Diagnostic tools for PEMFCs: From conception to implementation

International Journal of Hydrogen Energy

Volumn 39, Issue 20, 2014, Pages 10613-10626

  Cadet, C ^a   Jemei S ^b,c   Druart, F ^d   Hissel, D ^b,c  

^a GRENOBLE INSTITUTE OF TECHNOLOGY   (France)

^b Université de Franche Comté   (France)

^c UNIVERSITÉ DE FRANCHE COMTÉ   (France)

^d LEPMI   (France)

Author keywords

Comparison; Drying; Fault diagnosis; Flooding; PEM fuel cell; Performances

Indexed keywords

DEGRADATION; DIAGNOSTIC PRODUCTS; DRYING; FAILURE ANALYSIS; FLOODS; OIL WELL FLOODING;

COMPARISON; DEGRADATION MECHANISM; DIAGNOSIS PERFORMANCE; FLOODING AND DRYING; IMPLEMENTATION ABILITIES; OPERATING CONDITION; PEM FUEL CELL; PERFORMANCES;

PROTON EXCHANGE MEMBRANE FUEL CELLS (PEMFC);

EID: 84902545373     PISSN: 03603199     EISSN: None     Source Type: Journal    
DOI: 10.1016/j.ijhydene.2014.04.163     Document Type: Article

References (61)

