The role of hydrogen partial pressure in the gas phase hydrogenation of p-chloronitrobenzene over alumina supported Au and Pd: A consideration of reaction thermodynamics and kinetics

Chemical Engineering Journal

Volumn 210, Issue , 2012, Pages 103-113

  Wang, Xiaodong ^a   Perret, Noémie ^a   Keane, Mark A ^a  

^a HERIOT WATT UNIVERSITY   (United Kingdom)

Author keywords

Au alumina; Gas phase hydrogenation; Hydrogen partial pressure; Kinetics; P Chloronitrobenzene; Pd alumina; Thermodynamics

Indexed keywords

ADSORPTION COEFFICIENTS; ALUMINA-SUPPORTED; AROMATIC RINGS; BET SURFACE AREA; ELECTRON TRANSFER; ELECTRON-RICH; GAS-PHASE HYDROGENATION; HYDRODECHLORINATION; HYDROGEN PARTIAL PRESSURES; KINETIC MODELS; MEAN DIAMETER; NANOSCALE METALS; P-CHLORONITROBENZENE; P-CHLORONITROBENZENE (P-CNB); PD/ALUMINA; RATE DEPENDENCE; REACTION TEMPERATURE; REACTION THERMODYNAMICS; TEMPERATURE-PROGRAMMED REDUCTION; THERMODYNAMIC AND KINETIC ANALYSIS; THERMODYNAMIC CONTROL; TRANSMISSION ELECTRON MICROSCOPY TEM; TURNOVER FREQUENCY; XPS ANALYSIS;

ADSORPTION; ALUMINA; ANILINE; BENZENE; CATALYSTS; CYCLOHEXANE; ENZYME KINETICS; GASES; HYDROGENATION; ISOMERS; KINETICS; NITROGEN OXIDES; PARTIAL PRESSURE; PHOTOELECTRONS; TEMPERATURE PROGRAMMED DESORPTION; THERMODYNAMICS; TRANSMISSION ELECTRON MICROSCOPY; X RAY DIFFRACTION; X RAY PHOTOELECTRON SPECTROSCOPY;

DIAMOND FILMS;

EID: 84866277763     PISSN: 13858947     EISSN: None     Source Type: Journal    
DOI: 10.1016/j.cej.2012.08.061     Document Type: Article

References (79)

