Powering LED using high-efficiency SR flyback converter

IEEE Transactions on Industry Applications

Volumn 47, Issue 1, 2011, Pages 376-386

  Hwu, K I ^a   Yau, Y T ^b   Lee, Li Ling ^b  

^a NATIONAL TAIPEI UNIVERSITY OF TECHNOLOGY   (Taiwan)

^b INDUSTRIAL TECHNOLOGY RESEARCH INSTITUTE   (Taiwan)

Author keywords

Critical conduction mode (CRM); high efficiency; LC snubber; light emitting diodes (LEDs); multifunction circuit; peripheral circuit; synchronously rectified (SR) flyback converter; two stage power factor correction (PFC) converter; zero crossing

Indexed keywords

CRITICAL CONDUCTION MODES; FLYBACK CONVERTERS; HIGH EFFICIENCY; LC SNUBBER; LIGHT-EMITTING DIODES (LEDS); MULTIFUNCTION CIRCUIT; PERIPHERAL CIRCUITS; TWO STAGE; ZERO-CROSSINGS;

LIGHT EMISSION; TOPOLOGY;

LIGHT EMITTING DIODES;

EID: 78751674065     PISSN: 00939994     EISSN: None     Source Type: Journal    
DOI: 10.1109/TIA.2010.2091234     Document Type: Article

References (39)

