Effects of hydrophilic particles on bubbly flow in slurry bubble column

International Journal of Multiphase Flow

Volumn 58, Issue , 2014, Pages 154-167

  Ojima, Shimpei ^a   Hayashi, Kosuke ^a   Tomiyama, Akio ^a  

^a KOBE UNIVERSITY   (Japan)

Author keywords

Bubble coalescence; Bubble column; Multi fluid model; Simulation; Slurry

Indexed keywords

BUBBLE COALESCENCE; EFFICIENCY MODELS; HYDROPHILIC PARTICLES; MULTI-FLUID MODELS; PARTICLE CONCENTRATIONS; SIMULATION; SLURRY BUBBLE COLUMN; VOLUMETRIC CONCENTRATIONS;

FLOCCULATION; HYDROPHILICITY; SLURRIES;

BUBBLE COLUMNS;

EID: 84885064844     PISSN: 03019322     EISSN: None     Source Type: Journal    
DOI: 10.1016/j.ijmultiphaseflow.2013.09.005     Document Type: Article

References (49)

1. Ata S., Ahmed N., Jameson G.J. A study of bubble coalescence in flotation froths. Int. J. Miner. Process. 2003, 72:255-266.
2. Baird M.H.I., Rice R.G. Axial dispersion in large unbaffled columns. Chem. Eng. J. 1975, 9:171-174.
3. Brackbill J.U., Kothe D.B., Zemach C. A continuum method for modeling surface tension. J. Comput. Phys. 1992, 100:335-354.
4. Chen P., Sanyal J., Dudukovic M.P. CFD modeling of bubble columns flows: implementation of population balance. Chem. Eng. Sci. 2004, 59:5201-5207.
5. Clift R., Gauvin W.H. Motion of entrained particle in gas stream. Can. J. Chem. Eng. 1971, 49:439-449.
6. Davidson M.A., Schuler B.O.G. Bubble formation an orifice in an inviscid liquid. Trans. Inst. Chem. Eng. 1960, 38:335-342.
7. de Swart J.W.A., van Vliet R.E., Krishna R. Size, structure and dynamics of "large" bubbles in a two-dimensional slurry bubble column. Chem. Eng. Sci. 1996, 51:4619-4629.
8. Galetl L., Ouabbas Y., Chamayoul A., Grosseau P., Baronl M., Thomas G. Surface analysis of silica gel particles after mechanical dry coating with magnesium stearate. Powder. Part. J. 2010, 28:209-218.
9. Gallegos-Acevedo P.M., Espinoza-Cuadra J., Pérez-Garibay R., Pecina-Treviño E.T. Bubbles coalescence: hydrofobic particles effect. J. Min. Sci. 2010, 46:333-337.
10. Gandhi B., Prakash A., Bergougnou M.A. Hydrodynamic behavior of slurry bubble column at high solids concentrations. Powder Technol. 1999, 103:80-94.
11. Garnier C., Lance M., Marie J.L. Measurement of local flow characteristics in buoyancy-driven bubble flow at high void fraction. Exp. Therm. Fluid Sci. 2002, 26:811-815.
12. Gmachowski L. Flow drag in heterogeneous systems over wide intervals of porosity and Reynolds number. J. Chem. Eng. Jpn. 1996, 29:897-900.
13. Hillmer G., Weismantel L., Hofmann H. Investigations and modeling of slurry bubble columns. Chem. Eng. Sci. 1994, 49:837-843.
14. Jianping W., Shonglin X. Local hydrodynamics in a gas-liquid-solid three-phase bubble column reactor. Chem. Eng. J. 1998, 70:81-84.
15. Joshi K.S., Baumann A., Jeelani S.A.K., Blickenstorfer C., Naegeli I., Windhab E.J. Mechanism of bubble coalescence induced by surfactant covered antifoam particles. J. Colloid Interface Sci. 2009, 339:446-453.
16. Khare A.S., Joshi J.B. Effect of fine particles on gas hold-up in three-phase sparged reactors. Chem. Eng. J. 1990, 44:11-25.
17. Kim W.K., Lee K.L. Coalescence behavior of two bubbles in stagnant liquids. J. Chem. Eng. Jpn. 1987, 20:449-453.
18. Kirkpatrick R.D., Lockett M.J. The influence of approach velocity on bubble coalescence. Chem. Eng. Sci. 1974, 29:2363-2373.
19. Koide K., Takazawa A., Komura M., Matsunaga H. Gas holdup and volumetric liquid-phase mass transfer coefficient in solid-suspended bubble column. J. Chem. Eng. Jpn. 1984, 17:459-466.
20. Krishna R., de Swart J.W.A., Ellenberger J., Martina G.B., Maretto C. Gas holdup in slurry bubble columns: effect of column diameter and slurry concentrations. AIChE J. 1997, 43:311-316.
21. Kumar S., Ramkrishna D. On the solution of population balance equations by discretization - I. A fixed technique. Chem. Eng. Sci. 1996, 51:1311-1332.
22. Lakota A., Jazbec M., Levec J. Impact of structured packing on bubble column mass transfer characteristics, Part 1. Backmixing in the liquid phase. Acta Chim. Slov. 2001, 48:453-468.
23. Levich V.G. Physicochemical Hydrodynamics 1962, Prentice Hall.
