Correlation between electrochemical impedance and noise measurements of waterborne coatings

Corrosion Science

Volumn 51, Issue 3, 2009, Pages 499-510

  Hernandez M ^a   Genesca J ^b   Uruchurtu, J ^c   Barba, A ^b  

^a UNIVERSITY OF VIGO   (Spain)

^b UNIVERSIDAD NACIONAL AUTÓNOMA DE MÉXICO   (Mexico)

^c UNIVERSIDAD AUTÓNOMA DEL ESTADO DE MORELOS   (Mexico)

Author keywords

A. Organic coatings; A. Steel; B. Electrochemical impedance spectroscopy

Indexed keywords

ACOUSTIC NOISE MEASUREMENT; DIFFUSION COATINGS; ELECTRIC NETWORK ANALYSIS; ELECTROCHEMICAL CORROSION; ELECTROCHEMICAL IMPEDANCE SPECTROSCOPY; PROTECTIVE COATINGS; SODIUM CHLORIDE; STEEL;

A. ORGANIC COATINGS; A. STEEL; B. ELECTROCHEMICAL IMPEDANCE SPECTROSCOPY; DIFFUSION MECHANISMS; EQUIVALENT ELECTRIC CIRCUITS; FREQUENCY APPROACHES; NOISE MEASUREMENTS; NOISE RESISTANCES; NYQUIST FREQUENCIES; POLARIZATION RESISTANCES; PORE RESISTANCES; RATE-DETERMINING STEPS; SALINE MEDIAS; SAMPLING FREQUENCIES; WATER-BORNE COATINGS;

ORGANIC COATINGS;

EID: 60549093033     PISSN: 0010938X     EISSN: None     Source Type: Journal    
DOI: 10.1016/j.corsci.2008.12.011     Document Type: Article

References (49)