1. R. W. Erickson and D. Maksimovic, Fundamentals of Power Electronics, 2nd ed. Norwell, MA: Kluwer, 2001.
2. N. Mohan, T. M. Undeland, and W. P. Robbins, Power Electronics, 2nd ed. New York: Wiley, 2003.
3. A. M. Trynadlowski, Introduction to Modern Power Electronics, 1st ed. New York: Wiley, 1998.
4. A. Hren, J. Korelic, andM.Milanovic, "RC-RCD clamp circuit for ringing losses reduction in a flyback converter," IEEE Trans. Circuits Syst. II, Exp. Briefs, vol. 53, no. 5, pp. 369-373, May 2006.
5. N. Rouger, J. C. Crebier, and S. Catellani, "High-efficiency and fully integrated self-powering technique for intelligent switch-based flyback converters," IEEE Trans. Ind. Appl., vol. 44, no. 3, pp. 826-835, May/Jun. 2008.
6. Y. B. Weng and Y. Xing, "A dual-transformer flyback converter in critical conduction mode," in Proc. IEEE IPEMC, 2004, vol. 3, pp. 1074-1079.
7. W. Lin, H. Song, Z. Y. Lu, and G. Hua, "A high efficiency gate-driving scheme of synchronous rectifiers in wide-input-voltage-range CCM flyback converter," in Proc. IEEE PESC, 2006, pp. 1-6.
8. S. Y. Tseng, C. T. Hsieh, and H. C. Lin, "Active clamp interleaved flyback converter with single-capacitor turn-off snubber for stunning poultry applications," in Proc. IEEE PEDS, 2007, pp. 1401-1408.
9. C. Y. Inaba, Y. Konishi, H. Tanimatsu, K. Hirachi, and M. Nakaoka, "Soft switching PWM DC-DC flyback converter with transformer-assisted pulse current regenerative passive resonant snubbers," in Proc. IEEE PEDS, 2003, vol. 2, pp. 882-887.
10. M. Jinno, P.-Y. Chen, and K.-C. Lin, "An efficient active LC snubber for multi-output converters with flyback synchronous rectifier," in Proc. IEEE PESC, 2003, vol. 2, pp. 622-627.
11. K.-B. Park, C.-E. Kim, G.-W. Moon, and M.-J. Youn, "New cost-effective PWM single-switch isolated converter," in Proc. IEEE PESC, 2007, pp. 1715-1720.
12. A. Bakkali, P. Alou, J. A. Oliver, and J. A. Cobos, "Average modeling and analysis of a flyback with active clamp topology based on a very simple transformer," in Proc. IEEE APEC, 2007, pp. 500-506.
13. C.-S. Liao and K. M. Smedley, "Design of high efficiency flyback converter with energy regenerative snubber," in Proc. IEEE APEC, 2008, pp. 796-800.
14. Y. Xi, P. K. Jain, G. Joos, and Y. F. Liu, "An improved zero voltage switching flyback converter topology," in Proc. IEEE PESC, 1998, vol. 2, pp. 923-929.
15. W. Li, J. Shi, M. Hu, and X. He, "An isolated interleaved active-clamp ZVT flyback-boost converter with coupled inductors," in Proc. IEEE EPE, 2007, pp. 1-9.
16. J. Cho, J. Kwon, and S. Han, "Asymmetrical ZVS PWMflyback converter with synchronous rectification for ink-jet printer," in Proc. IEEE PESC, 2006, pp. 1-7.
17. G. Spiazzi, D. Tagliavia, and S. Spampinato, "DC-DC flyback converters in the critical conduction mode: A re-examination," in Conf. Rec. IEEE IAS Annu. Meeting, 2000, vol. 4, pp. 2426-2432.
18. C. Adragna, "Design equations of high-power-factor flyback converters based on the L6561," ST Application Note, 2003.
19. A. Fernandez, J. Sebastian, M. M. Hernando, and D. G. Lamar, "Power factor correction with a partial power processing converter," in Proc. IEEE APEC, 2005, vol. 3, pp. 1723-1729.
20. E. H. Ismail, M. A. Al-Saffar, and A. J. Sabzali, "Single-stage singleswitch PFC converter with extreme step-down voltage conversion ratio," in Proc. IEEE PEDS, 2009, pp. 543-549.
21. P. Barbosa, F. Canales, and F. C. Lee, "A front-end distributed power system for high-power applications," in Conf. Rec. IEEE IAS Annu. Meeting, 2000, vol. 4, pp. 2546-2551.
22. A. A. Fardoun and E. H. Ismail, "Non-isolated single stage PFC rectifier for wide-input large step-down voltage applications," in Proc. IEEE PEDS, 2009, pp. 294-299.
23. A. Uan-Zo-li, J. Zhang, F. C. Lee, and J. P. Noon, "Study and design considerations of a voltage-source single-stage," in Conf. Rec. IEEE IAS Annu. Meeting, 2000, vol. 4, pp. 2283-2289.
24. W. Qiu, W. Wu, W. Luo, W. Gu, and I. Batarseh, "A bi-flyback PFC converter with low intermediate bus voltage and tight output voltage regulation for universal input applications," in Proc. IEEE APEC, 2002, vol. 1, pp. 256-262.
25. K. W. Siu, Y. S. Lee, and C. K. Tse, "Analysis and experimental evaluation of single-switch fast-response switching regulators with unity power factor," IEEE Trans. Ind. Appl., vol. 33, no. 5, pp. 1260-1266, Sep./Oct. 1997.
26. S. Kim and P. N. Enjeti, "A parallel-connected single phase power factor correction approach with improved efficiency," in Proc. IEEE APEC, 2002, vol. 1, pp. 263-269.
27. Y.-S. Lee, K.-W. Siu, and B.-T. Lin, "Novel single-stage isolated powerfactor- corrected power supplies with regenerative clamping," IEEE Trans. Ind. Appl., vol. 34, no. 6, pp. 1299-1308, Nov./Dec. 1998.
28. T. Sun and D. D.-C. Lu, "Applying time-multiplexing control to singlestage forward-based power-factor-corrected converter," in Proc. IEEE PEDS, 2009, pp. 309-313.
29. J. F. Zhang, A. Shteynberg, D. Zhou, and J. McCreary, "A novel multimode digital control approach for single-stage flyback power supplies with power factor correction and fast output voltage regulation," in Proc. IEEE APEC, 2005, vol. 2, pp. 830-836.
30. K. Yao, M. Xu, X. Ruan, and L. Gu, "Boost-flyback single-stage PFC converter with large DC bus voltage ripple," in Proc. IEEE APEC, 2009, pp. 1867-1871.
31. Z. Ye, F. Greenfeld, and Z. Liang, "Single-stage offline SEPIC converter with power factor correction to drive high brightness LEDs," in Proc. IEEE APEC, 2009, pp. 546-553.
32. D. Gacio, J. M. Alonso, A. J. Calleja, J. Garcia, and M. Rico-Secades, "A universal-input single-stage high-power-factor power supply for HB-LEDs based on integrated buck-flyback converter," in Proc. IEEE APEC, 2009, pp. 570-576.
33. Q. Zhao, F. C. Lee, and J. Qian, "Single-switch parallel power factor correction AC/DC converters with inherent load current feedback," in Proc. IEEE APEC, 2002, vol. 1, pp. 270-276.
34. O. Garcia, C. Fernandez, J. A. Cobos, and J. Uceda, "Universal line voltage single-stage AC/DC converter," in Proc. IEEE APEC, 2002, vol. 1, pp. 237-241.
35. M. Shen and Z. Qian, "A novel high-efficiency single-stage PFC converter with reduced voltage stress," IEEE Trans. Ind. Appl., vol. 38, no. 2, pp. 507-513, Mar./Apr. 2002.
36. V. Belaguli and A. K. S. Bhat, "Characteristics of fixed-frequency hybrid resonant converter operating on the utility line," IEEE Trans. Ind. Appl., vol. 35, no. 6, pp. 1413-1423, Nov./Dec. 1999.
37. J. Shao, "Single stage offline LED driver," in Proc. IEEE APEC, 2009, pp. 582-586.
38. M. S. Agamy and P. K. Jain, "An adaptive energy storage technique for efficiency improvement of single stage three-level resonant AC/DC converters," in Proc. IEEE APEC, 2009, pp. 1005-1010.
39. H. Terashi, T. Sonoda, S. Tomioka, K. Sato, and T. Ninomiya, "Interleaved boost-input-type full bridge converter," in Proc. IEEE APEC, 2005, vol. 2, pp. 683-688.