Preparation and characterization of asymmetric membranes based on nonsolvent/NMP/P84 for gas separation

Journal of Membrane Science

Volumn 429, Issue , 2013, Pages 155-167

  Lua, Aik Chong ^a   Shen, Yi ^a  

^a NANYANG TECHNOLOGICAL UNIVERSITY   (Singapore)

Author keywords

Gas separation; P84 asymmetric membranes; Wet phase inversion and atomic force microscopy

Indexed keywords

AFM; ASYMMETRIC MEMBRANES; BET SURFACE AREA; CASTING SOLUTIONS; CHEMICAL MIXTURES; COAGULATION TEMPERATURE; EVAPORATION TIME; GAS SEPARATIONS; KINETIC PROPERTIES; MEMBRANE PREPARATION; NANOMETRES; NON-SOLVENTS; P84 CO-POLYIMIDES; PERMEATION TEST; SKIN LAYER; SKIN SURFACES; SKIN THICKNESS; SOLUTION CONCENTRATION; TAPPING-MODE ATOMIC FORCE MICROSCOPY; WET-PHASE INVERSION;

ATOMIC FORCE MICROSCOPY; CARBON DIOXIDE; COAGULATION; GASES; MEMBRANE STRUCTURES; POLYIMIDES; SCANNING ELECTRON MICROSCOPY; SEPARATION;

GAS PERMEABLE MEMBRANES;

ACETONE; ALCOHOL; BENZOPHENONE DERIVATIVE; CARBON DIOXIDE; DIAMINE; HELIUM; NANOPARTICLE; NITROGEN; OXYGEN; POLYIMIDE; WATER;

ARTICLE; ATOMIC FORCE MICROSCOPY; CHEMICAL INTERACTION; CHEMICAL PARAMETERS; CONCENTRATION (PARAMETERS); CONTROLLED STUDY; DIFFUSION COEFFICIENT; EVAPORATION; GAS PERMEABILITY; KINETICS; MEMBRANE FILTER; MEMBRANE PERMEABILITY; MORPHOLOGY; PHASE TRANSITION; POROSITY; PRIORITY JOURNAL; ROOM TEMPERATURE; SCANNING ELECTRON MICROSCOPY; SEPARATION TECHNIQUE; SKIN SURFACE; SURFACE TENSION; TEMPERATURE; THERMODYNAMICS; THICKNESS; VISCOSITY;

EID: 84871429997     PISSN: 03767388     EISSN: 18733123     Source Type: Journal    
DOI: 10.1016/j.memsci.2012.11.018     Document Type: Article

References (28)