1. M. Ciureanu, and R. Roberge Electrochemical impedance study of PEM fuel cells. Experimental diagnostics and modeling of air cathodes J Phys Chem B 105 2001 3531 3539
2. Fouquet, C. Doulet, C. Nouillan, G. Dauphin-Tanguy, and B. Ould-Bouamama Model based PEM fuel cell state-of-health monitoring via ac impedance measurements J Power Sourc 159 2006 905 913
3. N. Fouquet Real time model-based Monitoring of a PEM fuel cell flooding and drying out IEEE vehicle power and propulsion conference (VPPC), Lille, France 2010 1 8
4. A. Gebregergis, P. Pillay, and R. Rengaswamy PEMFC fault diagnosis, modeling, and mitigation IEEE Trans Ind Appl 46 2010 295 303
5. T. Kadyk, R. Hanke-Rauschenbach, and K. Sundmacher Nonlinear frequency response analysis of PEM fuel cells for diagnosis of dehydration, flooding and CO-poisoning J Electroanal Chem 630 2009 19 27
6. J. Kim, I. Lee, Y. Tak, and B.H. Cho State-of-health diagnosis based on hamming neural network using output voltage pattern recognition for a PEM fuel cell Int J Hydrogen Energy 37 2012 4280 4289
7. J.M. Le Canut, R.M. Abouatallah, and D.A. Harrington Detection of membrane drying, fuel cell flooding, and anode catalyst poisoning on PEMFC stacks by electrochemical impedance spectroscopy J Electrochem Soc 153 5 2006 A857 A864
8. W. Mérida, D.A. Harrington, J.M. Le Canut, and G. McLean Characterization of proton exchange membrane fuel cell (PEMFC) failures via electrochemical impedance spectroscopy J Power Sourc 161 2006 264 274
9. F.S. Saleh, and E.B. Easton Diagnosing degradation within PEM fuel cell catalyst layers using electrochemical impedance spectroscopy J Electrochem Soc 159 5 2012 B546 B553
10. N. Wagner, and E. Gtilzow Change of electrochemical impedance spectra (EIS) with time during CO-poisoning of the Pt-anode in a membrane fuel cell J Power Sourc 127 2004 341 347
11. X. Yuan, J.C. Sun, M. Blanco, H. Wang, J. Zhang, and D.P. Wilkinson AC impedance diagnosis of a 500 W PEM fuel ceil stack part I: stack impedance J Power Sourc 161 2006 920 928
12. X. Yuan, J.C. Sun, M. Blanco, H. Wang, J. Zhang, and D.P. Wilkinson AC impedance diagnosis of a 500 W PEM fuel cell stack part II: individual cell impedance J Power Sourc 161 2006 929 937
13. Aitouche, Q. Yang, and B.O. Bouamama Fault detection and isolation of PEM fuel cell system based on nonlinear analytical redundancy Eur Phys J Appl Phys 54 2 2012 23408 23419
14. F. Barbir, H. Gorgun, and X. Wang Relationship between pressure drop and cell resistance as a diagnostic tool for PEM fuel cells J Power Sourc 141 2005 96 101
15. Escobet, D. Feroldi, S. de Lira, V. Puig, J. Quevedo, and J. Riera et al. Model-based fault diagnosis in PEM fuel cell systems J Power Sourc 192 2009 216 223
16. A. Hernandez, D. Hissel, and R. Outbib Fuel cell fault diagnosis: a stochastic approach IEEE ISIE 2006, Montreal, Quebec, Canada 2006, July 9-12
17. A. Hernandez, D. Hissel, and R. Outbib Modeling and fault diagnosis of a polymer electrolyte fuel cell using electrical equivalent analysis IEEE Trans Energy Convers 25 2010 148 160
18. D. Hissel, M.C. Péra, and J.M. Kauffmann Diagnosis of automotive fuel cell power generators J Power Sourc 128 2004 239 246
19. M. Jung, M.D. Ashford, and K.A. Williams Analysis of a fuel cell system by a step response Fuel Cell 11 2 2011 327 338
20. A.M. Niroumand, W. Mérida, M. Eikerling, and M. Saif Pressure-voltage oscillations as a diagnostic tool for PEFC cathodes Electrochem Commun 12 2010 122 124
21. A.M. Niroumand, W. Mérida, and M. Saif PEM fuel cell low flow FDI J Process Contr 21 2011 602 612
22. L.A.M. Riascos, M.G. Simoes, and P.E. Miyagi On-line fault diagnostic system for proton exchange membrane fuel cells J Power Sourc 175 2008 419 429
23. M.A. Rubio, A. Urquia, and S. Dormido Diagnosis of PEM fuel cells through current interruption J Power Sourc 171 2007 670 677
24. M.A. Rubio, A. Urquia, and S. Dormido Diagnosis of performance degradation phenomena in PEM fuel cells Int J Hydrogen Energy 35 2010 2586 2590
25. J. Stumper, M. Löhr, and S. Hamada Diagnostic tools for liquid water in PEM fuel cells J Power Sourc 143 2005 150 157
26. X. Xuea, J. Tanga, N. Sammesa, and Y. Ding Model-based condition monitoring of PEM fuel cell using Hotelling 12 control limit J Power Sourc 162 2006 388 399
27. N. Yousfi Steiner, D. Hissel, P. Moçotéguy, and D. Candusso Diagnosis of polymer electrolyte fuel cells failure modes (flooding & drying out) by neural networks modeling Int J Hydrogen Energy 36 2011 3067 3075
28. N. Yousfi Steiner, D. Candusso, D. Hissel, and P. Moçotéguy Model-based diagnosis for proton exchange membrane fuel cells Math Comput Simul 81 2010 158 170
29. J. Chen, and B. Zhou Diagnosis of PEM fuel cell stack dynamic behaviors J Power Sourc 177 2008 83 95
30. E. Denisov PEM fuel cell electrical fluctuations and noises and their diagnosis properties [PhD] December 2011 Université de Poitier (in English)
31. B. Legros, P.X. Thivel, and R.P. Nogueira First results on PEMFC diagnosis by electrochemical noise Electrochem Commun 13 12 2011 1514 1516
32. N. Yousfi Steiner, D. Hissel, P. Moçotéguy, and D. Candusso Non-intrusive diagnosis of polymer electrolyte fuel cells by wavelet packet transform Int J Hydrogen Energy 36 2011 740 746
