Analysis of good practices, barriers and drivers for ELTs pyrolysis industrial application

Waste Management

Volumn 34, Issue 11, 2014, Pages 2335-2346

  Zabaniotou, A ^a   Antoniou, N ^a   Bruton, G ^b  

^a ARISTOTLE UNIVERSITY OF THESSALONIKI   (Greece)

^b UNIVERSITY COLLEGE CORK   (Ireland)

Author keywords

Barriers; Drivers; Economics; ELTs; Good practices; Pyrolysis

Indexed keywords

ACTIVATED CARBON; COMMERCE; ECONOMICS; LAWS AND LEGISLATION; POLLUTION CONTROL; TRUCK DRIVERS; WASTE INCINERATION; WASTE MANAGEMENT;

ACTIVATED CARBON PRODUCTION; BARRIERS; ELTS; ENVIRONMENTAL HAZARDS; GOOD PRACTICES; PRODUCT STANDARDIZATION; RESOURCE EFFICIENCIES; SCIENTIFIC RESEARCHES;

PYROLYSIS;

ACTIVATED CARBON; HEAVY METAL; PESTICIDE; INDUSTRIAL WASTE; POLYMER; RUBBER;

EUROPEAN UNION; PYROLYSIS; SUSTAINABILITY; WASTE MANAGEMENT;

ARTICLE; CONTROLLED STUDY; DEPOLYMERIZATION; ECOLOGICAL NICHE; ENERGY BALANCE; EUROPEAN UNION; HAZARD ASSESSMENT; INCINERATION; LAW; PYROLYSIS; STANDARDIZATION; ANALYSIS; CAR; INDUSTRIAL WASTE; PROCEDURES; RECYCLING; WASTE DISPOSAL;

EUROPE;

AUTOMOBILES; INCINERATION; INDUSTRIAL WASTE; POLYMERS; RECYCLING; REFUSE DISPOSAL; RUBBER;

EID: 84907712010     PISSN: 0956053X     EISSN: 18792456     Source Type: Journal    
DOI: 10.1016/j.wasman.2014.08.002     Document Type: Article

References (110)