1. Hernández M., Galliano F., and Landolt D. Mechanism of cathodic delamination control of zinc-aluminum phosphate pigment in waterborne coatings. Corr. Sci. 46 9 (2004) 2281
2. Almeida E., Santos D., and Uruchurtu J. Corrosion performance of waterborne coatings for structural steel. Prog. Org. Coat. 37 (1999) 131
3. Laverde D., Zubillaga J.C., Gil-Sevillano J., and Villanueva E. The influence of the primer layer on mechanical damage and loss of corrosion protection of deformed painted Zn-0.16% Al and Zn-5% Al galvanized sheet steel. Corr. Sci. 37 (1995) 79
4. Barraclough J., and Harrison J.B. New leadless-anticorrosive primers. J. Oil Col. Chem. Assoc. 48 4 (1965) 341
5. Grundmeier G., Schmidt W., and Stratmann M. Corrosion protection by organic coatings: electrochemical mechanism and novel methods of investigation. Electrochim. Acta 45 15 (2000) 2515
6. Akid R., and Garma M. Scanning vibrating reference electrode technique: a calibration study to evaluate the optimum operating parameters for maximum signal detection of point source activity. Electrochim. Acta 49 17 (2004) 2871
7. Zhong C., Tang X., and Cheng Y.F. Corrosion of steel under the defected coating studied by localized electrochemical impedance spectroscopy. Electrochim. Acta 53 14 (2008) 4740
8. Misczcyk A., and Szalinska H. Laboratory evaluation of epoxy coatings with an adhesion promoter by impedance. Prog. Org. Coat. 25 (1995) 357
9. Rammelt U., and Reinhard G. Characterization of active pigments in damage of organic coatings on steel by means of electrochemical impedance spectroscopy. Prog. Org. Coat. 24 (1994) 309
10. del Amo B., Romagnoli R., Deyá C., and González J.A. High performance water-based paints with non-toxic anticorrosive pigments. Prog. Org. Coat. 45 (2002) 389
11. Guenbour A., Benbachir A., and Kacemi A. Evaluation of the corrosion performance of zinc-phosphate-painted carbon steel. Surf. Coat. Tech. 113 1 (1999) 36
12. Kendig M., Mansfeld F., and Tsai S. Determination of the long term corrosion behavior of coated steel with A.C. impedance measurements. Corr. Sci. 23 4 (1983) 317
13. van Westing E.P.M., Ferrari G.M., Geenen F.M., and de Wit J.H.W. In situ determination of the loss of adhesion of barrier epoxy coatings using electrochemical impedance spectroscopy. Prog. Org. Coat. 23 1 (1993) 89
14. Stratmann M., Feser R., and Leng A. Corrosion protection by organic films. Electrochim. Acta 39 8 (1994) 1207
15. Stratmann M., Streckel H., and Feser R. A new technique able to measure directly the delamination of organic polymer films. Corr. Sci. 32 4 (1991) 467
16. Stratmann M., and Streckel H. On the atmospheric corrosion of metals which are covered with thin electrolyte layers-I. Verification of the experimental technique. Corr. Sci. 30 6 (1990) 681
17. Stratmann M., and Streckel H. On the atmospheric corrosion of metals which are covered with thin electrolyte layers-II. Experimental results. Corr. Sci. 30 6 (1990) 697
18. Liu C., Bi Q., Leyland A., and Matthews A. An electrochemical impedance spectroscopy study of the corrosion behaviour of PVD coated steels in 0.5 N NaCl aqueous solution: Part I. Establishment of equivalent circuits for EIS data modelling. Corr. Sci. 45 6 (2003) 1243
19. De Rosa R.L., Earl D.A., and Bierwagen G.P. Statistical evaluation of EIS and ENM data collected for monitoring corrosion barrier properties of organic coatings on Al-2024-T3. Corr. Sci. 44 7 (2002) 1607
20. Sanchez-Amaya J.M., Osuna R.M., Bethencourt M., and Botana F.J. Monitoring the degradation of a high solids epoxy coating by means of EIS and EN. Prog. Org. Coat. 60 3 (2007) 248
21. Greisiger H., and Schauer T. On the interpretation of the electrochemical noise data for coatings. Prog. Org. Coat. 39 1 (2000) 31
22. Skerry B.S., Chen C.T., and Eden D.A. Characterisation of coatings performance using electrochemical noise analysis. Prog. Org. Coat. 19 4 (1991) 379
23. Mansfeld F., Han L.T., and Lee C.C. Analysis of electrochemical noise data for polymer coated steel in the time and frequency domains. J. Electrochem. Soc. 143 12 (1996) L286-L289
24. Bertocci U., and Huet F. Noise analysis applied to electrochemical system. Corrosion 51 (1995) 131
25. Moreira de Almeida M.E., Mariaca L., Uruchurtu J., and Veloz M.A. Electrochemical methods in corrosion research V. Mat. Sci. Forum. 192-194 (1995) 723
