Effect of surfactants and biomass on the gas/liquid mass transfer in an aqueous-silicone oil two-phase partitioning bioreactor using Rhodococcus erythropolis T902.1 to remove VOCs from gaseous effluents

Journal of Chemical Technology and Biotechnology

Volumn 84, Issue 9, 2009, Pages 1274-1283

  Aldric, Jean Marc ^a   Gillet, Sébastien ^a   Delvigne, Frank ^a   Blecker, Christophe ^b   Lebeau, Frédéric ^b   Wathelet, Jean Paul ^b   Manigat, Geralda ^a   Thonart, Philippe ^a  

^a WALLOON AGRICULTURAL RESEARCH CENTRE   (Belgium)

^b UNIVERSITY OF LIÈGE   (Belgium)

Author keywords

[No Author keywords available]

Indexed keywords

BIOMASS GROWTH; BUBBLE DIAMETER; CONCENTRATION OF; GLOBAL MASS TRANSFER COEFFICIENTS; INTERFACIAL AREAS; MASS TRANSFER COEFFICIENT; NEW STRATEGY; OIL/WATER; OPTIMAL CONCENTRATION; RHODOCOCCUS ERYTHROPOLIS; SILICONE OIL; SURFACE HYDROPHOBICITY; TWO PHASE PARTITIONING BIOREACTOR; WASTE GAS TREATMENT;

BIOMASS; BIOREACTORS; GASEOUS EFFLUENTS; MATHEMATICAL MODELS; OXYGEN; SILICONES; SPONTANEOUS EMISSION; SURFACE ACTIVE AGENTS; WASTE TREATMENT;

MASS TRANSFER;

SILICONE OIL; SURFACTANT; VOLATILE ORGANIC COMPOUND;

AQUEOUS SOLUTION; ARTICLE; BACTERIAL GROWTH; CONTACT ANGLE; CONTROLLED STUDY; EFFLUENT; MICROBIAL BIOMASS; NONHUMAN; PHASE PARTITIONING; RHODOCOCCUS ERYTHROPOLIS; STIRRED REACTOR; SURFACE TENSION; WASTE MANAGEMENT;

RHODOCOCCUS ERYTHROPOLIS;

EID: 70349496051     PISSN: 02682575     EISSN: 10974660     Source Type: Journal    
DOI: 10.1002/jctb.2172     Document Type: Article

References (64)

