequn ^a   Liang, Youcai ^a   Wei, Haiqiao ^a   Tian, Hua ^a   Zhao, Jian ^a   Liu, Lina ^a  

^a TIANJIN UNIVERSITY   (China)

Author keywords

Desalination; Refrigeration; Ship; Turbocharger; WHR

Indexed keywords

DESALINATION; ECONOMICS; FUEL ECONOMY; INTEGRATED CIRCUITS; INTERNAL COMBUSTION ENGINES; REFRIGERATION; SHIPS; TIMING CIRCUITS; WASTE HEAT;

APPLICATION FEASIBILITY; BASIC PRINCIPLES; ECONOMY AND ENVIRONMENTAL; EXPERIMENTAL ANALYSIS; IC ENGINES; NOVEL METHODS; TECHNICAL PRINCIPLE; TURBOCHARGER;

WASTE HEAT UTILIZATION;

EID: 84870820557     PISSN: 13640321     EISSN: None     Source Type: Journal    
DOI: 10.1016/j.rser.2012.11.034     Document Type: Review

References (114)

1. V. Eyringer, H.W. Köhler, A. Lauer, and B. Lemper Emissions from international shipping: 2. Impact of future technologies on scenarios until 2050 Journal of Geophysical Research 110 2005 D17306
2. Marek Dzida, and Janusz Mucharski On the possible increasing of efficiency of ship power plant with the system combined of marine diesel engine, gas turbine and steam turbine in case of main engine cooperation with the gas turbine fed in parallel and the steam turbine Polish Maritime Research 1 59)(vol. 16) 2009 47 52
3. S. Jaichandar, and K. Annamalai Effects of open combustion chamber geometries on the performance of pongamia biodiesel in a DI diesel engine Fuel 98 2012 272 279
4. S. Park Optimization of combustion chamber geometry and engine operating conditions for compression ignition engines fueled with dimethyl ether Fuel 97 2012 61 71
5. S. Gan, H.K. Ng, and KM. Pang Homogeneous Charge Compression Ignition (HCCI) combustion: implementation and effects on pollutants in direct injection diesel engines Applied Energy 88 2011 559 567
6. M. Yao, Z. Zheng, and H. Liu Progress and recent trends in homogeneous charge compression ignition (HCCI) engines Progress in Energy and Combustion Science 35 2009 398 437
7. M. Zheng, and G.T. Reader Energy efficiency analyses of active flow aftertreatment systems for lean burn internal combustion engines Energy Conversion and Management 45 2004 2473 2493
8. C. Park, S. Kim, H. Kim, and Y. Moriyoshi Stratified lean combustion characteristics of a spray-guided combustion system in a gasoline direct injection engine Energy 41 2012 401 407
9. X. Lu, Y. Shen, Y. Zhang, X. Zhou, L. Ji, and Z. Yang Controlled three-stage heat release of stratified charge compression ignition (SCCI) combustion with a two-stage primary reference fuel supply Fuel 90 2011 2026 2038
10. W. Knecht Diesel engine development in view of reduced emission standards Energy 33 2008 264 271
11. Wartsila LTD. Solution for merchant vessels; 2010.
12. x and engine performance for electronically controlled marine two-stroke diesel engines Applied Thermal Engineering 37 2012 344 352
13. M. He, X. Zhang, K. Zeng, and K. Gao A combined thermodynamic cycle used for waste heat recovery of internal combustion engine Energy 36 2011 6821 6829
14. 2 emission. Copenhagen, Denmark: MAN B&W Diesel A/S, July 2005.
15. S. Park, J. Heo, B.S. Yu, and S.H. Phee Computational analysis of ship's exhaust-gas flow and its application for antenna location Applied Thermal Engineering 31 2011 1689 1702
16. J. Moldanova, E. Fridell, O. Popovicheva, B. Demirdjian, V. Tishkova, and A. Faccinetto Characterisation of particulate matter and gaseous emissions from a large ship diesel engine Atmospheric Environment 43 2009 2632 2641
17. G. Bidini, F. Maria, and M. Generosi Micro-cogeneration system for a small passenger vessel operating in a nature reserve Applied Thermal Engineering 25 2005 851 865
18. W.-K. Tien, R-H Yeh, and J-M Hong Theoretical analysis of cogeneration system for ships Energy Conversion and Management 48 2007 1965 1974
19. G.R. Rigby, G.M. Hallegraeff, and C. Sutton Novel ballast water heating technique offers cost-effective treatment to reduce the risk of global transport of harmful marine organisms Marine Ecology Progress Series 191 1999 289 293