26. Moon M., and Skerry B. Interpretation of corrosion resistance properties of organic paint films from fractal analysis of electrochemical noise data and implications for paint performance predictions. J. Coat. Technol. 67 843 (1995) 35
27. Jones C.L., Lonergan G.T., and Mainwaring D.E. Wavelet packet computation of the Hurst exponent. J. Phys. A 29 (1996) 2509
28. M. A. González-Nuñez, J. Uruchurtu-Chavarín, - R/S Fractal analysis of electrochemical noise signals of three organic coating samples under corrosion conditions, EUROCORR, 2004.
29. Leng A., Streckel H., and Stratmann M. The delamination of polymeric coatings from steel. Part 1: Calibration of the Kelvin probe and basic delamination mechanism. Corr. Sci. 41 3 (1999) 579
30. R. Cottis, S. Turgoose. Electrochemical Impedance and Noise. Corrosion Testing Made Easy, NACE, 1999.
31. Hernandez M., Genesca J., Uruchurtu J., Galliano F., and Landolt D. Effect of an inhibitive pigment zinc-aluminum-phosphate (ZAP) on the corrosion mechanisms of steel in waterborne coatings. Prog. Org. Coat. 56 (2006) 199
32. Guillaumin V., and Landolt D. Effect of dispersion agent on the degradation of a water borne paint on steel studied by scanning acoustic microscopy and impedance. Corr. Sci. 44 1 (2002) 179
33. Y.T. Al-Janabi, A.M. Al-Ramis, H.M. Al-Mutairi, A.H. AI-Rasheed, Ali.A. AI-Jabran, Life prediction of high temperature coatings by electrochemical impedance spectroscopy, Proccedings. NACE Corrosion 2000, paper 759.
34. García E., Hernández M.A., Rodríguez F.J., Genescá J., and Boerio F.J. Oscillation and chaos in pitting corrosion of steel. Corrosion 59 1 (2003) 50
35. Zubielewicz M., and Gnot W. Mechanisms of non-toxic anticorrosive pigments in organic waterborne coatings. Prog. Org. Coat. 49 4 (2004) 358
36. Mansfeld F., Han L.T., Lee C.C., Chen C., Zhang G., and Xiao H. Analysis of electrochemical impedance and noise data for polymer coated metals. Corr. Sci. 39 2 (1997) 255
37. Cottis R.A. Interpretation of electrochemical noise data. Corrosion 57 3 (2001) 265
38. Aballe A., Bautista A., Bertocci U., and Huet F. Measurement of the noise resistance for corrosion applications. Corrosion 57 1 (2001) 35
39. G.P. Bierwagen, V. Balbyshev, D. Mills, D. Tallman, "Fundamental Considerations on Electrochemical Noise Methods to Examine Corrosion Under Organic Coatings," in Advances in Corrosion Protection by Organic Coatings II, Electrochemical Society, Pennington, NJ, 1994.
40. M.E. Moreira de Almeida, L. Mariaca, A. Rodríguez, J.U. Chavarín, M.A. Veloz, Electrochemical Noise Measurement for Corrosion Applications, ASTM STP 1277, Philadelphia, Pennsylvania, 1996 (pp. 411).
41. Leidheiser Jr. H., Wang W., and Igetoft L. The mechanism for the cathodic delamination of organic coatings from a metal surface. Prog. Org. Coat. 11 1 (1983) 19
42. van Der Weijde D.H., van Westing E.P.M., and de Wit J.H.W. EIS measurements on artificial blisters in organic coatings. Electrochim. Acta 41 7 (1996) 1103
43. van Westing E.P.M., Ferrari G.M., and De Wit H.J.W. The determination of coating performance using electrochemical impedance spectroscopy. Electrochim. Acta 39 7 (1994) 899
44. Campestrini P., Van Westing E.P.M., and de Wit J.H.W. Influence of surface preparation on performance of chromate conversion coatings on Alclad 2024 aluminium alloy: Part II: EIS investigation. Electrochim. Acta 46 17 (2001) 2631
45. Campestrini P., Van Westing E.P.M., Hovestad A., and de Wit J.H.W. Investigation of the chromate conversion coating on Alclad 2024 aluminium alloy: effect of the pH of the chromate bath. Electrochim. Acta 47 7 (2002) 1097
46. Zview for Windows. Version 1.6b; Scribner Associates, Inc., Solartron Instruments, Inc., 2004. Available from: .
47. Le Thu Q., Bierwagen G.P., and Touzain S. EIS and ENM measurements for three different organic coatings on aluminum. Prog. Org. Coat. 42 3 (2001) 179
48. Geenen F.M., De Witt J.H., and Van Westing E.P.M. An impedance spectroscopy study of the degradation mechanism for a model epoxy coating on mild steel. Prog. Org. Coat. 18 3 (1990) 299
49. Galliano F., and Landolt D. Evaluation of corrosion protection properties of additives for waterborne epoxy coatings on steel. Prog. Org. Coat. 44 3 (2002) 217