24. Li H., Prakash A. Heat transfer and hydrodynamics in a three-phase slurry bubble column. Ind. Eng. Chem. Res. 1997, 36:4688-4694.
25. Li H., Prakash A. Influence of slurry concentrations on bubble population and their rise velocities in a three-phase slurry bubble column. Powder Technol. 2000, 113:158-167.
26. Lopez de Bertodano M., Lahey R.T., Jones O.C. Phase distribution in bubbly two-phase flow in vertical ducts. Int. J. Multiphase Flow 1994, 20:805-818.
27. Luo S., Svendsen H.F. Theoretical model for drop and bubble breakup in turbulent dispersions. AIChE J. 1996, 42:1225-1233.
28. Maekawa M., Sou A., Hosokawa S., Tomiyama A. Effects of inlet bubble diameter on bubbly flow in a bubble column under high gas volume flux condition. Trans. Jpn. Soc. Mech. Eng. Ser. B 2008, 74:1368-1375. (in Japanese).
29. Mena P.C., Ruzicka M.C., Rocha F.A., Teixeira J.A., Drahos J. Effect of solids on homogeneous-heterogeneous flow regime transition in bubble columns. Chem. Eng. Sci. 2005, 60:6013-6026.
30. Omota, F., 2005. Adhesion of Catalyst Particles to Gas Bubbles. Ph.D. Thesis. University of Amsterdam.
31. Prince M.J., Blanch H.W. Bubble coalescence and break-up in air-sparged bubble columns. AIChE J. 1990, 36:1485-1499.
32. Sanchez Perez J.A., Rodriguez Porcel E.M., Casas Lopez J.L., Fernandez Sevilla J.M., Chisti Y. Shear rate in stirred tank and bubble column bioreactors. Chem. Eng. J. 2006, 124:1-5.
33. Su X., Hol P.D., Talcott S.M., Staudt A.K., Heindel T.J. The effect of bubble column diameter on gas holdup in fiber suspension. Chem. Eng. Sci. 2006, 61:3098-3104.
34. Tadaki T., Maeda S. On the shape and velocity of single air bubbles rising in various liquids. Kagaku Kogaku 1961, 25:254-264.
35. Tanaka M., Hayashi K., Tomiyama A. Numerical simulation of poly-dispersed bubbly folws on bubble columns using a multi-fluid model. Trans. Jpn. Soc. Mech. Eng. Ser. B 2009, 75:2182-2189. (in Japanese).
36. Tomiyama A., Shimada N. (N+2)-Field modeling for bubbly flow simulation. Comput. Fluid Dyn. J. 2001, 9:418-426.
37. Tomiyama A., Kataoka I., Takumi F., Sakaguchi T. Drag coefficients of bubbles: 2nd report, drag coefficient for a swarm of bubbles and its applicability to transient flow. Trans. Jpn. Soc. Mech. Eng. Ser. B 1995, 61:2810-2817. (in Japanese).
38. Tomiyama A., Kataoka I., Zun I., Sakaguchi T. Drag coefficients of single bubbles under normal and micro gravity conditions. JSME Int. J. 1998, 42:472-479.
39. Tomiyama A., Tamai H., Zun I., Hosokawa S. Transverse migration of single bubbles in simple shear flows. Chem. Eng. Sci. 2002, 57:1846-1858.
40. Tomiyama A., Sakoda K., Hayashi K., Sou A., Shimada N., Hosokawa S. Modeling and hybrid simulation of bubbly flow. Multiphase Sci. Technol. 2006, 18:73-110.
41. Troshko A.A., Zdravistch F. CFD modeling of slurry bubble column reactors for Fisher-Tropsch synthesis. Chem. Eng. Sci. 2009, 64:892-903.
42. Tryggvason G., Scardovelli R., Zaleski S. Direct Numerical Simulations of Gas-Liquid Multiphase Flows 2011, Cambridge University Press.
43. Tsuchiya K., Furumoto A., Fan L.S., Zhang J. Suspension viscosity and bubble rising velocity in liquid-solid fluidized beds. Chem. Eng. Sci. 1997, 18:3053-3065.
44. Vakrushev I.A., Efremov G.I. Interpolation formula for computing the velocities of single gas bubbles in liquids. Chem. Technol. Fuels Oils 1970, 376-379.
45. van der Zon M., Hamersma P.J., Poels E.K., Bliek A. Coalescence of freely moving bubbles in water by the action of suspended hydrophobic particles. Chem. Eng. Sci. 2002, 57:4845-4853.
46. Vandu C.O., Krishna R. Volumetric mass transfer coefficient in a slurry bubble column operating in the heterogeneous flow regime. Chem. Eng. Sci. 2004, 59:5417-5423.
47. Wang T., Wang J., Jin Y. Theoretical prediction of flow regime transition in bubble columns by the population balance model. Chem. Eng. Sci. 2005, 60:6199-6209.
48. Yasunishi A., Fukuda M., Muroyama K. Measurement of behavior of gas bubbles and gas holup in a slurry bubble column by a dual electroresistivity probe method. J. Chem. Eng. Jpn. 1986, 19:444-449.
49. Žun I., Filipič B., Perpar M., Bombač A. Phase discrimination in void fraction measurements via generic algorithms. Rev. Sci. Instrum. 1995, 66:5055-5064.