Strain softening and hardening during superplastic-like flow in a fine-grained MgAl2O4 spinel polycrystal

Journal of the American Ceramic Society

Volumn 87, Issue 6, 2004, Pages 1102-1109

  Morita, Koji ^a   Hiraga, Keijiro ^a   Kim, Byung Nam ^a   Suzuki, Tohru S ^a   Sakka, Yoshio ^a  

^a NATIONAL INSTITUTE FOR MATERIALS SCIENCE   (Japan)

Author keywords

[No Author keywords available]

Indexed keywords

CRYSTAL LATTICES; CRYSTAL MICROSTRUCTURE; DEFORMATION; DISLOCATIONS (CRYSTALS); GRAIN BOUNDARIES; GRAIN GROWTH; POLYCRYSTALS; RESIDUAL STRESSES; STRAIN HARDENING; STRESS CONCENTRATION; STRESS RELAXATION; SUPERPLASTICITY;

GRAIN BOUNDARY SLIDING; LATTICE DIFFUSION; OXYGEN IONS; SPINEL POLYCRYSTALS; STRAIN SOFTENING;

MAGNESIUM COMPOUNDS;

EID: 3142677182     PISSN: 00027820     EISSN: None     Source Type: Journal    
DOI: 10.1111/j.1551-2916.2004.01102.x     Document Type: Article

References (31)

1. B.-N. Kim, K. Hiraga, K. Morita, and Y. Sakka, "A High-Strain-Rate Superplastic Ceramics," Nature (London), 413 [6853] 288-91 (2001).
2. 4 Spinel," J. Am. Ceram. Soc., 85 [7] 1900-902 (2002).
3. T. G. Nieh and J. Wadsworth, "Superplastic Behavior of a Fine-Grained, Yttria-Stabilied Tetragonal Zirconia Polycrystal (Y-TZP ," Acta Mater., 38 [6] 1121-33 (1990).
4. 2-Doped Y-TZP," Mater. Trans. JIM, 39 [11] 1108-14 (1998).
5. R. Duclos, N. Doukhan, and B. Escaig, "High-Temperature Creep Behavior of Nearly Stoichiometric Alumina Spinel," J. Mater. Sci., 13, 1740-48 (1978).
6. 3 Spinels," Acta Mater., 30 [7] 1381-88 (1982).
7. 4)," Philos. Mag. A, 45 [6] 1013-36 (1982).
8. W. T. Donlon, A. H. Heuer, and T. E. Mitchell, "Compositional Softening in Mg-Al Spinel," Philos. Mag. A, 78 [3] 615-41 (1998).
9. 3 Spinel Single Crystals," J. Am. Ceram. Soc., 82 [12] 3305-16 (1999).
10. 3 Spinel," J. Am. Ceram. Soc., 68 [10] 522-29 (1985).
11. 3 Spinel," Acta Mater., 43 [7] 2753-60 (1995).
12. 3 Spinel: Prospects for Superplastic Forming," J. Eur. Ceram. Soc., 17, 439-45 (1997).
13. T. Shiono, H. Ishitomi, Y. Okamoto, and T. Nishida, "Deformation Mechanism of Fine-Grained Magnesium Aluminate Spinel Prepared Using Alkoxide Precursor," J. Am. Ceram. Soc., 83 [3] 645-47 (2000).
14. M. I. Mendelson, "Average Grain Size in Polycrystalline Ceramics," J. Am. Ceram. Soc., 52 [8] 443-46 (1969).
15. 3 Spinels," J. Chem. Phys., 61 [2] 625-29 (1974).
16. K. P. R. Reddy and A. R. Cooper, "Oxygen Diffusion in Magnesium Aluminate Spinel," J. Am. Ceram. Soc., 64 [6] 368-71 (1981).
17. P. A. Friedman and A. K. Ghosh, "Microstructural Evaluation and Superplastic Deformation Behavior of Fine Grain 5083Al," Metall. Mater. Trans. A, 27 [12] 3827-39 (2000).
18. K. Hiraga, K. Nakano, T. S. Suzuki, and Y. Sakka, "Processing-Dependent Microstructural Factors Affecting Cavitation Damage and Tensile Ductility in a Superplastic Alumina with Zirconia," J. Am. Ceram. Soc., 85 [11] 2763-70 (2002).
19. T. G. Nieh, J. Wadsworth, and O. D. Sherby, Superplasticity in Metals and Ceramics; 58-202. Cambridge University Press, Cambridge, U.K., 1997.
20. T. Ohji, S. Sakai, M. Ito, Y. Yamaguchi, W. Kanematsu, and S. Ito, "Yielding Phenomena of Hot-Pressed Silicon Nitride," High Temp. Technol., 15 [3] 139-44 (1987).
21. T. Sakai and J. J. Jonas, "Dynamic Recrystallization: Mechanical and Microstructural Considerations," Acta Mater., 32 [2] 189-209 (1984).
22. S. Tsurekawa, K. Kawahara, and H. Nakashima, "Plastic Deformation of Covalent Bonded Ceramics at High Temperature"; pp. 260-69 in Precursor-Derived Ceramics: Synthesis, Structures, and High-Temperature Mechanical Properties. Edited by J. Bill, F. Wakai, and F. Aldinger. Wiley-VCH, New York, 1999.
23. M. F. Ashby, "On Interface-Reaction Control of Nabarro-Herring Creep and Sintering," Scr. Mater., 3 [11] 837-42 (1969).
24. B. Burton, "Interface-Reaction-Controlled Diffusional Creep: A Consideration of Grain Boundary Dislocation Climb Sources," Mater. Sci. Eng., 10 [1] 9-14 (1972).
25. M. Z. Berbon and T. G. Langdon, "An Examination of the Flow Process in Superplastic Yttria-Stabilized Tetragonal Zirconia," Acta Mater., 47 [8] 2485-95 (1999).
26. K. Morita and K. Hiraga, "Deformed Substructures in Fine-Grained Tetragonal Zirconia," Philos. Mag. Lett., 81 [5] 311-20 (2001).
27. K. Morita and K. Hiraga, "Critical Assessment of High-Temperature Deformation and Deformed Microstructure in High-Purity Tetragonal Zirconia Containing 3 mol% Yttria," Acta Mater., 50 [5] 1075-85 (2002).
28. K. Sumino and S. Kodaka, "Dynamical State of Dislocations in Germanium Crystals during Deformation," Mater. Sci. Eng. A, 13, 263-68 (1974).
29. H. Alexander, "Dislocation in Covalent Crystals"; pp. 115-234 in Dislocation in Solids, Vol. 7. Edited by F. R. N. Nabarro, North-Holland, Amsterdam, The Netherlands, 1986.
30. W. G. Johnston and J. Gilman, "Dislocation Velocities, Dislocation Densities, and Plastic Flow in Lithium Fluoride Crystals," J. Appl. Phys., 30 [2] 129-44 (1959).
31. H. Kurishita, K. Nakajima, and H. Yoshinaga, "The High-Temperature Deformation Mechanism in Titanium Carbide Single Crystals," Mater. Sci. Eng., 54 [1] 177-90 (1982).