1. Baker R.W. Future directions of membrane gas separation technology. Ind. Eng. Chem. Res. 2002, 41:1393.
2. Koros W.J., Fleming G.K. Membrane-based gas separation. J. Membr. Sci. 1993, 83:1.
3. Alexander S.S. Polymers for gas separations: the next decade. J. Membr. Sci. 1994, 94:1.
4. Loeb S., Sourirajan S. Sea water demineralization by means of an osmotic membrane. Adv. Chem. Ser. 1962, 38:117.
5. Reuvers A.J., van den Berg J.W.A., Smolders C.A. Formation of membranes by means of immersion precipitation: Part I. A model to describe mass transfer during immersion precipitation. J. Membr. Sci. 1987, 34:45.
6. Reuvers A.J., Smolders C.A. Formation of membranes by means of immersion precipitation: Part II. the mechanism of formation of membranes prepared from the system cellulose acetate-acetone-water. J. Membr. Sci. 1987, 34:67.
7. Yilmaz L., McHugh A.J. Analysis of nonsolvent-solvent-polymer phase diagrams and their relevance to membrane formation modeling. J. Appl. Polym. Sci. 1986, 31:997.
8. White L.S. Transport properties of a polyimide solvent resistant nanofiltration membrane. J. Membr. Sci. 2002, 205:191.
9. Barsema G.C., Kapantaidakis N.F.A., Koops G.H., Wessling M. Preparation and characterization of highly selective dense and hollow fiber asymmetric membranes based on BTDA-TDI/MDI co-polyimide. J. Membr. Sci. 2003, 216:195.
10. Ren J.Z., Li Z.S., Wong F.S. Membrane structure control of BTDA-TDI/MDI (P84) co-polyimide asymmetric membranes by wet-phase inversion process. J. Membr. Sci. 2004, 241:305.
11. Ren J.Z., Li Z.S., Wong F.S., Li D.F. Development of asymmetric BTDA-TDI/MDI (P84) co-polyimide hollow fiber membranes for ultrafiltration: the influence of shear rate and approaching ratio on membrane morphology and performance. J. Membr. Sci. 2005, 248:177.
12. Ren J.Z., Li Z.S., Wong F.S. Effects of the thermodynamics and rheology of BTDA-TDI/MDI co-polyimide (P84) dope solutions on the performance and morphology of hollow fiber UF membranes. J. Membr. Sci. 2008, 309:196.
13. Qiao X.Y., Chung T.S., Pramoda K.P. Fabrication and characterization of BTDA-TDI/MDI (P84) co-polyimide membranes for the pervaporation dehydration of isopropanol. J. Membr. Sci. 2005, 264:176.
14. Shen Y., Lua A.C. Effects of membrane thickness and heat treatment on the gas transport properties of membranes based on P84 polyimide. J. Appl. Polym. Sci. 2010, 116:2906.
15. 3 transport through matrimid-based hollow fiber membranes. J. Membr. Sci. 2008, 312:84.
16. Mikawa M., Seki N., Nagaoka S., Kawakami H. Structural and gas permeability of asymmetric polyimide membranes made by dry-wet phase inversion: influence of alcohol as casting solution. J. Polym. Sci., Part B: Polym. Phys. 2007, 45:2739.
17. Barton A.F.M. Solubility parameters. Chem. Rev. 1975, 75:731.
18. Matsuua T. Synthetic Membranes and Membrane Separation Processes 1994, CRC Press, Boca Raton.
19. Shimizu H., Kawakami H., Nagaoka S. Membrane formation mechianism and permeation properties of a novel porous polyimide membrane. Polym. Adv. Tech. 2002, 13:370.
20. Wang X.Y., Zhang L., Sun D.H., An Q.F., Chen H.L. Effect of coagulation bath temperature on formation mechanism of poly(vinylidene fluoride) membrane. J. Appl. Polym. Sci. 2008, 110:1656.
21. Feng C.S., Shi B.L., Li G.M., Wu Y.L. Preparation and properties of microporous membrane from poly(vinylidene fluoride-co-tetrafluoroethylene) (F2.4) for membrane distillation. J. Membr. Sci. 2004, 237:15.
22. Kawakami H., Nakajima K., Shimizu H., Nagaoka S. Gas permeation stability of asymmetric polyimide membrane with thin skin layer: effect of polyimide structure. J. Membr. Sci. 2003, 212:195.
23. van't Hof J.A., Reuvers A.J., Boom R.M., Rolevink H.H.M., Smolders C.A. Preparation of asymmetric gas separation membranes with high selectivity by a dual-bath coagulation method. J. Membr. Sci. 1992, 70:17.
24. Flick E.W. Industrial Solvents Handbook 1985, Noyes Dara Corporation, Park Ridge, NJ. third edn.
25. Smolders C.A., Reuvers A.J., Boom R.M., Wienk I.M. Microstructures in phase-inversion membranes. Part 1. Formation of macrovoids. J. Membr. Sci. 1992, 73:259.
26. Kawakami H., Mikawa M., Nagaoka S. Formation of surface skin layer of asymmetric polyimide membranes and their gas transport properties. J. Membr. Sci. 1997, 137:241.
27. Vandezande P., Li X.F., Gevers L.E.M., Vankelecom I.F.J. High throughput study of phase inversion parameters for polyimide-based SRNF membranes. J. Membr. Sci. 2009, 330:307.
28. Kawakami H., Mikawa M., Nagaoka S. Gas Transport properties of asymmetric polyimide membrane with an ultrathin surface skin layer. Macromolecules 1998, 31:6636.