1. Centi G., Perathoner S. Catalysis, a driver for sustainability and societal challenges. Catal. Today 2008, 138:69-76.
2. Haruta M., Kobayashi T., Sano H., Yamada N. Novel gold catalysts for the oxidation of carbon monoxide at a temperature far below 0°C. Chem. Lett. 1987, 405-408.
3. 4. J. Catal. 1993, 144:175-192.
4. Nkosi B., Coville N.J., Hutchings G.J. Reactivation of a supported gold catalyst for acetylene hydrochlorination. Chem. Commun. 1988, 71-72.
5. Herzing A.A., Kiely C.J., Carley A.F., Landon P., Hutchings G.J. Identification of active gold nanoclusters on iron oxide supports for CO oxidation. Science 2008, 321:1331-1335.
6. x by propene. Appl. Catal. A: Gen. 2008, 347:94-99.
7. 2. J. Phys. Chem. C 2008, 112:12834-12840.
8. Bond G.C., Thompson D.T. Catalysis by gold. Catal. Rev. Sci. Eng. 1999, 41:319-388.
9. 3. Catal. Commun. 2008, 9:475-481.
10. Cárdenas-Lizana F., Gómez-Quero S., Hugon A., Delannoy L., Louis C., Keane M.A. Pd-promoted selective gas phase hydrogenation of p-chloronitrobenzene over alumina supported Au. J. Catal. 2009, 262:235-243.
11. 2. J. Catal. 2009, 268:223-234.
12. 3. ChemSusChem 2008, 1:215-221.
13. Cárdenas-Lizana F., Gómez-Quero S., Perret N., Keane M. Support effects in the selective gas phase hydrogenation of p-chloronitrobenzene over gold. Gold Bull. 2009, 42:124-132.
14. Bond G.C. Gold: a relatively new catalyst. Catal. Today 2002, 72:5-9.
15. Iwasa N., Mayanagi T., Nomura W., Arai M., Takezawa N. Effect of Zn addition to supported Pd catalysts in the steam reforming of methanol. Appl. Catal. A: Gen. 2003, 248:153-160.
16. Iwasa N., Kudo S., Takahashi H., Masuda S., Takezawa N. Highly selective supported Pd catalysts for steam reforming of methanol. Catal. Lett. 1993, 19:211-216.
17. Wang R., Liao S., Ji S. High performance Pd-based catalysts for oxidation of formic acid. J. Power Sour. 2008, 180:205-208.
18. 3 catalyst at low temperature. Catal. Today 2008, 139:15-23.
19. 3 supported catalysts. Catal. Today 2010, 155:18-26.
20. Sekizawa K., Machida M., Eguchi K., Arai H. Catalytic properties of Pd-supported hexaaluminate catalysts for high-temperature catalytic combustion. J. Catal. 1993, 142:655-663.
21. 3: a consideration of HCl/catalyst interactions and solution pH effects. Appl. Catal. B: Environ. 2004, 52:301-314.
22. Jujjuri S., Keane M.A. Catalytic hydrodechlorination at low hydrogen partial pressures: activity and selectivity response. Chem. Eng. J. 2010, 157:121-130.
23. 3-fecralloy monolithic catalysts for the hydrogenation of sunflower oil. Catal. Commun. 2009, 10:1446-1449.
24. 3 catalysts. Appl. Catal. A: Gen. 2010, 373:66-70.
25. Borade R.B., Zhang B., Clearfield A. Selective dehydrogenation of cyclohexene to benzene using Pd-exchanged α-zirconium phosphate. Catal. Lett. 1997, 45:233-235.
26. Zhao B., Chen Y.-W. Hydrogenation of p-chloronitrobenzene on Mo, La, Fe, and W-modified NiCoB nanoalloy catalysts. J. Non-Cryst. Solids 2010, 356:839-847.
27. 2 for the selective hydrogenation of aromatic nitro compounds to anilines. Green Chem. 2011, 13:570-572.
28. Zhang G., Wang L., Shen K., Zhao D., Freeman H.S. Hydrogenation of o-chloronitrobenzene on a Pd/C catalyst doped with metal oxide nanoparticles. Chem. Eng. J. 2008, 141:368-374.
29. 2 catalyst for hydrogenation of the nitro group in chloronitrobenzene. Green Chem. 2012, 14:111-116.
30. Cárdenas-Lizana F., Gómez-Quero S., Perret N., Kiwi-Minsker L., Keane M.A. β-Molybdenum nitride: synthesis mechanism and catalytic response in the gas phase hydrogenation of p-chloronitrobenzene. Catal. Sci. Technol. 2011, 1:794-801.
