The properties of large bubbles rising in very viscous liquids in vertical columns

International Journal of Multiphase Flow

Volumn 67, Issue , 2014, Pages 160-173

  Azzopardi, B J ^a   Pioli, L ^b   Abdulkareem, L A ^c  

^a UNIVERSITY OF NOTTINGHAM   (United Kingdom)

^b UNIVERSITY OF GENEVA   (Switzerland)

^c UNIVERSITY OF ZAKHO   (Iraq)

Author keywords

Bubble column; Gas liquid; Slug; Viscous

Indexed keywords

SLUG; VERTICAL COLUMNS; VISCOUS; VISCOUS LIQUIDS;

BUBBLE COLUMNS;

EID: 84906830707     PISSN: 03019322     EISSN: None     Source Type: Journal    
DOI: 10.1016/j.ijmultiphaseflow.2014.08.013     Document Type: Article

References (54)

1. Azzopardi B.J., Zaidi S.H. Determination of entrained fraction in vertical annular gas/liquid flow. J. Fluids Eng. 2000, 122:146-150.
2. Azzopardi B.J., Jackson K., Robinson J.P., Kaji R., Byars M., Hunt A. Fluctuations in dense phase pneumatic conveying of pulverised coal measured using electrical capacitance tomography. Chem. Eng. Sci. 2008, 63:2548-2558.
3. Azzopardi B.J. Flow patterns: does gas/solids flow pattern correspond to churn flow in gas/liquid flow. Ind. Eng. Chem. Res. 2008, 47:7934-7939.
4. Azzopardi B.J., Abdulkareem L.A., Zhao D., Thiele S., da Silva M.J., Beyer M., Hunt A. Comparison between Electrical Capacitance Tomography and Wire Mesh Sensor output for air/silicone oil flow in a vertical pipe. Ind. Eng. Chem. Res. 2010, 49:8805-8811.
5. Bird J.C., de Ruiter R., Courbin L., Stone H.A. Daughter bubble cascades produced by ruptured thin films. Nature 2010, 465:759-762.
6. Blackburn E.A., Wilson L., Sparks R.S.J. Mechanisms and dynamics of Strombolian activity. J. Geolog. Soc. London 1976, 132:429-440.
7. Brown R.A.S. The mechanics of large gas bubbles in tubes: I. Bubble velocities in stagnant liquids. Can. J. Chem. Eng. 1965, 43:217-223.
8. Byars, M., Pendleton, J.D., 2003. A new high-speed control interface for an electric capacitance tomography system. In: 3rd World Congress on Industrial Process Tomography, Banff, Canada.
9. Chen Z., Gibilaro L.G., Foscolo P.U. Fluid pressure loss in slugging fluidised beds. Chem. Eng. Sci. 1997, 52:55-62.
10. Chirinos M.L., González J., Layrisse I. Rheological properties of crude oils from the Orinico oil belt and their mixtures with diluents. Revist. Téch. Intevep 1983, 3:103-115.
11. Collins R., Moraes F.F., Davidson J.F., Harrison D. The motion of a large gas bubble rising though liquid flowing in a tube. J. Fluid Mech. 1978, 89:497-514.
12. Cong X., Guo X., Lu H., Gong X., Liu K., Xie K., Sun X. Flow pattern characteristics in vertical dense-phase pneumatic conveying of pulverized coal using Electrical Capacitance Tomography. Ind. Eng. Chem. Res. 2012, 51:15268-15275.
13. Costigan G., Whalley P.B. Slug flow regime identification from dynamic void fraction measurements in vertical air-water flows. Int. J. Multiphase Flow 1997, 23:263-282.
14. da Silva M.J., Thiele S., Abdulkareem L., Azzopardi B.J., Hampel U. High-resolution gas-oil two-phase flow visualization with a capacitance wire-mesh sensor. Flow Meas. Instr. 2010, 21:191-197.
