Filtration efficiency and pressure drop of miniature diesel particulate filters

Aerosol Science and Technology

Volumn 47, Issue 4, 2013, Pages 452-461

  Swanson, J ^a,b   Watts, W ^a   Kittelson, D ^a   Newman, R ^c   Ziebarth, R ^c  

^a University of Minnesota   (United States)

^b UNIVERSITY OF CAMBRIDGE   (United Kingdom)

^c DOW CHEMICAL COMPANY   (United States)

Author keywords

[No Author keywords available]

Indexed keywords

ADVANCED CERAMICS; DIESEL PARTICULATE FILTERS; FILTRATION EFFICIENCY; FILTRATION PERFORMANCE; MINIATURE FILTERS; PENETRATING PARTICLE SIZES; SILICON CARBIDES (SIC); SUBSTRATE MORPHOLOGIES;

AIR FILTERS; CATALYSTS; FUEL FILTERS; MICROSTRUCTURE; PRESSURE DROP; SILICATE MINERALS; SILICON CARBIDE; SOOT;

PARTICLE SIZE;

SILICON CARBIDE;

ANALYTICAL EQUIPMENT; ARTICLE; CATALYST; CELL DENSITY; DIESEL PARTICULATE FILTER; EXHAUST GAS; FILTRATION; FILTRATION EFFICIENCY; PARTICLE SIZE; PARTICULATE MATTER; POROSITY; PRESSURE TRANSDUCER; PRIORITY JOURNAL;

EID: 84900278521     PISSN: 02786826     EISSN: 15217388     Source Type: Journal    
DOI: 10.1080/02786826.2012.763087     Document Type: Article

References (42)