31. Zuo B., Wang Y., Wang Q., Zhang J., Wu N., Peng L., Gui L., Wang X., Wang R., Yu D. An efficient ruthenium catalyst for selective hydrogenation of ortho-chloronitrobenzene prepared via assembling ruthenium and tin oxide nanoparticles. J. Catal. 2004, 222:493-498.
32. Shimizu K.-i., Miyamoto Y., Kawasaki T., Tanji T., Tai Y., Satsuma A. Chemoselective hydrogenation of nitroaromatics by supported gold catalysts: mechanistic reasons of size- and support-dependent activity and selectivity. J. Phys. Chem. C 2009, 113:17803-17810.
33. Konnecker G., Boehncke A., Schmidt S. Ecotoxicological assessment of p-chloroaniline-Fate and effects in aquatic systems. Fresen. Environ. Bull. 2003, 12:589-593.
34. Wang X., Li S., Wang H., Liu B., Ma X. Thermodynamic analysis of glycerin steam reforming. Energy Fuel 2008, 22:4285-4291.
35. Wang X., Li M., Wang M., Wang H., Li S., Wang S., Ma X. Thermodynamic analysis of glycerol dry reforming for hydrogen and synthesis gas production. Fuel 2009, 88:2148-2153.
36. Wang H., Wang X., Li M., Li S., Wang S., Ma X. Thermodynamic analysis of hydrogen production from glycerol autothermal reforming. Int. J. Hydrogen Energy 2009, 34:5683-5690.
37. Hazewinkel M. Encyclopaedia of Mathematics 2002, Springer-Verlag, Berlin.
38. 2. J. Mol. Catal. A: Chem. 1997, 118:261-269.
39. Tavoularis G., Keane M.A. The gas phase hydrodechlorination of chlorobenzene over nickel/silica. J. Chem. Technol. Biot. 1999, 74:60-70.
40. 3: reaction under controlled pH. Ind. Eng. Chem. Res. 2007, 46:705-715.
41. Cárdenas-Lizana F., Gómez-Quero S., Keane M.A. Clean production of chloroanilines by selective gas phase hydrogenation over supported Ni catalysts. Appl. Catal. A: Gen. 2008, 334:199-206.
42. Coq B., Tijani A., Dutartre R., Figuéras F. Influence of support and metallic precursor on the hydrogenation of p-chloronitrobenzene over supported platinum catalysts. J. Mol. Catal. 1993, 79:253-264.
43. Yu Z., Liao S., Xu Y., Yang B., Yu D. Hydrogenation of nitroaromatics by polymer-anchored bimetallic palladium-ruthenium and palladium-platinum catalysts under mild conditions. J. Mol. Catal. A: Chem. 1997, 120:247-255.
44. Baltzly R., Phillips A.P. The catalytic hydrogenolysis of halogen compounds. J. Am. Chem. Soc. 1946, 68:261-265.
45. Trueba M., Trasatti S.P. Γ-Alumina as a support for catalysts: a review of fundamental aspects. Eur. J. Inorg. Chem. 2005, 2005:3393-3403.
46. Gregg S.J., Sing K.S.W. Adsorption, Surface Area and Porosity 1982, Academic Press, London. second ed.
47. 3 with a lathlike framework morphology. J. Am. Chem. Soc. 2002, 124:12294-12301.
48. Melde B.J., Holland B.T., Blanford C.F., Stein A. Mesoporous sieves with unified hybrid inorganic/organic frameworks. Chem. Mater. 1999, 11:3302-3308.
49. Buchmeiser M.R. Polymeric Materials in Organic Synthesis and Catalysis, WILEY-VCH 2003, Verlag GmbH & Co. KGaA, Weinheim.
50. 3 catalysts for low-temperature CO oxidation. Top. Catal. 2006, 39:101-110.
51. 3 catalysts for CO oxidation: characterization by X-ray absorption near edge structure and temperature programmed reduction. J. Phys. Chem. B 2004, 108:12529-12536.
52. 3. Ind. Eng. Chem. Res. 2008, 47:6841-6853.
53. Babu N.S., Lingaiah N., Gopinath R., Sankar Reddy P.S., Sai Prasad P.S. Characterization and reactivity of alumina-supported Pd catalysts for the room-temperature hydrodechlorination of chlorobenzene. J. Phys. Chem. C 2007, 111:6447-6453.
54. Gopinath R., Seshu Babu N., Vinod Kumar J., Lingaiah N., Sai Prasad P. Influence of Pd precursor and method of preparation on hydrodechlorination activity of alumina supported palladium catalysts. Catal. Lett. 2008, 120:312-319.