15. Davies R.M., Taylor G.I. The mechanics of large bubbles rising through liquids in tubes. Proc. Roy. Soc. 1950, A200:375-390.
16. Dukler A.E., Fabre J. Gas liquid slug flow. Multiphase Sci. Technol. 1994, 8:355-469.
17. Dumitrescu D.T. Stromung an einer luftblase im senkrechten rohr. Z. Angew. Math. Mech. 1943, 23:139-149.
18. Frankel N.A., Acrivos A. The constitutive equation for a dilute emulsion. J. Fluid Mech. 1970, 44:65-79.
19. Fraser R.P., Dombrowski N., Routley J.H. The atomization of a liquid sheet by an impinging air stream. Chem. Eng. Sci. 1963, 18:339-353.
20. Goldsmith H.L., Mason S.G. The movement of single large bubbles in closed vertical tubes. J. Fluid Mech. 1962, 14:42-58.
21. Gonnermann H., Manga M. Dynamics of magma ascent in the volcanic conduit. Modeling Volcanic Processes: The Physics and Mathematics of Volcanism 2013, 55-84. Cambridge University Press, Cambridge. S. Fagents, T.G. Gregg, R. Lopez (Eds.).
22. Grace J.R., Krockmalnek J.S., Clift R., Farkas E.J. Expansions of liquids and fluidized beds in slug flow. Chem. Eng. Sci. 1971, 26:617-628.
23. Guet S., Ooms G., Oliemans R.V.A., Mudde R.F. Bubble size effect on low liquid input drift-flux parameters. Chem. Eng. Sci. 2004, 59:3315-3329.
24. Hayashi K., Kurimoto R., Tomiyama A. Terminal velocities of a Taylor drop in a vertical pipe. Int. J. Multiphase Flow 2011, 37:241-251.
25. Hinch E.J., Acrivos A. Long slender drops in a simple shear flow. J. Fluid Mech. 1980, 98:305-328.
26. James M.R., Lane S.J., Wilson L., Corder S.B. Degassing at low magma-viscosity volcanoes: Quantifying the transition between passive bubble-burst and Strombolian eruption. J Volcanol. Geotherm. Res. 2009, 180:81-88.
27. James M.R., Lane S.J., Corder S.B. Modelling the rapid near-surface expansion of gas 307 slugs in low-viscosity magmas. Fluid Motions in Volcanic Conduits: A Source of Seismic and Acoustic Signals 2009, 147-167. Geological Society, Special Publications, London. S.J. Lane, J.S. Gilbert (Eds.).
28. Kaji R., Zhao D., Licence P., Azzopardi B.J. Studies of the interaction of ionic liquid and gas in a small diameter bubble column. Ind. Eng. Chem. Res. 2009, 48:7938-7944.
29. Kajero, O.T., Azzopardi, B.J., Abdulkareem, L., 2012. Experimental investigation of the effect of liquid viscosity on slug flow in small diameter bubble columns. EPJ Web of Conferences, 010. http://dx.doi.org/10.1051/epjconf/201225010.
30. Khatib Z., Richardson J.F. Vertical co-current flow of air and shear thinning suspensions of kaolin. Chem. Eng. Res. Des. 1984, 62:139-154.
31. King D.F., Mitchell F.R.G., Harrison D. Dense phase viscosities of fluidised beds at elevated pressures. Powder Technol. 1981, 28:55-58.
32. Kurimoto R., Hayashi K., Tomiyama A. Terminal velocities of clean and fully contaminated drops in vertical pipes. Int. J. Multiphase Flow 2013, 49:8-23.
33. Llewellin E.W., Del Bello E., Taddeucci J., Scarlato P., Lane S.J. The thickness of the falling film of liquid around a Taylor bubble. Proc. Roy. Soc. 2012, A468(2140):1041-1064. 10.1098/rspa.2011.0476.