1. Acevedo B., Barriocanal C. Fuel-oils from co-pyrolysis of scrap tyres with coal and a bituminous waste. Influence of oven configuration. Fuel 2014, 125:155-163.
2. Acevedo B., Barriocanal C., Alvarez R. Pyrolysis of blends of coal and tyre wastes in a fixed bed reactor and a rotary oven. Fuel 2013, 113:817-825.
3. Aguado R., Olazar M., Vélez D., Arabiourrutia M., Bilbao J. Kinetics of scrap tyre pyrolysis under fast heating conditions. J. Anal. Appl. Pyrol. 2005, 73:290-298.
4. Al-Saadi A.A., Saleh T.A., Gupta V.K. Spectroscopic and computational evaluation of cadmium adsorption using activated carbon produced from rubber tires. J. Mol. Liq. 2013, 188:136-142.
5. Antoniou N., Zabaniotou A. Features of an efficient and environmentally attractive used tyres pyrolysis with energy and material recovery. Renew. Sust. Energy Rev. 2013, 20:539-558.
6. Antoniou, N., Samolada, M., Stavropoulos, G., Bruton, G., Zabaniotou, A., 2012. Challenges and Barriers for the End of Life Depolymerisation: The Depotec Project, PRE XI, Thessaloniki, Greece, pp. 1187-1196.
7. Aranda A., Murillo R., García T., Mastral A.M. Simulation and optimization of tyre-based steam activated carbons production for gas-phase polycyclic aromatic hydrocarbons abatement. Chem. Eng. J. 2012, 187:123-132.
8. Aylón E., Murillo R., Fernández-Colino A., Aranda A., García T., Callén M.S., Mastral A.M. Emissions from the combustion of gas-phase products at tyre pyrolysis. J. Anal. Appl. Pyrol. 2007, 79:210-214.
9. Bayer P., Heuer E., Karl U., Finkel M. Economical and ecological comparison of granular activated carbon (GAC) adsorber refill strategies. Water Res. 2005, 39:1719-1728.
10. Berrueco C., Esperanza E., Mastral F.J., Ceamanos J., García-Bacaicoa P. Pyrolysis of waste tyres in an atmospheric static-bed batch reactor: analysis of the gases obtained. J. Anal. Appl. Pyrol. 2005, 74:245-253.
11. Bianchi M., Bortolani G., Cavazzoni M., De Pascale A., Montanari I., Nobili M., Peretto A., Tosi C., Vecci R. Preliminary design and numerical analysis of a scrap tires pyrolysis system. Energy Proc. 2014, 45:111-120.
12. Brady T.A., Rostam-Abadi M., Rood M.J. Applications for activated carbons from waste tires: natural gas storage and air pollution control. Gas Sep. Purif. 1996, 10:97-102.
13. Bunkerworld, 2014. Bunker Index.
14. California Integrated Waste Management, B., 2003. Assessment of Markets for Fiber and Steel Produced from Recycling Waste Tires. California Integrated Waste Management Board, Sacramento.
15. Centonze G., Leone M., Aiello M.A. Steel fibers from waste tires as reinforcement in concrete: a mechanical characterization. Constr. Build. Mater. 2012, 36:46-57.
16. CEPA, 2006. Technology Evaluation and Economic Analysis of Waste Tire Pyrolysis, Gasification, and Liquefaction CalRecovery Inc, California.
17. Chaala A., Roy C. Production of coke from scrap tire vacuum pyrolysis oil. Fuel Process. Technol. 1996, 46:227-239.
18. Chan O.S., Cheung W.H., McKay G. Single and multicomponent acid dye adsorption equilibrium studies on tyre demineralised activated carbon. Chem. Eng. J. 2012, 191:162-170.
19. Chang N.B. Economic and policy instrument analyses in support of the scrap tire recycling program in Taiwan. J. Environ. Manage. 2008, 86:435-450.
20. Chen K.W. The applicant feasibility study of recovered fuel after waste tire pyrolysis. Adv. Mater. Res. 2014, 852:776-779.
21. Chen T.-C., Shen Y.-H., Lee W.-J., Lin C.-C., Wan M.-W. The study of ultrasound-assisted oxidative desulfurization process applied to the utilization of pyrolysis oil from waste tires. J. Clean. Product. 2010, 18:1850-1858.
22. 2 activation of pyrolysis char. Fuel Process. Technol. 2014, 123:57-64.
23. Clauzade C., Osset P., Hugrel C., Chappert A., Durande M., Palluau M. Life cycle assessment of nine recovery methods for end-of-life tyres. Int. J. Life Cycle Assessment 2010, 15:883-892.
24. Corti A., Lombardi L. End life tyres: alternative final disposal processes compared by LCA. Energy 2004, 29:2089-2108.
25. Cunliffe A.M., Williams P.T. Composition of oils derived from the batch pyrolysis of tyres. J. Anal. Appl. Pyrol. 1998, 44:131-152.
