Numerical study on thermal-induced lubricant depletion in laser heat-assisted magnetic recording systems

International Journal of Heat and Mass Transfer

Volumn 55, Issue 4, 2012, Pages 886-896

  Zeng, Yan ^a   Zhou, Weidong ^b   Huang, Xiaoyang ^a   Yu, Shengkai ^b  

^a NANYANG TECHNOLOGICAL UNIVERSITY   (Singapore)

^b DATA STORAGE INSTITUTE   (Singapore)

Author keywords

Heat transfer; Heat assisted recording system; Lubricant depletion; Numerical investigation

Indexed keywords

ACCOMMODATION COEFFICIENTS; EVAPORATION RATE; EXPERIMENTAL DATA; HEAT-ASSISTED MAGNETIC RECORDING; INITIAL THICKNESS; LUBRICANT FILM THICKNESS; LUBRICANT FILMS; NUMERICAL INVESTIGATIONS; NUMERICAL STUDIES; RECORDING SYSTEMS; THERMOCAPILLARITY; THIN LAYERS;

ENTHALPY; HEAT TRANSFER; MAGNETIC RECORDING; PHASE TRANSITIONS; RECORDING INSTRUMENTS; SURFACE TENSION;

THERMAL EVAPORATION;

EID: 82955195665     PISSN: 00179310     EISSN: None     Source Type: Journal    
DOI: 10.1016/j.ijheatmasstransfer.2011.10.020     Document Type: Article

References (26)

1. L. Wu Lubricant dynamics under sliding condition in disk drives J. Appl. Phys. 100 2006 024505
2. L. Wu A model for liquid transfer between two approaching gas bearing surfaces through coupled evaporation-condensation and migration dynamics J. Appl. Phys. 104 2008 014503
3. L. Wu Modeling and simulation of the lubricant depletion process induced by laser heating in heat-assisted magnetic recording system Nanotechnology 18 2007 215702
4. N. Tagawa, R. Kakitani, H. Tani, N. Iketani, and I. Nakano Study of lubricant depletion induced by laser heating in thermally assisted magnetic recording systems-effect of lubricant film materials IEEE Trans. Magn. 45 2009 877 882
5. N. Tagawa, H. Andoh, and H. Tani Study on lubricant depletion induced by laser heating in thermally assisted magnetic recording systems: effect of lubricant thickness and bonding ratio Tribol. Lett. 37 2010 411 418
6. N. Tagawa, and H. Tani Lubricant depletion characteristics induced by rapid laser heating in thermally assisted magnetic recording IEEE Trans. Magn. 47 2011 105 110
7. R. Wood The feasibility of magnetic recording at 1 terabit per square inch IEEE Trans. Magn. 26 2000 36 42 (Pubitemid 30576973)
8. B. Liu, J. Liu, and T.C. Chong Slider design for sub-3-nm flying height head-disk systems J. Magn. Magn. Mater. 287 2005 339 345 (Pubitemid 40135689)
9. B. Liu, S.K. Yu, M.S. Zhang, L. Gonzaga, H. Li, and J. Liu Air-bearing design towards highly stable head-disk interface at ultralow flying height IEEE Trans. Magn. 43 2007 715 720 (Pubitemid 46182966)
10. D.W. Meyer, P.E. Kupinski, J.C. Liu, US Patent No. 5991113, 1999.
11. M. Alex, A. Tselikov, T. McDaniel, N. Deeman, T. Valet, and D. Chen Characteristics of thermally assisted magnetic recording IEEE Trans. Magn. 37 2001 1244 1249 (Pubitemid 32968984)
12. H. Saga, H. Nemoto, H. Sukeda, and M. Takahashi New recording method combining thermo-magnetic writing and flux detection Japanese J. Appl. Phys. 38 1999 1839 1840
13. T. Rausch, C. Mihalcea, K. Pelhos, D. Karns, K. Mountfield, Y.A. Kubota, X. Wu, G. Ju, W.A. Challener, C. Peng, L. Li, Y. Hsia, and E.C. Gage Near field heat assisted magnetic recording with a planar solid immersion lens Japanese J. Appl. Phys. 45 2006 1314 1320
14. B.X. Xu, S.B. Hu, H.X. Yuan, J. Zhang, Y.J. Chen, R. Ji, X.S. Miao, J.S. Chen, and T.C. Chong Thermal effects of heated magnetic disk on the slider in heat-assisted magnetic recording J. Appl. Phys. 99 2006 08N102
15. M.J. Stirniman, S.J. Falcone, and B.J. Marchon Volatility of perfluorolyether lubricants measured by thermogravimetric analysis Tribol. Lett. 6 1999 199 205
16. A. Oron, S.H. Davis, and S.G. Bankoff Long-scale evolution of thin liquid films Rev. Modern Phys. 69 1997 931 980
17. B. Marchon, T. Karis, Q. Dai, and R. Pit A model for lubricant flow from disk to slider IEEE Trans. Magn. 39 2003 2447 2449
18. H. Matsuoka, K. Oka, Y. Yamashita, F. Saeki, and S. Fukui Deformation characteristics of ultra-thin liquid film considering temperature and film thickness dependence of surface tension: Three-dimensional analyses by the unsteady and linearized long wave equation Microsyst. Technol. 17 2011 983 990
19. C.M. Mate Taking a fresh look at disjoining pressure of lubricants at slider-disk interfaces IEEE Trans. Magn. 47 2011 124 130
20. R.W. Schrage A Theoretic Study of Interface Mass Transfer 1953 Columbia University Press New York
21. W.D. Zhou, B. Liu, S.K. Yu, and W. Hua Numerical studies of heat transfer in rarefied gases at head-disk interface Japanese J. Appl. Phys. 48 2009 105005
22. B.V. Derjaguin, and N.V. Churaev Polymolecular adsorption and capillary condensation in narrow slit pores J. Colloid Interface Sci. 54 1976 157 175
23. J.E. Curry, and H.K. Christenson Adsorption, wetting, and capillary condensation of nonpolar fluids in mica slits Langmuir 12 1996 5729 5735 (Pubitemid 126599517)
24. K.R. Paserba, and A.J. Gellman Desorption kinetics and energetic of monodisperse Fomblin Zdol from carbon surfaces J. Phys. Chem. B 105 2001 12105 12110 (Pubitemid 35338367)
25. R. Marek, and J. Straub Analysis of the evaporation coefficient and the condensation coefficient of water Int. J. Heat Mass Transfer 44 2001 39 53
26. M. Zientara, D. Jakubczyk, K. Kolwas, and M. Kolwas Temperature dependence of the evaporation coefficient of water in air and nitrogen under atmospheric pressure: study in water droplets J. Phys. Chem. A 112 2008 5152 5158