1. Daugulis AJ, Two-phase partitioning bioreactors: a new technology platform for destroying xenobiotics. Trends Biotechnol 19:459-464 (2001).
2. Nielsen DR, Daugulis AJ and McLellan PJ, Quantifying maintenance requirements from the steady-state operation of a two-phase partitioning bioscrubber. Biotechnol Bioeng 90:248-258 (2005).
3. Muñoz R, Arriaga S, Hernández S, Guieysse B and Revah S, Enhanced hexane biodegradation in a two phase partitioning bioreactor: Overcoming pollutant transport limitations. Process Biochem 41:1614-1619 (2006).
4. Boudreau NG, and Daugulis AJ, Transient performance of two-phase partitioning bioreactors treating a toluene contaminated gas stream. Biotechnol Bioeng 94:448-457 (2006).
5. Daugulis AJ and Boudreau NG, Removal and destruction of high concentrations of gaseous toluene in a two-phase partitioning bioreactor by Alcaligenes xylosoxidans. Biotechnol Lett 25:1421-1424 (2003).
6. García-Peña EI, Hernández S, Favela-Torres E, Auria R and Revah S, Toluene biofiltration by the fungus Scedosporium apiospermum TB1. Biotechnol Bioeng 76:61-69 (2001).
7. Jacobs P, de Bo I, Demeestere K, Verstraete W and van Langenhove H, Toluene removal from waste air using a flat composite membrane bioreactor. Biotechnol Bioeng 85:68-77 (2004).
8. Arriaga S and Revah S, Removal of n-hexane by Fusarium sp. with a gas phase biofilter. J Ind Microbiol Biotechnol 32:548-553 (2005).
9. Djeribi R, Dezenclos T, Pauss A and Lebeault JM, Removal of styrene from waste gas using a biological trickling filter. Eng Life Sci 5:450-457 (2005).
10. Aldric JM, Destain J and Thonart P, The two-phase bioreactor water/ silicone oil: prospects in the off-gas treatment. Appl Biochem Biotechnol 121-124:707-720 (2005).
11. Aldric JM and Thonart P, Performance evaluation of an aqueous-silicone oil two-phase partitioning bioreactor using Rhodococcus erythropolis T902.1 to remove VOC from gaseous effluents. J Chem Technol Biotechnol 83:1401-1408 (2008).
12. Muñoz R, Villaverde S, Guieysse B and Revah S, Two-phase partitioning bioreactors for treatment of volatile organic compounds. Biotechnol Adv 25:410-422 (2007).
13. Cesário MT, de Wit HL, Tramper J and Beeftink HH, Dispersed organic solvent to enhance the overall gas/water mass transfer coefficient of apolar compounds in the biological waste-gas treatment. Modeling and evaluation. Biotechnol Prog 13:399-407 (1997).
14. Rols JL, Condoret JS, Fonade C and Goma G, Modeling of oxygen transfer in water through emulsified organic liquids. Chem Eng Sci 46:1869-1873 (1991).
15. Brilman DWF, Goldschmidt MJV, Versteeg GF and van Swaaij WPM, Heterogeneous mass transfer models for gas absorption in multiphase systems. Chem Eng Sci 55:2793-2812 (2000).
16. Bruining WJ, Joosten GEH, Beenackers AACM and Hofman H, Enhancement of gas-liquid mass transfer by a dispersed second liquid phase. Chem Eng Sci 41:1873-1877 (1986).
17. Nagy E and Moser A, Three-phase mass transfer: improved pseudo-homogeneous model. AIChE J 41:23-34 (1995).
18. Cents HG, Brilman DWF and Versteeg GF, Gas absorption in an agitated gas-liquid-liquid system. Chem Eng Sci 56:1075-1083 (2001).
19. MacMillan JD and Wang DIC, Enhanced oxygen transfer using oil-in-water dispersions. Ann NY Acad Sci 506:569-582 (1987).
20. Brilman DWF, van Swaaij WPM and Versteeg GF, A one-dimensional instationary heterogeneous mass transfer model for gas absorption in multiphase systems. Chem Eng Process 37:471-488 (1998).
21. Van Ede CJ, Van Houten R and Beenackers AACM, Enhancement of gas to water mass transfer rates by a dispersed organic phase. Chem Eng Sci 50:2911-2922 (1995).
22. Junker BH, Wang DIC and Hatton TA, Oxygen transfer enhancement in aqueous/perfluorocarbon fermentation systems: II. Theoretical analysis. Biotechnol Bioeng 35:586-597 (1990).