26. Curran T., Williams I.D. A zero waste vision for industrial networks in Europe. J. Hazard. Mater. 2012, 207-208:3-7.
27. de Marco Rodriguez I., Laresgoiti M.F., Cabrero M.A., Torres A., Chomón M.J., Caballero B. Pyrolysis of scrap tyres. Fuel Process. Technol. 2001, 72:9-22.
28. DEPOTEC, 2011-2014. LIFE10 ENV/IE/000695, Depolymerisation Technology for Rubber with Energy Optimisation to Produce Carbon Products.
29. Díez C., Martínez O., Calvo L.F., Cara J., Morán A. Pyrolysis of tyres. Influence of the final temperature of the process on emissions and the calorific value of the products recovered. Waste Manage. (Oxford) 2004, 24:463-469.
30. Díez C., Sánchez M.E., Haxaire P., Martínez O., Morán A. Pyrolysis of tyres: a comparison of the results from a fixed-bed laboratory reactor and a pilot plant (rotatory reactor). J. Anal. Appl. Pyrol. 2005, 74:254-258.
31. E.P.A., U.S., 1997. Air Emissions from Scrap Tire Combustion.
32. E.P.A., U.S., 1999. In-Use Marine Diesel Fuel.
33. E.U.-Directive, 1999. Council Directive 1999/31/EC of 26 April 1999 on the Landfill of Waste.
34. E.U.-Directive, 2008. DIRECTIVE 2008/98/EC OF THE EUROPEAN PARLIAMENT AND OF THE COUNCIL of 19 November 2008 on Waste and Repealing Certain Directives.
35. E.U.-Directive, 2012. Directive 2012/33/EU of the European Parliament and of the Council of 21 November 2012 Amending Council Directive 1999/32/EC as Regards the Sulphur Content of Marine Fuels.
36. Edwin Raj R., Robert Kennedy Z., Pillai B.C. Optimization of process parameters in flash pyrolysis of waste tyres to liquid and gaseous fuel in a fluidized bed reactor. Energy Convers. Manage. 2013, 67:145-151.
37. EPD, 2011. Ministry of the Environment: A Technical Review of Municipal Solid Waste Thermal Treatment Practices: FINAL REPORT Stantec, Victoria, Canada.
38. ETRA, 1996. European Tyre Recycling Association.
39. ETRA, 2012. European Tyre Recycling Association 2012 Report.
40. ETRA, 2014. Annual Conference 2014, Pyrolysis Forum.
41. ETRMA, 1959. European Tyre & Rubber Manufacturing Association.
42. ETRMA, 2009. End of Life Tyre Guidance. Tyre Generic Exposure Scenario, Brussels, Belgium.
43. ETRMA, 2010. A Framework for Effective Management Systems, Brussels, Belgium.
44. ETRMA, 2013a. Annual Report 2012-2013.
45. ETRMA, 2013b. Statistics.
46. EU-BREF, 2006. Reference Document on the Best Available Techniques for Waste Incineration.
47. Eurostat, 2014. Labour Cost Index - Recent Trends.
48. Fabbri D., Vassura I. Evaluating emission levels of polycyclic aromatic hydrocarbons from organic materials by analytical pyrolysis. J. Anal. Appl. Pyrol. 2006, 75:150-158.
49. Fink J.K. Pyrolysis and combustion of polymer wastes in combination with metallurgical processes and the cement industry. J. Anal. Appl. Pyrol. 1999, 51:239-252.
50. Foo K.Y., Hameed B.H. Detoxification of pesticide waste via activated carbon adsorption process. J. Hazard. Mater. 2010, 175:1-11.
51. Freedonia-Study, 2013. Activated Carbon, US Industry Study with Forecasts for 2017 and 2022. Freedonia Group.
52. Frigo S., Seggiani M., Puccini M., Vitolo S. Liquid fuel production from waste tyre pyrolysis and its utilisation in a diesel engine. Fuel 2014, 116:399-408.
53. Gabarrell X., Font M., Vicent T., Caminal G., Sarrà M., Blánquez P. A comparative life cycle assessment of two treatment technologies for the Grey Lanaset G textile dye: biodegradation by Trametes versicolor and granular activated carbon adsorption. Int. J. Life Cycle Assessment 2012, 17:613-624.
54. Gieré R., Stille P. Energy, Waste and the Environment: A Geochemical Perspective 2004, Geological Society Publishing House.
55. Graeff A.G., Pilakoutas K., Neocleous K., Peres M.V.N.N. Fatigue resistance and cracking mechanism of concrete pavements reinforced with recycled steel fibres recovered from post-consumer tyres. Eng. Struct. 2012, 45:385-395.
56. Gupta V.K., Gupta B., Rastogi A., Agarwal S., Nayak A. Pesticides removal from waste water by activated carbon prepared from waste rubber tire. Water Res. 2011, 45:4047-4055.
57. Gupta V.K., Ganjali M.R., Nayak A., Bhushan B., Agarwal S. Enhanced heavy metals removal and recovery by mesoporous adsorbent prepared from waste rubber tire. Chem. Eng. J. 2012, 197:330-342.