20. D.G. Thombare, and S.K. Verma Technological development in the Striling cycle engines Renewable and Sustainable Energy Reviews 12 2008 1 38
21. B. Cullen, and J. McGovern Energy system feasibility study of an Otto cycle/Striling cyclehybrid automotive engine Energy 35 2010 1017 1023
22. L. Eriksson, L. Nielsen, J. Brugard, J. Bergstrom, F. Pettersson, and P. Andesson Modeling of a turbocharger SI engine Annual Reviews in Control 26 2002 129 137
23. W.M.S.R. Weerasinghe, R.K. Stobart, and S.M. Hounsham Thermal efficiency improvement in high output diesel engines a comparison of a Rankine cycle with turbo-compounding Applied Thermal Engineering 30 2010 2253 2256
24. J.B. Heywood Internal combustion engine fundamentals 1988 McGraw-Hill New York p. 248-70
25. Baines Nick, Wygant Karl D, Dris Antonis. The analysis of heat transfer in automotive turbochargers. ASME GT2009-59353.
26. M. Karabektas The effects of turbocharger on the performance and exhaust emissions of a diesel engine fuelled with biodiesel Renewable Energy 34 2009 989 993
27. Theotokatos GP. A modelling approach for the overall ship propulsion plant simulation. In: Proceedings of the 6th WSEAS international conference on system science and simulation in engineering. Venice, Italy; November 21-23, 2007.
28. A. Stefanopoulou, and R. Smith Maneuverability and smoke emission constraints in marine diesel propulsion Control Engineering Practice 8 2000 1023 1031
29. MAN diesel & turbo LTD. VTA-variable turbine area. Augsburg, Germany: MAN Diesel & Turbo 86224. 〈www.mandieselturbo.com〉.
30. C.D. Copeland, P. Newton, R. Martinez-Botas, and M. Seiler The effect of unequal admission on the performance and loss generation in a double-entry turbocharger turbine Journal of Turbo Machinery 134 2012 021004 021015
31. A. Romagnoli, R.F. Matinez-Botas, and S. Rajoo Steady state performance evaluation of variable geometry twin-entry turbine International Journal of Heat and Fluid Flow 32 2011 477 489
32. Ding Xianfei, and Xu Bin Study on regulating law of two-stage turbo charger system of piston aircraft engine Procedia Engineering 17 2011 581 586
33. J. Galindo, J.R. Serrano, H. Climent, and O. Varnier Impact of two-stage turbocharging architectures on pumping losses of automotive engines based on an analytical model Energy Conversion and Management 51 2010 1958 1969
34. Hopmann Ulrich, Marcelo C. Algrain diesel engine electric turbo compound technology. SAE paper 2003-01-2294.
35. MAN diesel & turbo LTD. MAN diesel & turbo technology boosts efficiency. MAN diesel & turbo SE Teglholmsgade 41 DK-2450 Copenhagen SV DENMARK; June 2011. 〈www.mandieselturbo.com〉.
36. S.G. Wang, and R.Z. Wang Recent developments of refrigeration technology in fishing vessels Renewable Energy 30 2005 589 600
37. A.A. Manzela, S.M. Hanriot, L.C. Gomez, and J.R. Sodre Using engine exhaust gas as energy source for an absorption refrigeration system Applied Energy 87 2010 1141 1148
38. A. Kececiler, H. Acar, and A. Dogan Thermodynamic analysis of the absorption refrigeration system with geothermal energy: an experimental study Energy Conversion and Management 41 2000 37 48
39. 2O absorption refrigeration plant in trawler chiller fishing vessels Applied Thermal Engineering 18 1998 1189 1205
40. J.D. Maloney, and R.C. Robertson Thermodynamic study of ammonia-water power cycles 1953 Oak Ridge National Laboratory Oak Ridge (TN)
41. Kalinowski P, Hwang Y, Radermacher R. Waste heat powered absorption refrigeration system in the LNG recovery process. In: Proceedings of the 9th international sorption heat pump conference. Seoul, Korea; 2008.
42. D.C. Erickson Extending the boundaries of ammonia absorption chillers ASHRAE Journal 49 4 2007 32 35
43. P. Srikhirin, S. Aphornratana, and S. Chungpaibulpatana A review of absorption refrigeration technologies Renewable and Sustainable Energy Reviews 5 4 2001 343 372