33. N. Youfi-Steiner, Ph. Moçotéguy, D. Candusso, D. Hissel, A. Hernandez, and A. Aslanides A review on PEM voltage degradation associated with water management: impact, influent factors and characterization J Power Sourc 183 2008 260 274
34. R. Petrone, Z. Zheng, D. Hissel, M.C. Péra, C. Pianese, and M. Sorrentino et al. A review on model-based diagnosis methodologies for PEMFCs Int J Hydrogen Energy 38 2013 7077 7091
35. A. Zeller, O. Rallières, J. Régnier, and C. Turpin Diagnosis of a hydrogen/air fuel cell by a statistical model-based method IEEE vehicle power and propulsion conference (VPPC) 2010 1 6
36. J. Hua, J. Li, M. Ouyang, L. Lu, and L. Xu Proton exchange membrane fuel cell system diagnosis based on the multivariate statistical method Int J Hydrogen Energy 36 16 2011 9896 9905
37. L. Placca, R. Kouta, D. Candusso, J.-F. Blachot, and W. Charon Analysis of PEM fuel cell experimental data using principal component analysis and multi linear regression Int J Hydrogen Energy 35 10 2010 4582 4591
38. S. Wasterlain, D. Candusso, F. Harel, X. François, and D. Hissel Diagnosis of a fuel cell stack using electrochemical impedance spectroscopy and bayesian networks 2010 IEEE vehicle power and propulsion conference (VPPC) 2010 1 6
39. S. De Lira, V. Puig, J. Quevedo, and A. Husar LPV observer design for PEM fuel cell system: application to fault detection J Power Sourc 196 2011 4298 4305
40. S. Giurgea, R. Tirnovan, D. Hissel, and R. Outbib An analysis of fluidic voltage statistical correlation for a diagnosis of PEM fuel cell flooding Int J Hydrogen Energy 38 2013 4689 4696
41. R. Isermann Fault-diagnosis systems 2006 Springer 465pp.
42. K.R. Cooper, and M. Smith Electrical test methods for on-line fuel cell ohmic resistance measurement J Power Sourc 160 2006 1088 1095
43. D. Hissel, D. Candusso, and F. Harel Fuzzy-clustering durability diagnosis of polymer electrolyte fuel cells dedicated to transportation applications IEEE Trans Veh Technol 56 5 2007 2414 2420
44. R. Onanena, L. Oukhellou, D. Candusso, A. Same, D. Hissel, and P. Aknin The estimation of fuel cell operating time for predictive maintenance strategies Int J Hydrogen Energy 35 15 2010 8022 8029
45. R. Onanena, L. Oukhellou, D. Candusso, F. Harel, D. Hissel, and P. Aknin Fuel cells static and dynamic characterizations as tools for the estimation of their ageing time Int J Hydrogen Energy 36 2011 1730 1739
46. J. Marcinkosk, B.D. James, J.A. Kalinoski, W. Podolski, T. Benjamin, and J. Kopasz Manufacturing process assumptions used in fuel cell system cost analyses J Power Sourc 196 2011 5282 5292
47. M.A. Riascos, and D.D. Pereira Limit operating temperature in PEM fuel cells J Electrochem Soc 156 9 2009 B1051 B1058
48. B. Wahdame, D. Candusso, X. François, F. Harel, J.-M. Kauffmann, and G. Coquery Design of experiment techniques for fuel cell characterisation and development Int J Hydrogen Energy 34 2009 967 980
49. M. Ji, and Z. Wei A review of water management in polymer electrolyte membrane fuel cells Energies 2 2009 1057 1106
50. T. Ous, and C. Arcoumanis Visualisation of water accumulation in the flow channels of PEMFC under various operating conditions J Power Sourc 187 2009 182 189
51. J. Larminie, and A. Dicks Fuel cell systems explained 2nd ed. 2003 John Wiley & Sons Ltd England
52. L. Placca, and R. Kouta Fault tree analysis for PEM fuel cell degradation process modelling Int J Hydrogen Energy 36 2011 12393 12405
53. N. Yousfi-Steiner, D. Hissel, P. Moçotéguy, D. Candusso, D. Marra, and C. Pianese et al. Application of fault tree analysis to fuel cell diagnosis Fuel Cell 12 2 2012 302 309
54. M. Halkidi, Y. Batistakis, and M. Vazirgiannis On clustering validation techniques J Intell Inf Syst 17 2-3 2001 107 145
55. I. Arsie, A. Di Filippi, D. Marra, C. Pianese, and M. Sorrentino Fault tree analysis aimed to design and implement on-field fault detection and isolation schemes for SOFC systems ASME. 8th International conference on fuel cell science, engineering and technology vol. 1 2010 1 11
56. O. Arbelaitz, I. Gurrutxaga, J. Muguerza, J.M. Pérez, and I. Perona An extensive comparative study of cluster validity indices Pattern Recogn 46 2013 243 256
57. M. Brun, C. Sima, J. Hua, J. Lowey, B. Carroll, and E. Suh et al. Model-based evaluation of clustering validation measures Pattern Recogn 40 2007 807 824
58. I. Yélamos, M. Graells, L. Puigjaner, and G. Escudero Simultaneous fault diagnosis in chemical plants using a MultiLabel approach AIChE J 53 11 2007 2871 2884
59. I. Yélamos, G. Escudero, M. Graells, and L. Puigjaner Performance assessment of a novel fault diagnosis system based on support vector machines Comput Chem Eng 33 2009 244 255
60. K. Wang Algorithmes et méthodes pour le diagnostic ex-situ et in-situ de systèmes de Piles à Combustibles à hautes températures de type oxyde-solide, Thèse de Doctorat de l'Université de Franche Comté, N° ordre: 2012107 2012
61. S. Wasterlain, F. Harel, D. Candusso, D. Hissel, and X. François A new high voltage impedance spectrometer for the diagnostic of the fuel cell stacks J Fuel Cell Sci Technol 8 2011 024502 024511 6