58. Gupta V., Ali I., Saleh T., Siddiqui M.N., Agarwal S. Chromium removal from water by activated carbon developed from waste rubber tires. Environ. Sci. Pollut. Res. 2013, 20:1261-1268.
59. Gupta V.K., Suhas, Nayak A., Agarwal S., Chaudhary M., Tyagi I. Removal of Ni (II) ions from water using scrap tire. J. Mol. Liq. 2014, 190:215-222.
60. Hajizadeh Y., Onwudili J.A., Williams P.T. Removal potential of toxic 2378-substituted PCDD/F from incinerator flue gases by waste-derived activated carbons. Waste Manage. (Oxford) 2011, 31:1194-1201.
61. Haydary J., Jelemenský Ľ., Gašparovič L., Markoš J. Influence of particle size and kinetic parameters on tire pyrolysis. J. Anal. Appl. Pyrol. 2012, 97:73-79.
62. Hjaila K., Baccar R., Sarrà M., Gasol C.M., Blánquez P. Environmental impact associated with activated carbon preparation from olive-waste cake via life cycle assessment. J. Environ. Manage. 2013, 130:242-247.
63. 2 removal under dry conditions at room temperature. Chem. Eng. J. 2011, 170:202-208.
64. Honus S., Juchelkova D., Campen A., Wiltowski T. Gaseous components from pyrolysis-characteristics, production and potential for energy utilization. J. Anal. Appl. Pyrol. 2014, 106:1-8.
65. Hu H., Fang Y., Liu H., Yu R., Luo G., Liu W., Li A., Yao H. The fate of sulfur during rapid pyrolysis of scrap tires. Chemosphere 2014, 97:102-107.
66. Huang H., Tang L. Pyrolysis treatment of waste tire powder in a capacitively coupled RF plasma reactor. Energy Convers. Manage. 2009, 50:611-617.
67. Ie I.-R., Chen W.-C., Yuan C.-S., Hung C.-H., Lin Y.-C., Tsai H.-H., Jen Y.-S. Enhancing the adsorption of vapor-phase mercury chloride with an innovative composite sulfur-impregnated activated carbon. J. Hazard. Mater. 2012, 217-218:43-50.
68. Ioannidou, O., 2011. Activated Carbon Production from Agricultural Biomass and Their Use in the Removal Of Selected Pesticides, Phd Thesis of Chemical Engineering Department, Thessaloniki.
69. Ioannidou O., Zabaniotou A. Agricultural residues as precursors for activated carbon production-a review. Renew. Sust. Energy Rev. 2007, 11:1966-2005.
70. Islam M.R., Joardder M.U.H., Hasan S.M., Takai K., Haniu H. Feasibility study for thermal treatment of solid tire wastes in Bangladesh by using pyrolysis technology. Waste Manage. (Oxford) 2011, 31:2142-2149.
71. Islam M.R., Islam M.N., Mustafi N.N., Rahim M.A., Haniu H. Thermal recycling of solid tire wastes for alternative liquid fuel: the first commercial step in Bangladesh. Proc. Eng. 2013, 56:573-582.
72. Kebritchi A., Firoozifar H., Shams K., Jalali-Arani A. Effect of pre-devulcanization and temperature on physical and chemical properties of waste tire pyrolytic oil residue. Fuel 2013, 112:319-325.
73. Laresgoiti M.F., Caballero B.M., de Marco I., Torres A., Cabrero M.A., Chomón M.J. Characterization of the liquid products obtained in tyre pyrolysis. J. Anal. Appl. Pyrol. 2004, 71:917-934.
74. Li L., Liu S., Zhu T. Application of activated carbon derived from scrap tires for adsorption of Rhodamine B. J. Environ. Sci. 2010, 22:1273-1280.
75. Li X., Xu H., Gao Y., Tao Y. Comparison of end-of-life tire treatment technologies: a Chinese case study. Waste Manage. (Oxford) 2010, 30:2235-2246.
76. Lopez G., Aguado R., Olazar M., Arabiourrutia M., Bilbao J. Kinetics of scrap tyre pyrolysis under vacuum conditions. Waste Manage. (Oxford) 2009, 29:2649-2655.
77. López F.A., Centeno T.A., Alguacil F.J., Lobato B., Urien A. The GRAUTHERMIC-Tyres process for the recycling of granulated scrap tyres. J. Anal. Appl. Pyrol. 2013, 103:207-215.
78. Marsh H., Reinoso F.R. Activated Carbon 2006, Elsevier Science, Oxford, UK. first ed.
79. Martínez J.D., Murillo R., García T., Veses A. Demonstration of the waste tire pyrolysis process on pilot scale in a continuous auger reactor. J. Hazard. Mater. 2013, 261:637-645.
80. Martínez J.D., Puy N., Murillo R., García T., Navarro M.V., Mastral A.M. Waste tyre pyrolysis - a review. Renew. Sust. Energy Rev. 2013, 23:179-213.
81. Martínez J.D., Rodríguez-Fernández J., Sánchez-Valdepeñas J., Murillo R., García T. Performance and emissions of an automotive diesel engine using a tire pyrolysis liquid blend. Fuel 2014, 115:490-499.