44. Little Adrienne, Garimella Srinivas. Comparative assessment of alternative cycles for waste heat recovery and upgrade. In: Proceedings of the ASME 2009 3rd international conference of energy sustainability. ES2009-90023.
45. Y. Fan, L. Luo, and B. Souyri Review of solar sorption refrigeration technologies: development and applications Renewable and Sustainable Energy Reviews 11 2007 1758 1775
46. Daliang Hong, Guangming Chen, Limin Tang, and Yijian He A novel ejector-absorption combined refrigeration cycle International Journal of Refrigeration 34 2011 159 160
47. D. Hong, L. Tang, Y. He, and G. Chen A novel absorption refrigeration cycle Applied Thermal Engineering 30 2010 2045 2050
48. S. Garimella, A.M. Brown, and A.K. Nagavarapu Waste heat driven absorption/vapor-compression cascade refrigeration system for megawatt scale, high-flux, low-temperature cooling International Journal of Refrigeration 2011 10.1016/j.ijrefrig.2011.05.017
49. R.D. Misra, P.K. Sahoo, S. Sahoo, and A. Gupta Thermoeconomic optimization of a single effect water/LiBr vapour absorption refrigeration system International Journal of Refrigeration 26 2003 158 169
50. O. Kizilkan, A. Sencan, and A. Kalogirou Thermoeconomic optimization of a LiBr absorption refrigeration system Chemical Engineering and Processing 46 2007 1376 1384
51. 2O absorption refrigeration system for the minimization of the annual operating cost Applied Thermal Engineering 37 2012 10 18
52. 2O absorption chiller using structural method Journal of Energy Resources Technology 127 2 2005 119 124
53. N.C. Srivastava, and I.W. Eames A review of adsorbents and adsorbates in solid-vapour adsorption heat pump systems Applied Thermal Engineering 18 1998 707 714
54. D.M. Ruthven Principles of adsorption and adsorption processes 1984 Wiley New York
55. M. Suzuki Adsorption for energy transport 1980 Adsorption Engineering Japan
56. Y. Liu, and K.C. Leong The effect of operating conditions on the performance of zeolite/water adsorption cooling systems Applied Thermal Engineering 25 2005 1403 1418
57. I. Solmus, B. Kaftanoglu, C. Yamali, and D. Baker Experimental investigation of a natural zeolite-water adsorption cooling unit Applied Energy 88 2011 4206 4213
58. L.Z. Zhang Design and testing of an automobile waste heat adsorption cooling system Applied Thermal Engineering 20 2000 103 114
59. R.Z. Wang, J.Y. Wu, Y.X. Xu, and W. Wang Performance researches and improvements on heat regenerative adsorption refrigerator and heat pump Energy Conversion and Management 42 2001 233 249
60. L.W. Wang, R.Z. Wang, Z.S. Lu, C.J. Chen, K. Wang, and J.Y. Wu The performance of two adsorption ice making test units using activated carbon and a carbon composite as adsorbents Carbon 44 2006 2671 2680
61. D.C. Wang, Z.Z. Xia, and J.Y. Wu Design and performance prediction of a novel zeolite-water adsorption air conditioner Energy Conversion and Management 47 2006 590 610
62. Z.S. Lu, R.Z. Wang, J.Y. Wu, and C.J. Chen Performance analysis of an adsorption refrigerator using activated carbon in a compound adsorbent Carbon 44 2006 747 752
63. R.Z. Wang Performance improvement of adsorption cooling by heat and mass recovery operation International Journal of Refrigeration 24 2001 602 611
64. Shelton SV, Wepfer WJ. Solid-vapor heat pump technology. In: Proceedings of the IEA heat pump conference. Tokyo; 1990. p. 525-35.
65. R.E. Critoph Forced convection adsorption cycle with packed bed heat regeneration International Journal of Refrigeration 22 1999 38 46
66. F. Ziegler, F. Brandl, J. Volkel, and G. Alefeld A cascading two-stage sorption chiller system consisting of water-zeolite high temperature stage and a water-LiBr low temperature stage Absorption Heat Pump Congress Paris 1985 231 238
67. Y. Liu, and K.C. Leong Numerical modeling of a zeolite/water adsorption cooling system with non-constant condensing pressure International Communications in Heat and Mass Transfer 35 2008 618 622
