State-of-the-art high power density and high efficiency DC-DC chopper circuits for HEV and FCEV applications

2008 13th International Power Electronics and Motion Control Conference, EPE-PEMC 2008

Volumn , Issue , 2008, Pages 7-20

  Kawamura, Atsuo ^a   Pavlovsky, Martin ^a   Tsuruta, Yukinori ^a  

^a YOKOHAMA NATIONAL UNIVERSITY   (Japan)

Author keywords

[No Author keywords available]

Indexed keywords

AUTOMOBILE PARTS AND EQUIPMENT; AUTOMOBILES; CHOPPERS (CIRCUITS); ELECTRIC AUTOMOBILES; ELECTRIC BATTERIES; ELECTRIC VEHICLES; FUEL CELLS; MOTION CONTROL; MOTION PLANNING; PHOTOLITHOGRAPHY; POWER ELECTRONICS;

DAILY LIVES; DC CHOPPERS; ENERGY CONSUMPTIONS; ENERGY SAVINGS; ENVIRONMENTAL ISSUES; FUEL CELL ELECTRIC VEHICLES; HIGH EFFICIENCIES; HIGH POWER DENSITIES; HYBRID ELECTRIC VEHICLES; LOAD CONDITIONS; MOS FETS; POWER DENSITIES; POWER RANGES; SHORT TERMS; STATE OF THE ARTS;

AUTOMOBILE ELECTRONIC EQUIPMENT;

EID: 56449108602     PISSN: None     EISSN: None     Source Type: Conference Proceeding    
DOI: 10.1109/EPEPEMC.2008.4635239     Document Type: Conference Paper

References (41)