82. Mastral A.M., Murillo R., Callen M.S., Garcia T. Optimisation of scrap automotive tyres recycling into valuable liquid fuels. Resour. Conserv. Recycl. 2000, 29:263-272.
83. Mui E.L.K., Ko D.C.K., McKay G. Production of active carbons from waste tyres--a review. Carbon 2004, 42:2789-2805.
84. Mui E.L.K., Cheung W.H., Valix M., McKay G. Mesoporous activated carbon from waste tyre rubber for dye removal from effluents. Micropor. Mesopor. Mater. 2010, 130:287-294.
85. Papakonstantinou C.G., Tobolski M.J. Use of waste tire steel beads in Portland cement concrete. Cement Concrete Res. 2006, 36:1686-1691.
86. PAS-107, 2012. Specification for the manufacture and storage of size reduced tyre materials. European Committee for Standardization.
87. Peters M.S., Timmerhaus K.D., West R.E., Timmerhaus K., West R. Plant Design and Economics for Chemical Engineers 1968, McGraw-Hill, New York.
88. REACH, 2006. REACH Directive. In: EU (Ed.).
89. RMA, 2009. U.S. Scrap Tire Market Summary.
90. Roy C., Rastegar A., Kaliaguine S., Darmstadt H., Tochev V. Physicochemical properties of carbon blacks from vacuum pyrolysis of used tires. Plast. Rub. Compos. Process. Appl. 1995, 23:21-30.
91. Saleh T.A., Gupta V.K., Al-Saadi A.A. Adsorption of lead ions from aqueous solution using porous carbon derived from rubber tires: experimental and computational study. J. Colloid Interface Sci. 2013, 396:264-269.
92. Samolada M.C., Zabaniotou A.A. Potential application of pyrolysis for the effective valorisation of the end of life tires in Greece. Environ. Dev. 2012, 4:73-87.
93. Shah J., Jan M.R., Mabood F. Recovery of value-added products from the catalytic pyrolysis of waste tyre. Energy Convers. Manage. 2009, 50:991-994.
94. Sienkiewicz M., Kucinska-Lipka J., Janik H., Balas A. Progress in used tyres management in the European Union: a review. Waste Manage. (Oxford) 2012, 32:1742-1751.
95. Skodras G., Diamantopoulou I., Zabaniotou A., Stavropoulos G., Sakellaropoulos G.P. Enhanced mercury adsorption in activated carbons from biomass materials and waste tires. Fuel Process. Technol. 2007, 88:749-758.
96. Stavropoulos G.G. Precursor materials suitability for super activated carbons production. Fuel Process. Technol. 2005, 86:1165-1173.
97. Stavropoulos G.G., Zabaniotou A.A. Minimizing activated carbons production cost. Fuel Process. Technol. 2009, 90:952-957.
98. Tanthapanichakoon W., Ariyadejwanich P., Japthong P., Nakagawa K., Mukai S.R., Tamon H. Adsorption-desorption characteristics of phenol and reactive dyes from aqueous solution on mesoporous activated carbon prepared from waste tires. Water Res. 2005, 39:1347-1353.
99. TRA, 2012. Specification for the manufacture and storage of size reduced tyre materials. Tyre Recovery Association.
100. Troca-Torrado C., Alexandre-Franco M., Fernández-González C., Alfaro-Domínguez M., Gómez-Serrano V. Development of adsorbents from used tire rubber: their use in the adsorption of organic and inorganic solutes in aqueous solution. Fuel Process. Technol. 2011, 92:206-212.
101. UNI-CEN/TS-14243, 2010. Materials produced from end of life tyres - specification of categories based on their dimension(s) and impurities and methods for determining their dimension(s) and impurities. European Commitee for Standardization.
102. Uruburu Á., Ponce-Cueto E., Cobo-Benita J.R., Ordieres-Meré J. The new challenges of end-of-life tyres management systems: a Spanish case study. Waste Manage. (Oxford) 2013, 33:679-688.
103. WFD, 2008. Waste Framework Directive.
104. WID, 2008. Waste Incineration Directive.
105. Williams P.T. Pyrolysis of waste tyres: a review. Waste Manage. (Oxford) 2013, 33:1714-1728.
106. Williams P.T., Brindle A.J. Aromatic chemicals from the catalytic pyrolysis of scrap tyres. J. Anal. Appl. Pyrol. 2003, 67:143-164.
107. Wilts H., Dehoust G., Jepsen D., Knappe F. Eco-innovations for waste prevention-best practices, drivers and barriers. Sci. Total Environ. 2013, 461-462:823-829.
108. WRAP, 2009. Protocol for Tyre Derived Rubber Materials.
109. Zabaniotou A.A., Stavropoulos G. Pyrolysis of used automobile tires and residual char utilization. J. Anal. Appl. Pyrol. 2003, 70:711-722.
110. 2 mixture. J. Anal. Appl. Pyrol. 2004, 72:289-297.