Effects of pressure, orientation, and heater size on pool boiling of water with nanocoated heaters

International Journal of Heat and Mass Transfer

Volumn 53, Issue 23-24, 2010, Pages 5199-5208

  Kwark, Sang M ^a   Amaya, Miguel ^a   Kumar, Ratan ^a   Moreno, Gilberto ^a   You, Seung M ^a  

^a University of Texas at Arlington   (United States)

Author keywords

Boiling heat transfer; Critical Heat Flux; Nanocoating; Parametric study; Pool boiling

Indexed keywords

BOILING HEAT TRANSFER; CRITICAL HEAT FLUX; NANO-COATINGS; PARAMETRIC STUDY; POOL BOILING;

HEAT FLUX; HEAT TRANSFER; NANOPARTICLES;

LAKES;

EID: 77956059375     PISSN: 00179310     EISSN: None     Source Type: Journal    
DOI: 10.1016/j.ijheatmasstransfer.2010.07.040     Document Type: Article

References (46)

1. J.A. Eastman, U.S. Choi, S. Li, Enhanced thermal conductivity through the development of nanofluids, Symposium of Nanophase and Nanocomposite Materials II, Anonymous Materials Research Society, Boston, MA, vol. 457, 1997, pp. 3-11.
2. P. Vadasz Heat conduction in nanofluid suspensions Trans. ASME J. Heat Transfer 128 5 2006 465 477
3. R.K. Shukla, and V.K. Dhir Effect of Brownian motion on thermal conductivity of nanofluids J. Heat Transfer 130 4 2008 1 13
4. S.M. You, J.H. Kim, and K.H. Kim Effect of nanoparticles on critical heat flux of water in pool boiling heat transfer Appl. Phys. Lett. 83 16 2003 3374 3376
5. J.H. Kim, K.H. Kim, S.M. You, Pool boiling heat transfer in saturated nanofluids, in: ASME Conference Proceedings, Anaheim, CA, 2004, pp. 621-628.
6. G. Moreno, S.J. Oldenburg, S.M. You, Pool boiling heat transfer of alumina-water, zinc oxide-water and alumina-water + ethylene glycol nanofluids, in: ASME Conference Proceedings, San Francisco, CA, 2005, pp. 625-632.
7. S.J. Kim, I.C. Bang, and J. Buongiorno Surface wettability change during pool boiling of nanofluids and its effect on critical heat flux Int. J. Heat Mass Transfer 50 19-20 2007 4105 4116
8. S.K. Das, N. Putra, and W. Roetzel Pool boiling characteristics of nano-fluids Int. J. Heat Mass Transfer 46 5 2003 851 862
9. G.P. Narayan, K.B. Anoop, and S.K. Das Mechanism of enhancement /deterioration of boiling heat transfer using stable nanoparticle suspensions over vertical tubes J. Appl. Phys. 102 074317 2007 1 7
10. K. Sefiane On the role of structural disjoining pressure and contact line pinning in critical heat flux enhancement during boiling of nanofluids Appl. Phys. Lett. 89 044106 2006 1 3
11. H. Kim, and M. Kim Experimental study of the characteristics and mechanism of pool boiling CHF enhancement using nanofluids Heat Mass Transfer 45 7 2007 991 998
12. S.M. Kwark, R. Kumar, G. Moreno, J. Yoo, and S.M. You Pool boiling characteristics of low concentration nanofluids Int. J. Heat Mass Transfer 53 5-6 2010 972 981
13. S.M. Kwark, G. Moreno, R. Kumar, H. Moon, and S.M. You Nanocoating characterization in pool boiling heat transfer of pure water Int. J. Heat Mass Transfer 53 2010 4579 4587
14. M.T. Cichelli, and C.F. Bonilla Heat transfer to liquids boiling under pressure AIChE 1945 755 787
15. K. Nishikawa, Y. Fujita, and H. Ohta Effect of system pressure and surface roughness on nucleate boiling heat transfer Memoirs Faculty Eng. Kyushu Univ. 42 2 1982 95 111
16. A.A. Watwe, A. Bar-Cohen, and A. McNeil Combined pressure and subcooling effects on pool boiling from a PPGA chip package ASME J. Electron. Pack. 119 2 1997 95 105
17. K.N. Rainey, S.M. You, and S. Lee Effect of pressure, subcooling, and dissolved gas on pool boiling heat transfer from microporous, square pin-finned surfaces in FC-72 Int. J. Heat Mass Transfer 46 2003 23 35
18. W.R. McGillis, V.P. Carey, J.S. Fitch, W.R. Hamburgen, Pool boiling enhancement techniques for water at low pressure, in: Proceedings, Seventh Annual IEEE Semiconductor Thermal Measurement and Management Symposium, IEEE, Phoenix, AZ, 1991, pp. 64-72.
19. I. Mudawar, and T.M. Anderson Parametric investigation into the effect of pressure, subcooling, surface augmentation and choice of coolant on pool boiling in the design of cooling systems for high-power-density electronic chips J. Electron. Pack. 112 1990 375 382