1. Abdul-Khalek, I. S., and Kittelson, D. B. (1995). Real Time Measurement of Volatile and Solid Exhaust Particles Using a Catalytic Stripper. SAE Tech. Paper Ser., 950236.
2. California Environmental Protection Agency Air Resources Board (CARB). (2011). Verification Procedure-Currently Verified. http://www.arb.ca.gov/diesel/ verdev/vt/cvt.htm.
3. Dekati. (2011). FPS-4000 Dekati Fine Particle Sampler. http://dekati.com/cms/fps-4000.
4. Dieselnet. (2011). Emission Standards Summary of Worldwide Diesel Emission Standards. http://www.dieselnet.com/standards/.
5. Dillon, H., Maupin, G., Carlson, S., Saenz, N., and Gallant, T. (2007a). Visualization Techniques for Single Channel DPF Systems. SAE Tech. Paper Ser., 2007-01-1126.
6. Dillon, H. E., Stewart, M. L., Maupin, G. D., Gallant, T. R., Li, C., Mao, F. H., et al. (2007b). Optimizing the Advanced Ceramic Material for Diesel Particulate Filter Applications. SAE Tech. Paper Ser., 2007-01-1124.
7. Erickson, K., and Quant, F. (2011). Investigation of Fast Scanning SMPS Measurements: 16s and Below. Proceedings of 30th AAAR Conference, October 3-7, Orlando, Florida, USA.
8. Hinds, C. W. (1999). Aerosol Technology, Properties, Behavior, and Measurement of Airborne Particles. John Wiley & Sons, New York.
9. Johnson, T. V. (2004). Diesel Emission Control Technology - 2003 in Review. SAE Tech. Paper Ser., 2004-01-0070.
10. Johnson, T. V. (2008). Diesel Engine Emissions and Their Control. Platinum Met. Rev., 52:23-37.
11. Johnson, T. V. (2010). SAE 2009 World Congress Key Developments in Diesel Emission Control and Catalysts. Platinum Met. Rev., 54:37-41.
12. Kalogirou, M., Katsaounis, D., Koltsakis, G., and Samaras, Z. (2007). Measurements of Diesel Soot Oxidation Kinetics in an Isothermal Flow Reactor-Catalytic Effects Using Pt Based Coatings. Top. Catal., 42-43:247-251.
13. Kittelson, D. B., Watts, W. F., Johnson, J. P., and Ragatz, A. C. (2010). New Method for the Real-Time Measurement of Diesel Aerosol. Contract Final Report for NIOSH Grant no., R01 OH 008676-01. Available online at: http://www.me.umn.edu/centers/cdr/reports/nioshrealtime.pdf.
14. Konstandopoulos, A. G., and Johnson, J. H. (1989). Wall-flow Diesel Particulate Filters-Their Pressure Drop and Collection Efficiency. SAE Tech. Paper Ser., 890405.
15. Konstandopoulos, A. G., Kostoglou, M., Skaperdas, E., Papaioannou, E., Zarvalis, D., and Kladopoulou, E. (2000). Fundamental Studies of Diesel Particulate Filters: Transient Loading, Regeneration and Aging. SAE Tech. Paper Ser., 2000-01-1016.
16. Konstandopoulos, A. G., and Papaioannou, E. (2008). Update on the Science and Technology of Diesel Particulate Filters. KONA Part. Powder, 26:36-65.
17. Konstandopoulos, A. G., Skaperdas, E., and Masoudi, M. (2002). Microstructural Properties of Soot Deposits in Diesel Particulate. SAE Tech. Paper Ser., 2002-01-1015.
18. Konstandopoulos, A., Zarvalis, D., Kladopoulou, E., and Dolios, I. (2006). A Multi-Reactor Assembly for Screening of Diesel Particulate Filters. SAE Tech. Paper Ser., 2006-01-0874.
19. Li, C. G., Koelman, H., Ramanathan, R., Baretzky, U., Forbriger, G., and Meunier, T. (2008). Particulate Filter Design for High Performance Diesel Engine Application. SAE Tech. Paper Ser., 2008-01-1747.
20. Li, C. G., and Pyzik, A. J. (2009). Application of Porous Acicular Mullite for Filtration of Diesel Nano Particulates, in Developments in Porous, Biological and Geopolymer Ceramics: Ceramic Engineering and Science Proceedings, M. Brito, E. Case, W. M. Kriven, J. Salem, and D. Zhu, eds., John Wiley & Sons, Hoboken, USA, p. 27.
21. Mikkanen, P. (2001). Characterization of Exhaust Particulate Emissions from Road Vehicles Deliverable 4: Prototype Dilution Sampling System. Particulates project sponsored by: European Commission Directorate General Transport and Environment. http://lat.eng.auth.gr/particulates/deliverables/ Particulates D4.pdf.
22. Mizutani, T., Kaneda, A., Ichikawa, S., Miyairi, Y., Ohara, E., Takahashi, A., et al. (2007). Filtration Behavior of Diesel Particulate Filters (2). SAE Tech. Paper Ser., 2007-01-0923.