68. M. Tatler A novel approach to enhance heat and mass transfer in adsorption heat pumps using the zeolite-water pair Microporous and Mesoporous Materials 27 1999 1 10
69. R.Z. Wang, J.Y. Wu, Y.X. Xu, and W. Wang Performance researches and improvements on heat regenerative adsorption refrigerator and heat pump Energy Conversion and Management 42 2001 233 249
70. Z. Tamainot-Telto, and R.E. Critoph Adsorption refrigerator using monolithic carbon-ammonia pair International Journal of Refrigeration 20 2 1997 146 155
71. Y.Z. Lu, R.Z. Wang, S. Jianzhou, Y.X. Xu, and J.Y. Wu Practical experiments on an adsorption air conditioner powered by exhausted heat from a diesel locomotive Applied Thermal Engineering 24 2004 1051 1059
72. L.W. Wang, H.S. Bao, and R.Z. Wang A comparison of the performances of adsorption and resorption refrigeration systems powered by the low grade heat Renewable Energy 34 2009 2373 2379
73. T.X. Li, R.Z. Wang, R.G. Oliveira, J.K. Kiplagat, and L.W. Wang A combined double-way chemisorptions refrigeration cycle based on adsorption and resorption processes International journal of Refrigeration 32 2009 47 57
74. Hendricks TJ, Lustbader JA. Advanced thermoelectric power system investigations for light-duty and heavy-duty vehicle applications: part I. In: Proceedings of the 21st international conference on thermoelectrics. IEEE Catalogue; 2002. p. 381-6.
75. Rowe DM, Min G, Williams SGK, Aoune A, Matsuura K, Kuznetsov VL, et al. Thermoelectric recovery of waste heat - case studies. In: Proceedings of the 32nd international energy conversion engineering conference, vol. 2; 1997. p. 1075-9.
76. Hendricks Terry, Choate William T. Engineering scoping study of thermoelectric generator systems for industrial waste heat recovery; November 2006.
77. Kajikawa T. Present state of R&D on thermoelectric technology in Japan. In: Proceedings of the 20th international conference on thermoelectrics. IEEE catalogue; 2001. p. 49-56.
78. Bass JC, Elsner NB Leavitt FA. Performance of the 1 kW thermoelectric generator for diesel engines. In: Proceedings of the international conference on thermoelectric. Kansas City, Kansas, USA; 1994.
79. David Michael Rowe Thermoelectric waste heat recovery as a renewable energy source International Journal of Innovations in Energy Systems and Power 1 1 2006
80. Hendricks Terry, Choate William T. Engineering scoping study of thermoelectric generator systems for industrial waste heat recovery; November 2006.
81. Gequn Shu, Zhao J, Tian H, Wei H, Liang X, Yu G. Theoretical analysis of engine waste heat recovery by the combined thermo-generator and organic Rankine cycle system. SAE paper 2012-01-0636.
82. Haidar Jihad G, Ghojel Jamil I. Waste heat recovery from the exhaust of low-power diesel engine using thermoelectric generators. In: Proceedings of the 20th international conference on thermoelectrics; 2001.
83. David Michael Rowe Thermoelectric waste heat recovery as a renewable energy source International Journal of Innovations in Energy Systems and Power 1 1 2006
84. T. Wang, Y. Zhang, Z. Peng, and G. Shu A review of researches on thermal exhaust heat recovery with Rankine cycle Renewable and Sustainable Energy Reviews 15 2011 2862 2871
85. Ringler J, Seifert M, Guyotot V, Hubner W. Rankine cycle for waste heat recovery of IC engines. SAE paper 2009-01-0174; 2009.
86. T.C. Hung, T.Y. Shai, and S.K. Wang A review of organic Rankine cycles (ORCs) for the recovery of low-grade waste heat Energy 22 7 1997 661 667
87. P. Bombarda, C.M. Invernizzi, and C. Pietra Heat recovery from diesel engines: a thermodynamic comparison between Kalina and ORC cycles Applied Thermal Engineering 30 2010 212 219
88. J. Larjola Electricity from industrial waste heat using high-speed organic Rankine cycle (ORC) International Journal of Production Economics 41 1995 227 235