55. Nag N.K. A study on the formation of palladium hydride in a carbon-supported palladium catalyst. J. Phys. Chem. B 2001, 105:5945-5949.
56. 2 catalysts as a function of metal dispersion. Catal. Lett. 1995, 32:293-303.
57. Mendez C.M., Olivero H., Damiani D.E., Volpe M.A. On the role of Pd b-hydride in the reduction of nitrate over Pd based catalyst. Appl. Catal. B: Environ. 2008, 84:156-161.
58. x trap catalysts. Ind. Eng. Chem. Res. 2006, 45:8815-8821.
59. Nikolaev S., Smirnov V. Selective hydrogenation of phenylacetylene on gold nanoparticles. Gold Bull. 2009, 42:182-189.
60. 2 catalysts. Chem. Commun. 2011, 47:2351-2353.
61. 3 catalysts by atomic-resolution electron energy-loss spectroscopy. Catal. Lett. 2002, 84:193-199.
62. x nanoparticles. J. Phys. Chem. C 2009, 113:6042-6049.
63. Bond G.C. Chemisorption and reactions of small molecules on small gold particles. Molecules 2012, 17:1716-1743.
64. Claus P. Heterogeneously catalysed hydrogenation using gold catalysts. Appl. Catal. A: Gen. 2005, 291:222-229.
65. 3-supported gold catalysts. J. Phys. Chem. B 2005, 109:14581-14587.
66. Kartusch C., van Bokhoven J.A. Hydrogenation over gold catalysts: the interaction of gold with hydrogen. Gold Bull. 2009, 42:343-348.
67. Bus E., van Bokhoven J.A. Hydrogen chemisorption on supported platinum, gold, and platinum-gold-alloy catalysts. Phys. Chem. Chem. Phys. 2007, 9:2894-2902.
68. Lu C.-M., Wang I., Chou S.-C., Yeh C.-T. Hydrogenation of benzene over rhodium-copper alloy crystallites supported on alumina. Chinyi J. 2001, 19:119-131.
69. Murthy K.V., Patterson P.M., Keane M.A. C-X bond reactivity in the catalytic hydrodehalogenation of haloarenes over unsupported and silica supported Ni. J. Mol. Catal. A: Chem. 2005, 225:149-160.
70. Jujjuri S., Ding E., Hommel E.L., Shore S.G., Keane M.A. Synthesis and characterization of novel silica-supported Pd/Yb bimetallic catalysts: application in gas-phase hydrodechlorination and hydrogenation. J. Catal. 2006, 239:486-500.
71. Zhang Y., Cui X., Shi F., Deng Y. Nano-gold catalysis in fine chemical synthesis. Chem. Rev. 2012, 112:2467-2505.
72. Cárdenas-Lizana F., Gómez-Quero S., Keane M. Gas phase hydrogenation of m-dinitrobenzene over alumina supported Au and Au-Ni alloy. Catal. Lett. 2009, 127:25-32.
73. Cárdenas-Lizana F., Gómez-Quero S., Baddeley C.J., Keane M.A. Tunable gas phase hydrogenation of m-dinitrobenzene over alumina supported Au and Au-Ni. Appl. Catal. A: Gen. 2010, 387:155-165.
74. Cárdenas-Lizana F., Gómez-Quero S., Perret N., Keane M.A. Gold catalysis at the gas-solid interface: role of the support in determining activity and selectivity in the hydrogenation of m-dinitrobenzene. Catal. Sci. Technol. 2011, 1:652-661.
75. Yuan G., Keane M.A. Liquid phase catalytic hydrodechlorination of chlorophenols at 273K. Catal. Commun. 2003, 4:195-201.
76. Amorim C., Wang X., Keane M.A. Application of hydrodechlorination in environmental pollution control: comparison of the performance of supported and unsupported Pd and Ni catalysts. Chin. J. Catal. 2011, 32:746-755.
77. Lazar C.D.M., Almasan V., Aldea N., Barz B., Marginean P., Sutan C., Malinovschi V. Nanostructured gold supported catalysts: Relation between structure and hydrogen catalytic activity. Rom. J. Phys. 2006, 51:299-304.
78. 2 catalysts: a cooperative effect between gold and the support. J. Am. Chem. Soc. 2007, 129:16230-16237.
79. Pietrowski M., Wojciechowska M. The origin of increased chemoselectivity of platinum supported on magnesium fluoride in the hydrogenation of chloronitrobenzene. Catal. Today 2011, 169:217-222.