Steam gasification of epoxy circuit board in the presence of carbonates

Journal of Material Cycles and Waste Management

Volumn 14, Issue 4, 2012, Pages 294-300

  Zhang, Shangzhong ^a   Yoshikawa, Kunio ^a   Nakagome, Hideki ^b   Kamo, Tohru ^c  

^a TOKYO INSTITUTE OF TECHNOLOGY   (Japan)

^b CHIBA UNIVERSITY   (Japan)

^c NATIONAL INSTITUTE OF ADVANCED INDUSTRIAL SCIENCE AND TECHNOLOGY AIST   (Japan)

Author keywords

Carbonate; E waste; Epoxy board; Steam gasification

Indexed keywords

ACTIVATION ENERGY; CARBON DIOXIDE; CARBON MONOXIDE; CARBONATES; CARBONATION; ELECTRONIC WASTE; EUTECTICS; FUELS; GASIFICATION; POTASH; PYROLYSIS; SODIUM BICARBONATE; SODIUM CARBONATE; STEAM; TIMING CIRCUITS;

END-OF-LIFE ELECTRONICS; EPOXY BOARD; LITHIUM CARBONATES; PLASTIC COMPONENTS; RAPID PYROLYSIS; SECONDARY STEAM; STEAM GASIFICATION; TERNARY EUTECTICS;

LITHIUM COMPOUNDS;

EID: 84867878850     PISSN: 14384957     EISSN: 1436378X     Source Type: Journal    
DOI: 10.1007/s10163-012-0057-x     Document Type: Article

References (30)

1. UNEP (2006) Basel conference addresses electronic waste challenge-Nairobi conference on Basel convention to address the growing challenge of electronic wastes. http://www. unep. org/documents. multilingual/default. asp?DocumentID=485&ArticleID=5431&I=en.
2. Robinson BH (2009) E-waste: an assessment of global production and environmental impact. Sci Total Environ 408: 183-191.
3. Rolf W, Heidi OK, Deepali SK, Max S, Heinz B (2005) Global perspectives on e-waste. Environ Impact Assess Rev 25: 436-458.
4. UNEP (2009) Sustainable innovation and technology transfer industrial sector studies-recycling from e-waste to resources. http://www. unep. org/PDF/PressReleases/E-Waste_publication_screen_FINALVERSION-sml. pdf.
5. European Commission (2003) Directive 2002/96/EC of the European parliament and of the Council on waste electrical and electric equipment (WEEE). Off J Eur Union L 37/24 13. 2. 2003.
6. Ministry of international trade and industry (1998) Law for the promotion of effective utilization of resources. http://www. meti. go. jp/policy/kaden_recycle/en_cha/pdf/english. pdf.
7. Ministry of international trade and industry (2000) Law for the recycling of special kinds of home appliances (Home appliance recycling law). http://www. meti. go. jp/english/information/data/cReEffectLe. pdf.
8. Cui JR, Forssberg E (2003) Mechanical recycling of WEEE. J Hazard Mater B99: 243-263.
9. Gramatyka P, Nowosielski R, Sakiewicz P (2007) Recycling of waste electrical and electronic equipment. J Achiev Mater Manuf Eng 20(1-2): 535-538.
10. Sato Y, Kodera Y, Kamo T (1999) Effect of solvents on the liquid-phase cracking of thermosetting resins. Energy Fuel 13: 364-368.
11. Marco ID, Caballero BM, Chomon MJ, Laresgoiti MF, Torres A, Fernandez G, Arnaiz S (2008) Pyrolysis of electrical and electronic waste. J Anal Appl Pyrol 82: 179-183.
12. Yamawaki T (2003) The gasification recycling technology of plastics WEEE containing brominated flame retardants. Fire Mater 27: 315-319.
13. Braun D, Gentzkow W, Rudolf AP (2001) Hydrogenolytic degradation of thermosets. Polym Degrad Stab 74: 25-32.
14. Xiu FR, Zhang FS (2010) Materials recovery from waste printed circuit boards by supercritical methanol. J Hazard Mater 178: 628-634.
15. Nishiyama Y (1991) Catalytic gasification of coals-Features and possibilities. Fuel Process Technol 29: 32-42.
16. William JH, Paul TW (2007) Separation and recovery of materials from scrap printed circuit boards. Res Conserv Recycl 51: 691-709.
17. 2 gas bubbling in molten salt for solar/fossil energy hybridization. Sol Energy 68(3): 257-261.
18. Tulay D (1999) Effect of sodium and lithium carbonate catalysts on the rate of steam gasification of low temperature lignite coke. Energy Sour 21(7): 621-627.
19. Bruno G, Carvani L, Passoni G (1986) Correlation between potassium losses and mineral matter composition in catalytic coal steam gasification. Fuel 65: 1473-1475.
20. 2 and synthesis gas. Fuel 87: 491-497.
21. 3 for enhanced production of hydrogen without formation of methane. Fuel 88: 1572-1579.
22. Yeboah YD, Xu Y, Sheth A, Godavarty A, Agrawal PK (2003) Catalytic gasification of coal using eutectic salts: identification of eutectics. Carbon 41: 203-214.
23. Kamo Tu, Wu BL, Egami Y, Yasuda H, Nakagome H (2011) Influence of mixed molten carbonate composition on hydrogen formation by steam gasification. J Mater Cycles Waste Manag 13: 50-55.
24. Sugiura K, Minami K, Yamauchi M, Morimitsu S, Tanimoto K (2007) Gasification characteristics of organic waste by molten carbonate. J Power Sour 171: 228-236.
25. Jin G, Iwaki H, Arai N, Kitagawa K (2005) Study on the gasification of wastepaper/carbon dioxide catalyzed by molten carbonate salts. Energy 30: 1192-1203.
26. 2 or steam using catalysts of molten carbonates. Appl Catal A Gen 270: 237-243.
27. Kajitani S, Hara S, Matsuda H (2002) Gasification rate analysis of coal char with a pressurized drop tube furnace. Fuel 81: 539-546.
28. Sharma DK (2011) Modeling the steam gasification reactions for reactor design. Energy Sour Part A Recov Util Environ Effects 33(1): 57-71.
29. Karimi A, Semagina N, Gray MR (2011) Kinetics of catalytic steam gasification of bitumen coke. Fuel 90: 1258-1291.
30. Sheth A, Yeboah YD, Godavarty A, Xu Y, Agrawal PK (2003) Catalytic gasification of coal using eutectic salts: reaction kinetics with binary and ternary eutectic catalysts. Fuel 82: 305-317.