The effect of an alumina counterface on friction reduction of CuO/3Y-TZP composite at room temperature

Wear

Volumn 274-275, Issue , 2012, Pages 75-83

  Song, Jiupeng ^a   Valefi, Mahdiar ^a   De Rooij, Matthijn ^a   Schipper, Dirk J ^a   Winnubst, Louis ^b  

^a UNIVERSITY OF TWENTE   (Netherlands)

^b UNIVERSITY OF TWENTE   (Netherlands)

Author keywords

Ceramics; Composite; Friction; Sliding wear

Indexed keywords

CERAMICS; COEFFICIENT OF FRICTIONS; COMPOSITE; CONTACT CONDITIONS; CONTACT SURFACE; COUNTER MATERIALS; DRY SLIDING; ENERGY DISPERSIVE X RAY SPECTROSCOPY; FRICTION AND WEAR; FRICTION BEHAVIOR; FRICTION REDUCTION; FRICTIONAL BEHAVIOR; FTIR; INTERFACIAL CHEMICAL REACTIONS; INTERFACIAL LAYER; INTERFERENCE MICROSCOPY; LOW FRICTION; REDUCING-FRICTION; ROOM TEMPERATURE; SCANNING ELECTRONS; SLIDING DISTANCES; SLIDING TEST; SLIDING WEAR; SURFACE LAYERS; TETRAGONAL ZIRCONIA; TRANSFORM INFRARED SPECTROSCOPY; WEAR MECHANISMS;

ALUMINA; ALUMINUM; FOURIER TRANSFORM INFRARED SPECTROSCOPY; REDUCTION; TRIBOLOGY; X RAY PHOTOELECTRON SPECTROSCOPY; X RAY SPECTROSCOPY; YTTRIUM ALLOYS; ZIRCONIA;

FRICTION;

EID: 82955172294     PISSN: 00431648     EISSN: None     Source Type: Journal    
DOI: 10.1016/j.wear.2011.08.016     Document Type: Article

References (23)

1. Liu H., Xue Q. The tribological properties of TZP-graphite self-lubricating ceramics. Wear 1996, 198:143-149.
2. 2 composites. Wear 2004, 256:182-189.
3. Pasaribu H.R., Sloetjes J.W., Schipper D.J. Friction reduction by adding copper oxide into alumina and zirconia ceramics. Wear 2003, 255:699-707.
4. Ran S., Winnubst L., Blank D.H.A., Pasaribu H.R., Sloetjes J.W., Schipper D.J. Effect of microstructure on the tribological and mechanical properties off CuO-doped 3Y-TZP ceramics. J. Am. Ceram. Soc. 2007, 90(9):2747-2752.
5. Pasaribu H.R., Reuver K.M., Schipper D.J., Ran S., Wiratha K.W., Winnubst A.J.A., Blank D.H.A. Environmental effects on friction and wear of dry sliding zirconia and alumina ceramics doped with copper oxide. Int. J. Refract. Met. Hard Mater. 2005, 23:386-390.
6. Tocha .E., Pasaribu H.R., Schipper D.J., Schönherr H., Vancso G.J. Low friction in CuO-doped yttria-stabilized tetragonal zirconia ceramics: a complementary macro- and nanotribolology study. J. Am. Ceram. Soc. 2008, 91(5):1646-1652.
7. Anstis G.R., Chantikul P., Lawn B.R., Marshall D. A critical evaluation of indentation techniques for measuring fracture toughness: I, direct crack measurements. J. Am. Ceram. Soc. 1981, 64(9):533-538.
8. H.R. Pasaribu, Friction and wear of zirconia and alumina ceramics doped with CuO, Ph.D. Thesis, University of Twente, Enschede, The Netherlands, 2005.
9. Pasaribu H.R., Schipper D.J. Deterministic friction model of a rough surface sliding against a flat layered surface. Tribol. Lett. 2004, 17(4):967-976.
10. Gee M.G. The formation of aluminum hydroxide in the sliding wear of alumina. Wear 1992, 153:201-227.
11. Dong X., Jahanmir S., Hsu S.M. Tribological characteristics of α-alumina at elevated temperatures. J. Am. Ceram. Soc. 1991, 74(5):1036-1044.
12. Mortimer R.J., Mayes R.J. Characterisation and humidity-sensing properties of aluminium (oxy)-hydroxide films prepared by cathodically induced precipitation. Sens. Actuators B 2007, 128:124-132.
13. Gee M.G., Almond E.A. The effect of surface finish on the wear of alumina. J. Mater. Sci. 1990, 25:296-310.
14. Wefer K., Bell G.M. Oxides and Hydroxides of the Aluminum, Technical Paper 19 1972, Alcoa Research Laboratories.
15. Misra C. Industrial Alumina Chemicals 1986, American Chemical Society, 17.
16. Ajayi O.O., Ludema K.C. Mechanism of transfer film formation during repeat pass sliding of ceramic materials. Wear 1990, 140:191-206.
17. He Y., Winnubst L., Burggraaf A.J., Verweij H., Van der Vast P.G., de With B. Grain-size dependence of sliding wear in tetragonal zirconia polycrystals. J. Am. Ceram. Soc. 1996, 79:3090-3096.
18. Misra S.K., Chaklader A.C.D. The system copper oxide-alumina. J. Am. Ceram. Soc. 1963, 46(10):509.
19. 3. Trans. Br. Ceram. Soc. 1964, 563:39-62.
20. Tokumitsu K. Reduction of metal oxides by mechanical alloying method. Solid State Ionics 1997, 101-103:25-31.
21. 3(η, γ and α) systems. Thermochim. Acta 1984, 78:71-80.
22. 3. J. Am. Ceram. Soc. 1975, 58:192-195.
23. 3-metal systems. J. Appl. Phys. 1976, 47(6):2579-2583.