89. D. Gewald, S. Konstantinos, K. Sotirios, and S. Hartmut Waste heat recovery from a landfill gas-fired power plant Renewable and Sustainable Energy Reviews 16 2012 1779 1789
90. Leibowitz H, Smith IK, Stosic N. Cost effective small scale ORC systems for power recovery from low grade heat sources. In: IMECE 2006-14284, ASME international mechanical engineering congress and exposition. Chicago, Illinois, USA; November 5-10, 2006.
91. Brasz Joost J, Biederman BP, Holdmann G Power Production from a moderate-temperature geothermal resource. GRC annual meeting. Reno, NV, USA; September 25-28th; 2005.
92. B.-T. Liu, K-H Chien, and C-C Wang Effect of working fluids on organic Rankine cycle for waste heat recovery Energy 29 2004 1207 1217
93. T.C. Hung Waste heat recovery of organic Rankine cycle using dry fluids Energy Conversion and Management 42 2001 539 553
94. T. Yamamoto, T. Furuhata, N. Arai, and K. Mori Design and testing of the organic Rankine cycle Energy 26 2001 239 251
95. A.D. Khawaji, I.K. Kutubkhanah, and J-M Wie Advances in seawater desalination technologies Desalination 221 2008 47 69
96. R. Borsani, and R. Rebagliati Fundamentals and costing of MSF desalination plants and comparison with other technologies Desalination 182 2005 9 37
97. Walid Elshorbagy, and Mohamed Abdulkarim Chlorination byproducts in drinking water produced from thermal desalination in United Arab Emirates Environmental Monitoring and Assessment 123 2006 313 331
98. O.K. Buros The U.S.A.I.D. desalination manual 1980 International Desalination and Environmental Association Gainesville, Florida
99. Federico Ghirardo, Marco Santin, Alberto Trave rso, and Aristide Massardo Heat recovery options for onboard fuel cell systems International Journal of Hydrogen Energy 36 2011 8134 8142
100. C. Sommariva, and R. Venkatesh MSF desalination MEDRC Newsletter 18 2002 1 3
101. IDA Desalination Yearbook. Water desalination report. Topsfield (MA), USA: Global Water Intelligence and International Desalination Association; 2006-2007.
102. F. Al-Juwayhel, E.I. Dessouky, and H. Ettouney Analysis of single-effect evaporator desalination systems combined with vapor compression heat pumps Desalination 114 1997 253 275
103. R. Borsani, and R. Rebagliati Fundamentals and costing of MSF desalination plants and comparison with other technologies Desalination 182 2005 9 37
104. I.C. Karagiannis, and P.G. Soldatos Water desalination cost literature: review and assessment Desalination 223 2008 448 456
105. M.A. Eltawil, Z. Zhengming, and L. Yuan A review of renewable energy technologies integrated with desalination systems Renewable and Sustainable Energy Reviews 13 2009 2245 2262
106. M. Al-Sahali, and H. Ettouney Developments in thermal desalination processes: design, energy, and costing aspects Desalination 214 2007 227 240
107. A. Ophir, and F. Lokiec Advanced MED process for most economical sea water Desalination 182 2005 81 192
108. Hisham Ettouney Design and analysis of humidification dehumidification desalination process Desalination 183 2005 341 352
109. O.J. Morin Design and operating comparison of MSF and MED systems Desalination 93 1-3 1993 69 109
110. G.Th. Vlachos, and J.K. Kaldellis Application of gas-turbine exhaust gases for brackish water desalination: a techno-economic evaluation Applied Thermal Engineering 24 2004 2487 2500
111. Ebensperger U, Isley P. Review of the current state of desalination: water policy working paper 2005-008. Georgia Water Planning and Policy Center; 2005. 〈http://www.h2opolicycenter.org/wp2005.shtml〉 [accessed 15.09.07].
112. Wartsila Corporation. Waste heat recovery. Leaflet; 2007. p. 6.
113. Evans LR, Miller JE. Sweeping gas membrane desalination using commercial hydrophobic hollow fiber membranes. SAND report. SAND 2002-0138. Unlimited release. Printed January; 2002.
114. Karytsas. Mediterranean conference on renewable energy sources for water production, European commission. EURORED Network. Santorini, Greece: CRES; 1996. p. 128-31.