23. Dumont E and Delmas H, Mass transfer enhancement of gas absorption in oil-in-water systems: a review. Chem Eng Process 42:419-438 (2003).
24. Morao CI, Maia MMR, Fonseca JMT, Vasconcelos and Alves SS, Effect of antifoam addition on gas-liquid mass transfer in stirred fermenters. Bioprocess Biosyst Eng 20:165-172 (1999).
25. Painmanakul P, Loubière K, Hébrard G, Mietton-Peuchot M and Roustan M, Effect of surfactants on liquid-side mass transfer coefficients. Chem Eng Sci 60:6480-6491 (2005).
26. Schmid A, Kollmer A and Witholt B, Effects of biosurfactant and emulsification on two-liquid phase pseudomonas oleovorans cultures and cell-free emulsions containing n-decane. Enzyme Microb Technol 22:487-493 (1998).
27. Déziel E, Comeau Y and Villemur R, Two-liquid-phase bioreactors for enhanced degradation of hydrophobic/toxic compounds. Biodegradation 10:219-233 (1999).
28. Ascon-Cabrera M and Lebeault JM, Selection of xenobiotic-degrading microorganisms in a biphasic aqueous-organic system Appl Environ Microbiol. 59:1717-1724 (1993).
29. Djeribi R, Dezenclos T, Pauss A and Lebeault JM, Removal of styrene from waste gas using a biological trickling filter. Eng Life Sci 5:450-457 (2005).
30. Yamashita S, Satoi M, Iwasa Y, Honda K, Sameshima Y, Omasa T, et al., Utilization of hydrophobic bacterium Rhodococcus opacus B-4 as whole-cell catalyst in anhydrous organic solvents. Appl Microbiol Biotechnol 74:761-767 (2007).
31. Ju LK and Sundararajan A, The effect of cells on oxygen transfer in bioreactors. Bioprocess Biosyst Eng 13:271-278 (2004).
32. Galaction A, Cascaval D, Oniscu C and Turnea M, Prediction of oxygen mass transfer coefficients in stirred bioreactors for bacteria, yeasts and fungus broths. Biochem Eng J 20:85-94 (2004).
33. Ruthiya KC, Van der Schaaf J, Kuster BFM and Schouten JC, Mechanisms of physical and reaction enhancement of mass transfer in a gas inducing stirred slurry reactor. Chem Eng J 96:. 55-69 (2003).
34. Kluytmans JHJ, Van Wachem BGM and Kuster BFM, Mass transfer in sparged and stirred reactors: influence of carbon particles and electrolyte. Chem Eng Sci 58:4719-4728 (2003).
35. Dorobantu LS, Yeung AKC, Foght JM and Gray MR, Stabilization of oil-water emulsions by hydrophobic bacteria. Appl Environ Microbiol, 70:6333-6336.
36. Leal-Calderon F and Schmitt V, Solid-stabilized emulsions. Curr Opin Colloid Interface Sci 13:217-227 (2008).
37. Legrand J, Chamerois M, Placin F, Poirier JE, Bibette J and Leal-Calderon F, Mineral particles inducing coalescence in bitumenin-water emulsions. Langmuir 21:64-70 (2005).
38. Binks BP, Desforges A and Duff DG, Synergetic stabilization of emulsions by a mixture of surface-active nanoparticles and surfactant. Langmuir 23:1098-1106 (2007).
39. Binks BP and Rodrigues JA, Synergetic interaction in emulsions stabilized by a mixture of silica nanoparticles and cationic surfactant. Langmuir 23:3626-3636 (2007).
40. Giermanska-Kahn J, Laine V, Arditty S, Schmitt V and Leal-Calderon F, Particle-stabilized emulsions comprised of solid droplets. Langmuir 21:4316-4323 (2005).
41. Dabrock B, Kesseler, Averhoff B and Gottschalk G, Identification and characterization of a transmissible linear plasmid from Rhodococcus erythropolis BD2 that encodes isopropylbenzene and trichloroethene catabolism. Appl Environ Microbiol 60:853-860 (1994).
42. Martin M, Bosch P, Parra JL, Espuny MJ and Virgili A, Structure and bioconversion of threalose lipids. Carbohydr Res 220:93-100 (1991).
43. Kuyukina MS, Ivshina IB, Philp JC, Christofi N, Dunbar SA and Ritchkova MI, Recovery of Rhodococcus biosurfactants using methyl tertiary-butyl ether extraction. J Microbiol Methods 46:149-156 (2001).
