Influence of hydrodynamics and probe response on oxygen mass transfer measurements in a high aspect ratio bubble column reactor: Effect of the coalescence behaviour of the liquid phase

Biochemical Engineering Journal

Volumn 39, Issue 1, 2008, Pages 1-14

  Gourich, B ^a   Vial, Ch ^b   El Azher, N ^a   Belhaj Soulami, M ^c   Ziyad, M ^d  

^a Ecole Superieur de Technologie   (Morocco)

^b UNIVERSITÉ CLERMONT AUVERGNE   (France)

^c Laboratoire de Génie des Procédés et Environnement   (Morocco)

^d FACULTÉ DES SCIENCES   (Morocco)

Author keywords

Bubble column; Coalescence behaviour; Hydrodynamics; Mass transfer; Oxygen sensor dynamics

Indexed keywords

BIOREACTORS; COALESCENCE; HYDRODYNAMICS; MASS TRANSFER; OXYGEN SENSORS;

OXYGEN CONCENTRATION CURVES; OXYGEN RESPONSE CURVES; OXYGEN SENSOR DYNAMICS;

BUBBLE COLUMNS;

BUBBLE COLUMN REACTOR; EXPERIMENTAL DESIGN; GAS TRANSPORT; HEMODYNAMICS; MEASUREMENT; OXYGEN CONCENTRATION; OXYGEN SENSING; PLUG FLOW REACTOR; PRIORITY JOURNAL; REVIEW; SENSITIVITY ANALYSIS;

EID: 43049126200     PISSN: 1369703X     EISSN: None     Source Type: Journal    
DOI: 10.1016/j.bej.2007.08.011     Document Type: Review

References (60)

