Thermal conductance of pneumatic conveying preheater for air-gypsum and air-sand heat transfer

International Journal of Thermal Sciences

Volumn 49, Issue 1, 2010, Pages 182-186

  Rajan, K S ^a   Srivastava, S N ^a   Pitchumani, B ^b   Surendiran, V ^a  

^a SASTRA UNIVERSITY   (India)

^b INDIAN INSTITUTE OF TECHNOLOGY DELHI   (India)

Author keywords

Correlation; Dimensionless thermal conductance; Heat transfer area; Pneumatic conveying heat exchanger

Indexed keywords

AIR VELOCITIES; DIMENSIONLESS CORRELATION; DIMENSIONLESS NUMBER; DRIVING FORCES; DRY SOLIDS; EXPERIMENTAL DATA; FEED-RATES; GAS-SOLID; HEAT TRANSFER AREA; HEAT TRANSFER RATE; PHARMACEUTICAL INDUSTRY; PNEUMATIC CONVEYING; PRE-HEATER; THERMAL CONDUCTANCE; VERTICAL PNEUMATIC CONVEYING;

CEMENT INDUSTRY; CONVEYING; DRUG PRODUCTS PLANTS; GYPSUM; HEAT TRANSFER; PNEUMATIC CONVEYORS; PNEUMATIC EQUIPMENT; PNEUMATICS; SPECIFIC HEAT; THERMAL CONDUCTIVITY;

HEAT EXCHANGERS;

EID: 71849094747     PISSN: 12900729     EISSN: None     Source Type: Journal    
DOI: 10.1016/j.ijthermalsci.2009.07.001     Document Type: Article

References (20)

1. Balakrishnan A.R., and Pei D.C.T. Convective heat transfer in gas-solid suspension flow through packed beds. AIChE J. 24 (1978) 613-619
2. Balakrishnan A.R., and Pei D.C.T. Heat transfer in gas-solid packed bed systems - part 1: a critical review. Ind. Eng. Chem. Proc. Des. Dev. 18 (1979) 30-40
3. Balakrishnan A.R., and Pei D.C.T. Thermal transport in two-phase gas-solid suspension flow through packed beds. Powder Technol. 62 (1990) 51-57
4. Turton R., Fitzgerald T.J., and Levenspiel O. An experimental method to determine the heat transfer coefficient between fine fluidized particles and air via changes in magnetic properties. Int. J. Heat Mass Transf. 32 (1989) 289-296
5. Bandrowski J., and Kaczmarzyk G. Gas-to-particle heat transfer in vertical pneumatic conveying of granular materials. Chem. Eng. Sci. 33 (1978) 1303-1310
6. Rajan K.S., Srivastava S.N., Pitchumani B., and Dhasandhan K. Experimental study of thermal effectiveness in pneumatic conveying heat exchanger. Appl. Therm. Eng. (2008) 10.1016/j.applthermaleng.2007.12.004
7. Rajan K.S., Dhasandhan K., Srivastava S.N., and Pitchumani B. Studies on gas-solid heat transfer during pneumatic conveying. Int. J. Heat Mass Transf. 51 11-12 (2008) 2801-2813
8. Nieuwland J.J., Meijer R., Kuipers J.A.M., and Swaaij W.P.M.V. Measurements of solids concentration and axial solids velocity in gas-solid two-phase flows. Powder Technol. 87 (1996) l27-139
9. Mansoori Z., Saffar-Avval M., Basirat-Tabrizi H., and Ahmadi G. Experimental study of turbulent gas-solid heat transfer at different particles temperature. Exp. Therm. Fluid Sci. 28 (2004) 655-665
10. Hettiaratchi K., Woodhead S.R., and Reed A.R. Comparison between pressure drop in horizontal and vertical pneumatic conveying pipelines. Powder Technol. 95 (1998) 67-73
11. Rautiainen A., Stewart G., Poikolainen V., and Sarkomaa P. An experimental study of vertical pneumatic conveying. Powder Technol. 104 (1999) 139-150
12. M. Rhodes, Pneumatic transport of powders. Educational Resources for Particle Technology (an archived electronic journal at www.erpt.org), 2 (2001).
13. Rajan K.S., Pitchumani B., Srivastava S.N., and Mohanty B. Two-dimensional simulation of gas-solid heat transfer during pneumatic conveying. Int. J. Heat Mass Transf. 50 5-6 (2007) 967-976
14. Levy A., and Borde I. Steady state one dimensional flow model for pneumatic drying. Chem. Eng. Process. 38 (1999) 121-130
15. Li J., Campbell G.M., and Mujumdar A.S. Discrete modeling and suggested measurement of heat transfer in gas-solids flows. Drying Technol. 21 6 (2003) 979-997
16. Freitas L.A.P., and Freire. Gas-to-particle heat transfer in the draft tube of a spouted bed. Drying Technol. 19 (2001) 1065-1082
17. Jain A., Mohanty B., Pitchumani B., and Rajan K.S. Study of gas-solid heat transfer in cyclone heat exchanger. ASME J. Heat Transf. 128 8 (2006) 761-768
18. Radford R.D. A model of particulate drying in pneumatic conveying systems. Powder Technol. 93 (1997) 109-126
19. C.P. Narimatsu, M.C. Ferreira, J.T. Freire, Drying of porous alumina particles in a vertical pneumatic dryer, in: Proceedings of the 14th International Drying Symposium (IDS 2004), vol. A, Sao Paulo, Brazil, 22-25 August 2004, pp. 549-556.
20. Namkung W., and Cho M. Pneumatic drying of iron ore particles in a vertical tube. Drying Technol. 22 4 (2004) 877-891