20. N. Abuaf, S.H. Balck, and F.W. Staub Pool boiling performance of finned surfaces in R-113 Int. J. Heat Fluid Flow 6 1 1985 23 30
21. A. Bar-Cohen, A. McNeil, Parametric effects on pool boiling critical heat flux in dielectric liquids, in: Proceedings of the Engineering Foundation Conference on Pool and External Flow Boiling, ASME, Santa Barbara, CA, 1992, pp. 171-175.
22. E.A. Kazakova Maximum heat transfer to boiling water at high pressures Eng. Digest 12 3 1951 81 85
23. A.T. Storr, The Effect of Heating Surface Geometry and Orientation on Nucleate Boiling of Subcooled Water, M.S. Thesis, Washington University, Sever Institute of Technology, Department of Chemical Engineering, 1958.
24. B.D. Marcus, and D. Dropkin The effect of surface configuration on nucleate boiling heat transfer Int. J. Heat Mass Transfer 6 1963 863 867
25. P.M. Githinji, and R.H. Sabersky Some effect of the orientation of the heating surface in nucleate boiling ASME J. Heat Transfer 85 4 1963 379
26. J.Y. Chang, and S.M. You Heater orientation effect on pool boiling of micro-porous-enhanced surfaces in saturated FC-72 ASME J. Heat Transfer 118 1996 937 943
27. K. Nishikawa, Y. Fujita, S. Uchida, and H. Ohta Effect of surface configuration on nucleate boiling heat transfer Int. J. Heat Mass Transfer 27 9 1984 1559 1571
28. D.S. Jung, J.E.S. Venar, and A.C.M. Sousa Effects of enhanced surfaces and surface orientation on nucleate and film boiling heat transfer in R-11 Int. J. Heat Mass Transfer 30 1987 2627 2639
29. C. Beduz, R.G. Scurlock, and A.J. Sousa Angular dependence of boiling heat transfer mechanisms in liquid nitrogen Adv. Cryogenic Eng. 33 1988 363 370
30. S.J. Reed, and I. Mudawar Elimination of boiling incipience temperature drop in highly wetting fluids using spherical contact with a flat surface Int. J. Heat Mass Transfer 42 1999 2439 2454
31. E. Baker Liquid cooling of microelectronic devices by free and forced convection Microelectron. Reliab. 11 1972 213 222
32. K.A. Park, and A.E. Bergles Effects of size of simulated microelectronic ships on boiling and critical heat flux ASME J. Heat Transfer 110 1988 728 734
33. I.I. Gogonin, and S.S. Kutateladze Critical heat flux as a function of heater size for liquid boiling in large enclosure J. Eng. Phys. 33 1977 1286 1289
34. S. Ishigai, K. Inoue, Z. Kiwaki, T. Inai, Boiling heat transfer from a flat surface facing downward, in: Proceedings of the International Heat Transfer Conference, Boulder, CO, 1961, pp. 224-229.
35. J. H Lienhard, V.K. Dhir, and D.M. Riherd Peak pool boiling heat flux measurement on finite horizontal flat plates J. Heat Transfer 95 4 1973 477 482
36. J.R. Saylor, T.W. Simon, and A. Bar-Cohen The effect of a dimensionless length scale on the critical heat flux in saturated pool boiling ASME Publication HTD 108 1989 71 80
37. I.L. Pioro, W. Rohsenow, and S.S. Doerffer Nucleate pool-boiling heat transfer. I: Review of parametric effects of boiling surface Int. J. Heat Mass Transfer 47 23 2004 5033 5044
38. S.J. Kline, and F.A. McClintock Describing uncertainties in single-sample experiments Mech. Eng. 75 1953 3 8
39. W.M. Rohsenow A method of correlating heat transfer data for surface boiling of liquids Trans. ASME 84 1962 969 975
40. V.P. Carey Liquid-Vapor Phase Change Phenomena: An Introduction to the Thermophysics of Vaporization and Condensation Process in Heat Transfer Equipment 1992 Taylor & Francis Hebron, KY
41. N. Zuber, Hydrodynamic Aspects of Boiling Heat Transfer, Physics and Mathematics AEC, Report No. AECU-4439, 1959.
42. S.M. Kwark, Pool Boiling Heat Transfer Characteristics of Nanofluids and Nanocoatings, Ph.D. Dissertation, University of Texas at Arlington, Department of Mechanical and Aerospace Engineering, 2009.
43. R. Cole, and H.L. Shulman Bubble departure diameters at subatmospheric pressure Chem. Eng. Prog. Symp. Ser. 62 64 1966 6 16
44. R. Cole Bubble frequencies and departure volumes at subatmospheric pressures AIChE J. 13 1967 779 783
45. J.H. Lienhard On the two regimes of nucleate boiling ASME J. Heat Transfer 118 1985 262 264
46. K.N. Rainey, and S.M. You Effect of heater size and orientation on pool boiling heat transfer from microporous coated surface Int. J. Heat Mass Transfer 44 2001 2589 2599