1. Y. Chisti Pneumatically agitated bioreactors in industrial and environmental bioprocessing: hydrodynamics, hydraulics and transport phenomena Appl. Mech. Rev. 51 1989 33 112
2. H. Debellefontaine S. Crispel P. Reilhac F. Périé J.N. Foussard Wet air oxidation (WAO) for the treatment of industrial wastewater and domestic sludge, design of bubble column reactors Chem. Eng. Sci. 54 1999 4953 4959
3. A. Sánchez Mirón F. García Camacho A. Contreras Gómez E. Molina Grima Y. Chisti Bubble column and airlift photobioreactors for algal culture AIChE J. 46 2000 1872 1887
4. A. Sánchez Mirón M. Carmen Cerón García F. García Camacho E. Molina Grim Y.Y. Chisti Growth and biochemical characterization of microalgal biomass produced in bubble column and airlift photobioreactors: studies in fed-batch culture Enzyme Microb. Technol. 31 2002 1015 1023
5. A. Sánchez Mirón M. Carmen Cerón García A. Contreras Gómez F. García Camacho E. Molina Grima Y. Chisti Shear stress tolerance and biochemical characterization of Phaeodactylum tricornutum in quasi steady-state continuous culture in outdoor photobioreactors Biochem. Eng. J. 16 2003 287 297
6. F.G. Ancién Fernández J.M. Fernández Sevilla J.A. Sánchez Pérez E. Molina Grima Y. Chisti Airlift-driven external-loop tubular photobioreactors for outdoor production of microalgae: assessment of design and performance Chem. Eng. Sci. 56 2001 2721 2732
7. H.P. Luo A. Kemoun M.H. Al-Dahhan J.M. Fernández Sevilla J.L. García Sánchez F. García Camacho E. Molina Grima Analysis of photobioreactors for culturing high-value microalgae and cyanobacteria via an advanced diagnostic technique Chem. Eng. Sci. 58 2003 2519 2527
8. W.-D. Deckwer Bubble column reactors 1992 J. Wiley & Sons Chichester, UK
9. M. Hosseini S.A. Shojaosadati J. Towighi Application of bubble column reactor for the production of a single-cell protein from cheese whey Ind. Eng. Chem. Res. 42 2003 764 766
10. J. García-Ochoa S. Foucher S. Poncin D. Morin G. Wild Bioleaching of mineral ores in a suspended solid bubble column: hydrodynamics, mass transfer and reaction aspects Chem. Eng. Sci. 54 1999 3197 3205
11. B. Haut V. Halloin T. Cartage A. Cockx Production of sodium bicarbonate in industrial bubble columns Chem. Eng. Sci. 59 2004 5687 5694
12. M. Al-Tarazi B.M. Heesink G.F. Versteeg M.O.J. Azzam K. Azzam Precipitation of CuS and ZnS in a bubble column reactor AIChE J. 51 2005 235 246
13. K. Akita F. Yoshida Gas hold-up and volumetric mass transfer coefficients in bubble columns Ind. Eng. Chem. Process Des. Dev. 12 1973 76 80
14. H. Hikita K. Asai K. Tanigawa K. Segawa M. Kitao The volumetric mass transfer coefficient in bubble columns Chem. Eng. J. 22 1981 61 67
15. K. Koide A. Tekazawa M. Komura H. Matsunaga Gas holdup and volumetric mass transfer coefficient in solid-suspended bubble columns J. Chem. Eng. Jpn. 17 1984 459 466
16. K.D.P. Nigam A. Schumpe Gas-liquid mass transfer in a bubble column with suspended solids AIChE J. 33 1987 328 330
17. S.S. Öztürk A. Schumpe W.-D. Deckwer Organic liquids in a bubble column; hold-ups and mass transfer coefficients AIChE J. 33 1987 1473 1480
18. M.K. Popovic C.W. Robinson Mass transfer studies of external-loop airlifts and a bubble column AIChE J. 35 1989 393 405
19. P.M. Wilkinson L. van Dierendonck Pressure and gas density effects on bubble break up and gas hold-up in bubble columns Chem. Eng. Sci. 45 1990 2309 2315
20. I.-S. Suh A. Schumpe W.-D. Deckwer W.-M. Kulicke Gas liquid mass transfer in the bubble column with viscoelastic liquid Can. J. Chem. Eng. 69 1991 506 512
21. J. García-Ochoa R. Khalfet S. Poncin G. Wild Hydrodynamics and mass transfer in a suspended solid bubble column with polydispersed high density particles Chem. Eng. Sci. 52 1997 3827 3834
22. K. Terasaka H. Shibata Oxygen transfer in viscous non-Newtonian liquids having yield stress in bubble columns Chem. Eng. Sci. 58 2003 5331 5337
23. C.O. Vandu R. Krishna Gas hold-up and volumetric mass transfer coefficient in a slurry bubble column Chem. Eng. Technol. 26 2003 779 782
24. J.M.T. Vasconcelos J.M.L. Rodrigues S.C.P. Orvalho S.S. Alves R.L. Mendes A. Reis Effect of contaminants on mass transfer coefficients in bubble column and airlift contactors Chem. Eng. Sci. 58 2003 1431 1440
25. C.O. Vandu K. Koop R. Krishna Volumetric mass transfer coefficient in a slurry bubble column operating in the heterogeneous flow regime Chem. Eng. Sci. 59 2004 5417 5423
26. C.O. Vandu R. Krishna Influence of scale on the volumetric mass transfer coefficients in bubble columns Chem. Eng. Process. 43 2004 575 579
27. C.O. Vandu R. Krishna Volumetric mass transfer coefficients in slurry bubble columns operating in the churn-turbulent flow regime Chem. Eng. Process. 43 2004 987 995
28. P. Painmanakul K. Loubière G. Hébrard M. Mietton-Peuchot M. Roustan Effect of surfactants on liquid-side mass transfer coefficients Chem. Eng. Sci. 60 2005 6480 6491
29. A.A. Mouza G.K. Dalakoglou S.V. Paras Effect of liquid properties on the performance of bubble column reactors with fine pore spargers Chem. Eng. Sci. 60 2005 1465 1475