1. K.Shingo, K.Kaoru, T.Katsu, Y.Hata: "Development of Electric Motors for the TOYOTA Hybrid Vehicle "PRIUS"", EVS-17, Dec.2000
2. W.Yu, J.Lai, "Ultra High Efficiency Bidirectional DC-DC Converter With Multi-Frequency Pulse Width Modulation", APEC08, pp.1079-1084, 2008
3. A. Kawamura, Y.Tsuruta, S. Inasaka, " Proposal of electrical mileage for electric vehicle and discussions", IEEJ, VT-07-13, December 2007
4. Y. Ito, Y. Tsuruta, M. Bando, and A. Kawamura, "50kHz-25kW Bilateral Chopper Circuit SAZZ-1 for HEV", EVS-22, Oct.23-28 pp.848-857, 2006
5. H. Ohasi, "Recent Power Devices Trend (in Japanese)", Trans. of IEEJ, vol. 12, no.3, 2002, pp. 168-171.
6. H. Ohashi, "Power Electronics Inovation with Next Generation Advanced Power Devices", Proceeding of INTELEC'03, Oct. 2003, Yokohama (Japan), pp.9-13
7. J.W. Kolar, U. Drofenik, J. Biela, M.L. Heldwein, H. Ertl, T. Friedli, S.D. Round, "PWM Converter Power Density Barriers" Proceedings of Power Conversion Conference, PCC 2007, pp. 9-29, 2-5 April 2007
8. T. Teratani,"Vehicle Energy Management and Higher Voltage 42V for New Generation", 2nd International Congress on 42V Power Net(2000)
9. M.Okamura, E.Sato, S.Sasaki: "Development of Hybrid Electric Drive System Using a Boost Converter", EVS-20, Nov.2003
10. A.Kawamura, "Future commuter vehicles", KAST seminar on next generation mobility systems, 2007 November
11. S. Cuk and R.D. Middlebrook : "Advances on Switched-Mode Power Conversion Part I", IEEE Trans. on Industrial Electronics, Vol.IE-30, No.1, pp.10-19 (1983)
12. Richard G. Hoft : "Semiconductors Power Electronics", Van Nostrand Reinhold Company Inc. New York (1986) (in Japanese)
13. IEEJ : "Recent development on soft switching", IEEJ Technical Report, No.899, pp. 4-8 (2002-9)(in Japanese)
14. A. Kawamura : "Modern Power Electronics", SUURIKOUGAKU-SHA Co. Ltd., the First Edition, Tokyo, pp.39 (2005) (in Japanese)
15. G. Hua, C.S. Leu, and F.C. Lee : "Novel zero-voltage-transition PWM converters", IEEE Trans. on Power Electronics, Vol.9, NO.2, pp.213-219 (1994)
16. M.Nakamura, T.Myoui, M.Ishitobi,M.Nakaoka:"A Soft-Switching PWM Boost Chopper Comtrolled DC-DC Converter with A Single Passive Auxiliary Resonant Snubber and Its Performance Evaluations.",T.IEE Japan,Vol.122-D,No.10, pp.1006-1016,(2002)
17. Q. Zhao and F.C.Lee: "High-Efficiency, High Step-Up DC-DC Converters", IEEE Trans. Power Electronics, Vol.18, No.1, pp.65-73 (2003)
18. J.Zhang, R.-young Kim and J.-Sheng Lai: "High-Power Density Design of a Soft Switching High-Power Bidirectional DC-DC Converter", Proc. of IEEE PESC06, WeA2-1, pp.2119-2125 (2006)
19. K. Maikawa, Y. Tsuruta, and A. Kawamura: "Soft Switching Chopper Circuit for high power application", IEEJ/JIASC 2003, No.1-101, pp.477-478 (2003-8) (in Japanese)
20. Y. Tsuruta and A. Kawamura : "Proposed of 98.5% High Efficiency Chopper Circuit QRAS for the Electric Vehicle and the Verification", T.IEE Japan, Vol.125-D, No.11, pp.977-987 (2005) (in Japanese)
21. Y. Tsuruta, Y. Ito, and A. Kawamura : "The prompt report regarding the efficiency measurement of 8kW QRAS chopper using SiC schottky diode", IEEJ/JIASC 2004, No.1-85, pp.439-442 (2004) (in Japanese)
22. Y. Tsuruta, Y. Ito, and A. Kawamura : "8kW QRAS Chopper Using SiC Schottky Diode", The 2005 International Power Electronics Conference, IPEC-Niigata 2005, S30-3, pp.1113-1119 (2005)
23. Y. Tsuruta, Y. Ito, and A. Kawamura : "The proposal of SAZZ chopper circuit and test verification by means of the preceding fabrication", 2005 National Convention Record, No.4-045, pp.71-72 (2005) (in Japanese)
24. Y. Tsuruta, Y. Ito, and A. Kawamura : "A High Frequency, High Efficiency and High Power Chopper SAZZ and the Test Evaluation at 100kHz-8kW", IEEE 37th Annual Power Electronics Specialists Conference, PESC'06, WeA1-4, pp.1965-1971 (2006)
25. Y. Tsuruta, Y. Ito, M. Bando, and A. Kawamura : "Proposal of Bilateral Buck and Boost Chopper Circuit SAZZ-1 for EV Drive Application and the Test Evaluation at 25kW", IEEE International Conference on Industrial Technology, ICIT-2006, IF005878, pp.1504-1509 (2006)
26. Y. Tsuruta and A. Kawamura : "Technical Stream on a High Efficiency and High Frequency Chopper Circuit", IEEJ/JIASC 2006, No. 1-o-6-2, pp. I-139-I-144 (2006) (in Japanese)
27. st Annual Meeting, IAS 2007,IAS56p5, pp.1-6 (2007)
28. Chin Chang; M.A. Knights, "Interleaving technique in distributed power conversion systems", IEEE Transactions on Circuits and Systems I: Fundamental Theory and Applications, Volume 42 Issue 5, pp. 245 -251
29. M. Gerber, J.A. Ferreira, I.W. Hofsajer, N. Seliger, "Interleaving optimization in synchronous rectified DC/DC converters", Proceedings of Power Electronics Specialists Conference, PESC 2004, Achen - Germany, pp. 4655-4661, Jun 2004
30. O. Garcia, P. Alou, J.A. Oliver, J.A. Cobos, " A high number of phases enables high frequency techniques and a better thermal management in medium power converters", Proceedings of Conference on Integration of Power Electronics Systems, CIPS 2008, pp. 281 - 284, March 2008
31. G.R. Blackwell, The electronic packaging handbook, Boca Raton CRC Press 2000
32. J. Popovic, J.A. Ferreira, "Concepts for high packaging and integration efficiency", Proceedings of Power Electronics Specialists Conference, PESC 2004, Volume 6, June 2004, pp. 4188-4194
33. J. Popovic, J.A. Ferreira, "Design and evaluation of highly integrated dc-dc converters for automotive applications", Proceedings of Industry Applications Conference, IAS 2005, Volume 2, Oct. 2005, pp. 1152-1159
34. J.T. Strydom, J.D. van Wyk, "Electromagnetic modeling for design and loss estimation of resonant integrated spiral planar power passives (ISP/sup 3/)", IEEE Transactions on Power Electronics, Volume 19, Issue 3, May 2004, pp. 603-617
35. M. Pavlovsky, Y. Tsuruta, A. Kawamura, "Automotive DC-DC converter designed for high power-density and high efficiency" Proceedings of Conference on Integration of Power Electronics Systems, CIPS 2008, pp. 191-195, March 2008
36. M. Pavlovsky, S.W.H. de Haan, J.A. Ferreira, "Concept of 50 kW DC/DC converter based on ZVS, quasi-ZCS topology and integrated thermal and electromagnetic design", European Conference on Power Electronics and Applications, EPE 2005, Sept. 2005
37. M. Pavlovsky, "Electronic DC transformer with High Power Density", PhD thesis Delft University of Technology, The Netherlands
38. J. Wanes, "A novel integrated packaging technique for high density DC-DC converters providing enhanced efficiency and thermal management", Proceeding of Applied Power Electronics Conference and Exposition, APEC 2004, Volume 2, pp. 1229-1235
39. M. Gerber, J.A. Ferreira, I.W. Hofsajer, N. Seliger, "High density packaging of the passive components in an automotive DC/DC converter", IEEE Transactions on Power Electronics, Volume 20, Issue 2, Mar 2005, pp. 268-275
40. M. Pavlovsky, Y. Tsuruta, A. Kawamura, "Pursuing High Power-Density and High Efficiency in DC-DC Converters for Automotive Application" Proceedings of Power Electronics Specialists Conference, PESC 2008, Jun 2008
41. Y. Tsuruta, M. Bando, Y. Ito and A. Kawamura, "A new circuit geometry SAZZ for an EV drive application", Proceedings of IEEE Industry Applications Conference, IAS 2006, pp.1-6