23. Murtagh, M. J., Sherwood, D. L., and Socha, L. S., Jr. (1994). Development of Diesel Particulate Filter Composition and Its Effect on Thermal Durability and Filtration Performance. SAE Tech. Paper Ser., 940235.
24. Otto, K., Betta, R. A., and Yao, H. C. (1974). A Laboratory Method for the Simulation of Automobile Exhaust and Studies of Catalyst Poisoning. J. Air Pollut. Contr. Assoc., 24(6):596-600.
25. Park, K., Cao, F., Kittelson, D. B., and McMurry, P. (2003). Relationship Between Particle Mass and Mobility for Diesel Exhaust Particles. Environ. Sci. Technol., 37:577-583. (Pubitemid 36159649)
26. Pyzik, A. J., and Li, C. G. (2005). New Design of a Ceramic Filter for Diesel Emission Control Applications. Int. J. Appl. Ceram. Technol., 2:440-451. (Pubitemid 43056456)
27. Pyzik, A. J., Todd, C., and Han, S. C. (2008). Formation Mechanism and Microstructure Development in Acicular Mullite Ceramics Fabricated by Controlled Decomposition of Fluorotopaz. J. Eur. Ceram. Soc., 28:383-391. (Pubitemid 350047433)
28. Rakovec, N., Viswanathan, S., and Foster, D. (2011). Micro-scale Study of DPF Permeability as a Function of PM Loading. SAE Tech. Paper Ser., 2011-01-0815.
29. Schrade, F., Brammer, M., Schaeffner, J., Langeheinecke, K., and Kraemer, L. (2012). Physico-Chemical Modeling of an Integrated SCR on DPF (SCR/DPF) System. SAE Int. J. Engines, 5(3):958-974.
30. Suresh, A., Khan, A., and Johnson, J. H. (2000). Pressure Drop and Permeability of Clean and Particulate Loaded Filters. SAE Tech. Paper Ser., 2000-01-0476.
31. Swanson, J., and Kittelson, D. (2010). Evaluation of Thermal Denuder and Catalytic Stripper Methods for Solid Particle Measurements. J. Aerosol Sci., 41:1113-1122.
32. Swanson, J. J., Watts, W., and Kittelson. D. B. (2011). Diesel Exhaust Aerosol Measurements Using Air-Ejector and Porous Wall Dilution Techniques. SAE Tech. Paper Ser., 2011-01-0637.
33. Swanson, J. J., Kittelson, D., Watts, W., Newman, R., and Ziebarth, R. (2013). Simultaneous Reduction of Particulate Matter and NOx Emissions using 4-Way Catalyzed Filtration Systems. Submitted.
34. Tan, J., Solbrig, C., and Schmieg, S. (2011). The Development of Advanced 2-Way SCR/DPF Systems to Meet Future Heavy-Duty Diesel Emissions. SAE Tech. Paper Ser., 2011-01-1140.
35. Tien, C. (1989). Granular Filtration of Aerosols and Hydrosols. Butterworths, New York.
36. Tsuneyoshi, K., Takagi, O., and Yamamoto, K. (2011). Effects of Washcoat on Initial PM Filtration Efficiency and Pressure Drop in SiC DPF. SAE Tech. Paper Ser., 2011-01-0817.
37. U.S. Environmental Protection Agency. (2011). National Clean Diesel Campaign (NCDC). Verification Verified Technologies List. http://epa.gov/ cleandiesel/verification/verif-list.htm.
38. Wang, X., Grose, M., Caldow, R., Swanson, J., Watts, W., and Kittelson (2009). Improvement of Engine Exhaust Particle Sizer Spectrometer (EEPS) for Engine Emissions Measurement. Proceedings of 28th AAAR Conference, October 26-30, Minneapolis, MN, USA.
39. Wirojsakunchai, E., Kolodziej, C., Yapaulo, R., and Foster, D. E. (2008). Development of the Diesel Exhaust Filtration Analysis System (DEFA). SAE Tech. Paper Ser., 2008-01-0486.
40. Wirojsakunchai, E., Schroeder, E., Kolodziej, C., Foster, D., Schmidt, N., Root, T., et al. (2007). Detailed Diesel Exhaust Particulate Characterization and Real-Time DPF Filtration Efficiency Measurements During PM Filling Process. SAE Tech. Paper Ser., 2007-01-0320.
41. Yang, J., Stewart, M., Maupin, G. D., Herling, D. R., and Zelenyuk, A. (2009). Single Wall Diesel Particulate Filter (DPF) Filtration Efficiency Studies Using Laboratory Generated Particles. Chem. Eng. Sci., 64(8):1625-1634.
42. Yapaulo, R. A., Wirojsakunchai, E., Orita, T., Foster, D. E., Akard, M., Walker, L. R., et al. (2009). Impact of Filtration Velocities and Particulate Matter Characteristics on Diesel Particulate Filter Wall Loading. Intl. J. Engine Res., 10(5):287-304.