30. Y.T. Shah B.G. Kelkar S.P. Godbole W.-D. Deckwer Design parameter, estimations for bubble column reactors AIChE J. 28 1982 353 379
31. J.J. Heijnen K. Van’t Riet Mass transfer, mixing and heat transfer phenomena in low viscosity bubble column reactors Chem. Eng. J. 28 1984 B21 B42
32. W.-D. Deckwer A. Schumpe Improved tools for bubble column reactor design and scale-up Chem. Eng. Sci. 48 1993 889 911
33. B. Hu A.W. Nienow A.W. Pacek The effect of sodium caseinate concentration and processing conditions on bubble sizes and their break-up and coalescence in turbulent, batch air/aqueous dispersions at atmospheric and elevated pressures Colloids Surf. B: Biointerf. 31 2003 11 33
34. H.M. Letzel J.C. Schouten R. Krishna C.M. van den Bleek Gas holdup and mass transfer in bubble column reactors operated at elevated pressure Chem. Eng. Sci. 54 1999 2237 2246
35. S. Maalej B. Benadda M. Otterbein Interfacial area and volumetric mass transfer coefficient in a bubble reactor at elevated pressure Chem. Eng. Sci. 58 2003 2365 2376
36. A.-I. Galaction D. Cascaval C. Oniscu M. Turnea Prediction of oxygen mass transfer coefficients in stirred bioreactors for bacteria, yeasts and fungus broths Biochem. Eng. J. 20 2004 85 94
37. W.-D. Deckwer R. Burckhart G. Zoll Mixing and mass transfer in tall bubble columns Chem. Eng. Sci. 29 1974 2177 2188
38. L a estimation Biotechnol. Bioeng. 35 1990 1161 1163
39. E.S. Gaddis Mass transfer in gas-liquid reactors Chem. Eng. Process. 38 1999 503 510
40. C.O. Vandu J. Ellenberger R. Krishna Hydrodynamics and mass transfer in an upflow monolith loop reactor Chem. Eng. Process. 44 2005 363 374
41. H. Dhaouadi S. Poncin J.M. Hornut G. Wild P. Oinas J. Korpijarvi Mass transfer in an external-loop airlift reactor: experiments and modeling Chem. Eng. Sci. 52 1997 3909 3917
42. B.N. Thorat J.B. Joshi Regime transition in bubble columns: experimental and predictions Exp. Therm. Fluid Sci. 28 2004 423 430
43. L. Han M.H. Al-Dahhan Gas–liquid mass transfer in a high pressure bubble column reactor with different sparger designs Chem. Eng. Sci. 62 2007 131 139
44. F. Camacho Rubio J.L. Garcia E. Molina Y. Chisti Steady-state axial profiles of dissolved oxygen in tall bubble column bioreactors Chem. Eng. Sci. 54 1999 1711 1723
45. B. Gourich C. Vial A.H. Essadki F. Allam M. Belhaj Soulami M. Ziyad Identification of flow regimes and transition points in a bubble column through analysis of differential pressure signal: influence of the coalescence behaviour of the liquid phase Chem. Eng. Process. 45 2005 214 223
46. B. Gourich C. Vial N. El Azher M. Belhaj Soulami M. Ziyad Improvement of oxygen mass transfer estimation from oxygen concentration measurements in bubble column reactors Chem. Eng. Sci. 61 2006 6218 6222
47. M. Jamialahmadi H. Müller-Steinhagen Effect of alcohol, organic and potassium chloride concentration on bubble size, bubble rise velocity and gas hold-up in bubble columns Chem. Eng. J. 50 1992 47 56
48. E. Camarasa C. Vial S. Poncin G. Wild N. Midoux J. Bouillard Influence of the coalescence behaviour of the liquid and of gas sparging on hydrodynamics and bubble characteristics in a bubble column Chem. Eng. Process. 38 1999 329 344
49. 2) in organic liquids at 293.2 K J. Chem. Eng. Data 34 1989 250 252
50. K.H. Choi Y. Chisti M. Moo-Young Comparative evaluation of hydrodynamic and gas-liquid mass transfer characteristics in bubble column and airlift slurry reactors Chem. Eng. J. 62 1996 223 229
51. H. Dhaouadi S. Poncin N. Midoux G. Wild Gas-liquid mass transfer in airlift reactor—analytical solution and experimental confirmation Chem. Eng. Process. 40 2001 129 133
52. W.-D. Deckwer N. Nguyen-Tien B.G. Kelkar Y.T. Shah Applicability of axial dispersion model to analyze mass transfer measurements in bubble columns AIChE J. 29 1983 915 922
53. Ch. Vial, Apport de la mécanique des fluides à l’étude des contacteurs gaz/liquide : expérience et simulation numérique, Thèse de doctorat, INPL, Nancy, France, 2000.
54. R. Krishna M.I. Urseanu J.M. van Baten J. Ellenberger Liquid phase dispersion in bubble columns operating in the churn-turbulent flow regime Chem. Eng. J. 78 2000 43 51
55. J. Zahradník M. Fialová M. Růžička J. Drahoš F. Kaštánek N.H. Thomas Duality of the gas-liquid flow regimes in bubble column reactors Chem. Eng. Sci. 52 1997 3811 3826
56. C. Vial E. Camarasa S. Poncin G. Wild N. Midoux J. Bouillard Study of hydrodynamic behaviour in bubble columns and external-loop airlift reactors through analysis of pressure fluctuations Chem. Eng. Sci. 55 2000 2957 2973
57. R.F. Mudde D.J. Lee J. Reese L.-S. Fan Role of coherent structures on Reynolds stresses in a 2-D bubble column AIChE J. 43 1998 913 926
58. C. Vial R. Lainé S. Poncin N. Midoux G. Wild Influence of gas distribution and regime transitions on liquid velocity and turbulence in a 3-D bubble column Chem. Eng. Sci. 56 2001 1085 1093
59. K. Terasaka D. Hullmann A. Schumpe Mass transfer in bubble columns studied with oxygen optode Chem. Eng. Sci. 53 1998 3181 3184
60. A. Fadavi Y. Chisti Gas-liquid mass transfer in a novel forced circulation loop reactor Chem. Eng. J. 112 2005 73 80