34. Lu X., Prosperetti A. A numerical study of Taylor bubbles. Ind. Eng. Chem. Res. 2009, 48:242-252.
35. Mader H.M., Llewellin E.W., Mueller S.P. The rheology of two-phase magmas: a review and analysis. J. Volc. Geotherm. Res. 2013, 257:135-158.
36. Matsen J.M., Hovmand S., Davidson J.F. Expansion of fluidized beds in slug flow. Chem. Eng. Sci. 1969, 24:1743-1754.
37. Nicklin D.J., Wilkes J.O., Davidson J.F. Two-phase flow in vertical tubes. Trans. Inst. Chem. Eng. 1962, 40:61-68.
38. Nogueira S., Riethmuler M.L., Campos J.B.L.M., Pinto A.M.F.R. Flow in the nose region and annular film around a Taylor bubble rising through vertical columns of stagnant and flowing Newtonian liquids. Chem. Eng. Sci. 2006, 61:845-857.
39. Nusselt W. Die Oberflachenkondensation des Wasserdamphes. Z. VDI 1916, 60:541-546.
40. Padmanaban, A., 2006. Film thickness measurements in falling annular films. MSc Thesis, University of Saskatchan, Saskatoon, Saskatchewan, Canada.
41. Pal R. Rheological behavior of bubble-bearing magmas. Earth Planetary Sci. Lett. 2003, 207:165-179.
42. Pal R. Rheological constitutive equation for Bubbly suspensions. Ind. Eng. Chem. Res. 2004, 43:5372-5379.
43. Philip J., Proctor J.M., Niranyan K., Davidson J.F. Gas hold-up and liquid recirculation in internal loop columns containing highly viscous Newtonian and non-Newtonian liquids. Chem. Eng. Sci. 1990, 45:651-664.
44. Pioli L., Bonadonna C., Azzopardi B.J., Phillips J., Ripepe M. Experimental constraints on the outgassing dynamics of basaltic magmas. J. Geophys. Res. - Solid Earth 2012, 117:B03204. 10.1029/2011JB008392.
45. Sauter, J., 1926. Die groessenbestimmung der im gemischnebel von verbrennungskraftmaschinen vorhandenen brennstoffteilchen. VDI Forsch. 279.
46. Sekoguchi, K., Mori, K., 1997. New development of experimental study on interfacial structure in gas-liquid two-phase flow. In: Giot, M., Mayinger, F., Celata, G.-P., (Eds.), Experimental Heat Transfer, Fluid Mechanics and Thermodynamics, (Edizione ETS) 2, pp. 1177-1188.
47. Sharaf S., Da Silva M., Hampel U., Zippe C., Beyer M., Azzopardi B. Comparison between wire mesh sensor technology and gamma densitometry. Meas. Sci. Technol. 2011, 22. 104019 (13 pp).
48. Shu W.R. A viscosity correlation for mixtures of heavy oil, bitumen and petroleum fractions. Soc. Pet. Eng. J. 1984, 277-282.
49. Stein D.J., Spera F.J. Rheology ad microstructure of magmatic emulsions: theory and experiments. J. Volcanol. Geoth. Res. 1992, 49:157-174.
50. Taha T., Cui Z.F. CFD modelling of slug flow in vertical tubes. Chem. Eng. Sci. 2006, 61:676-687.
51. Taylor G.I. The viscosity of a fluid containing small drops of another fluid. Proc. Roy. Soc. 1932, A138:41-48.
52. Taylor G.I. The formation of emulsions in definable fields of flow. Proc. Roy. Soc. 1934, A146:501-523.
53. Viana F., Pardo R., Yanez R., Trallero J.L., Joseph D.D. Universal correlation for the rise velocity of long gas bubbles in round pipes. J. Fluid Mech. 2003, 494:379-398.
54. White E.T., Beardmore R.H. The velocity of rise of single cylindrical air bubbles through liquids contained in vertical tubes. Chem. Eng. Sci. 1962, 17:351-361.