44. Bandyopoudhyay B, Humphrey AE and Taguchi H, Dynamic measurement of the volumetric oxygen transfer coefficient in fermentation systems. Biotechnol Bioeng 9:533-544 (1967).
45. Barigou M, and Greaves M, A capillary suction probe for bubble size measurement. Meas Sci Technol 2:318-326 (1991).
46. Miller R and Hoffman A, Measuring dynamic surface and interfacial tension. Adv Mater 4:370-374 (1992).
47. Bastiaens L, and Springeal D, Isolation of adherent polycyclic aromatic hydrocarbons (PAH)-degrading bacteria using PAH-sorbing carriers. Appl Environ Microbiol 66:1834-1843 (2000).
48. MacLeod CT and Daugulis AJ, Interfacial effects in a two-phase partitioning bioreactor: Degradation of polycyclic aromatic hydrocarbons (PAHs) by hydrophobic Mycobacterium. Process Biochem 40:1799-1805 (2005).
49. Gutiérrez JA, Nichols P and Couperwhite I, Changes in whole cell-derived fatty acids induced by benzene and occurrence of the unusual 16:1ω6c in Rhodococcus sp. 33 FEMS Microbiol Lett 176:213-218 (1999).
50. Ascon-Cabrera MA and Lebeault JM, Cell hydrophobicity influencing the activity/stability of xenobiotic-degrading microorganisms in a continuous biphasic aqueous-organic system. J Ferment Bioeng 80:270-275 (1995).
51. Basheva ES, Stoyanov S, Denkov ND, Kasuga K, Satoh N and Tsujii K, Foam boosting by amphiphilic molecules in the presence of silicone oil. Langmuir 17:969-979 (2001).
52. Dumont E, Andrès Y and Le Cloirec P, Effect of organic solvents on oxygen mass transfer in multiphase systems: Application to bioreactors inenvironmental protection. Biochem Eng J 30:245-252 (2006).
53. Aldric JM, Lecomte JP and Thonart P, Study on mass transfer of isopropylbenzene and oxygen in a two-phase partitioning bioreactor in the presence of silicone oil. Appl Biochem Biotechnol - In press. DOI 10.1007/s12010-008-8480-0.
54. Sharma MM and Mashelkar RA, Absorption with reaction in bubble columns. Inst Chem Eng Symp 28:10-21 (1968).
55. Blokker PC, On mass transfer across liquid/liquid interfaces in systems with and without surface active agents. in Proceedings of the Second International Congress of Surface Activity, vol 1, ed. by Schulman JH. Butterworths, London, pp. 503-511 (1957).
56. Fyferling M, Uribelarrea JL, Goma G and Molina-Jouve C, Oxygen transfer in intensive microbial culture. Bioprocess Biosyst Eng 26:595-604 (2008).
57. Roustan M, Transfert gaz liquide dans les procédés de traitement des eaux et des effluents gazeux. Editions Lavoisier (2003).
58. Gogoi NC and Dutta NN, Empirical approach to solid-liquid mass transfer in a three-phase sparged reactor. Fuel Process Technol 48:145-157 (1996).
59. Dumont E, Andrès Y and Le Cloirec P, Effect of organic solvents on oxygen mass transfer in multiphase systems: Application to bioreactors inenvironmental protection. Biochem Eng J 30:245-252 (2006).
60. Dumont E, Andrès Y and Le Cloirec P, Mass transfer coefficients of styrene and oxygen into silicone oil emulsions in a bubble reactor. Chem Eng Sci 61:5612-5619 (2006).
61. Yoshida F, Yamane T and Miyamoto Y, Oxygen absorption into oil-in-water emulsions. A study on hydrocarbon fermentors. Ind. Eng. Chem. Des. Develop. 9:570-577 (1970).
62. Srivastava P, Hahr O, Buchholz R and Worden RM, Enhancement of mass transfer using colloidal liquid aphrons: Measurement of mass transfer coefficients in liquid-liquid extraction. Biotechnol Bioeng 70:525-32 (2000).
63. Bredwell MD and Worden RM, Mass-transfer properties of microbubbles. 1. Experimental studies. Biotechnol Prog 14:31-38 (1998).
64. Lye GJ, Stuckey DC, Predispersed solvent extraction of microlide antibiotics using colloidal liquid aphrons. in Proceedings of the international Solvent Extraction Conference, ed. by Shallcross DC, Paimin R and Prvic LM. Melbourne, Australia, pp. 1399-405 (1996).