Direct-contact evaporation in the homogeneous and heterogeneous bubbling regimes. Part II: Dynamic simulation

International Journal of Heat and Mass Transfer

Volumn 47, Issue 17-18, 2004, Pages 3841-3854

  Ribeiro Jr , Cláudio P ^a   Lage, Paulo L C ^a  

^a FEDERAL UNIVERSITY OF RIO DE JANEIRO   (Brazil)

Author keywords

Bubble column; Direct contact evaporator; Gas hold up; Heat and mass transfer; Simulation

Indexed keywords

BUBBLES (IN FLUIDS); COMPUTER SIMULATION; DATA REDUCTION; EVAPORATION; MASS TRANSFER;

AIR-WATER SYSTEM; BUBBLING REGIME; DIRECT-CONTACT EVAPORATORS;

HEAT TRANSFER;

BUBBLE COLUMN; EVAPORATION; FLOW REGIME RELATIONS; GAS FLOW; HOLD-UP; VELOCITY;

EID: 2942736843     PISSN: 00179310     EISSN: None     Source Type: Journal    
DOI: 10.1016/j.ijheatmasstransfer.2004.03.017     Document Type: Article

References (55)

1. Cronan C.S. Submerged combustion flares anew Chem. Eng. 63 2 1956 163-167
2. Williams A. Submerged combustion for water plants Mech. Eng. 87 7 1965 34-37
3. C.P. Ribeiro Jr., P.L.C. Lage, Direct-contact evaporation in the homogeneous and heterogeneous bubbling regime. Part I: Experimental analysis, Int. J. Heat Mass Transfer, in press
4. A.L. Andrade, Heat transfer in superheated bubbles, DSc thesis, PEQ/COPPE/UFRJ, Rio de Janeiro, RJ, 1985 (in Portuguese)
5. E.M. Queiroz, Simultaneous heat and mass transfer in bubbling processes, DSc thesis, PEQ/COPPE/UFRJ, Rio de Janeiro, RJ, 1990 (in Portuguese)
6. Guy C. Carreau P.J. Paris J. Heat and mass transfer between bubbles and a liquid Can. J. Chem. Eng. 70 1 1992 55-60
7. Lage P.L.C. Hackenberg C.M. Simulation and design of direct-contact evaporators Veziroglu T.N. Multiphase Transport Particulate Phenomena vol. 2 1990 577-592 Hemisphere Publishing Corporation New York
8. Moody F.J. Dynamic and thermal behavior of hot gas bubbles discharged into water Nucl. Eng. Des. 95 1986 47-54
9. Komarov S.V. Sano M. Bubble behaviour and heat transfer in preheated gas injection into liquid bath ISIJ Int. 38 10 1998 1045-1052
10. Campos F.B. Lage P.L.C. Modelling and simulation of direct-contact evaporators Braz. J. Chem. Eng. 18 3 2001 277-286
11. Vermeer D.J. Krishna R. Hydrodynamics and mass transfer in bubble columns operating in the churn-turbulent regime Ind. Eng. Chem. Process Des. Develop. 20 1981 475-482
12. Krishna R. Wilkinson P.M. Van Dierendonck L.L. A model for gas holdup in bubble columns incorporating the influence of gas density on flow regime transitions Chem. Eng. Sci. 46 10 1991 2491-2496
13. Wilkinson P.M. Spek A.P. Van Dierendonck L.L. Design parameters estimation for scale-up of high-pressure bubble columns AIChE J. 38 4 1992 544-554
14. Ellenberger J. Krishna R. A unified approach to the scale-up of gas-solid fluidised bed and gas-liquid bubble column reactors Chem. Eng. Sci. 49 24B 1994 5391-5411
15. Letzel H.M. Schouten J.C. Krishna R. Van Den Bleek C.M. Gas holdup and mass transfer in bubble column reactors operated at elevated pressure Chem. Eng. Sci. 54 1999 2237-2246
16. Iguchi M. Morita Z. Tokunaga H. Tatemichi H. Heat transfer between bubbles and liquid during cold gas injection ISIJ Int. 32 7 1992 865-872
17. Tokunaga H. Iguchi M. Tatemichi H. Heat transfer between bubbles and molten wood's metal ISIJ Int. 35 1 1995 21-25
18. Grassmann P. Wyss E. Determination of heat and mass transfer coefficients between steam bubbles and fluids Chem. Ing. Tech. 34 11 1962 755-759
19. Bhagade S.S. Giradkar J.R. Mene P.S. Studies on heat transfer during bubble formation Indian J. Technol. 11 7 1973 281-283
20. Safonov A.I. Gomonova K.V. Krylov V.S. Heat transfer to a growing bubble during gas dispersion in a liquid Theor. Found. Chem. Eng. 8 5 1975 654-660
21. Jeje A. Ross B. The temperature field near a nozzle and the dynamics of saturated steam bubbles in subcooled water at low steady vapor supply rates Chem. Eng. Sci. 43 10 1988 2817-2831
22. A.D. Pinto, Bubble formation at orifices: initial evaporation in bubbling processes, MSc dissertation, PEQ/ COPPE/UFRJ, Rio de Janeiro, RJ, 1990 (in Portuguese)
23. Cho S.C. Lee W.K. Steam bubble formation at a submerged orifice in quiescent water Chem. Eng. Sci. 46 3 1991 789-795
24. A.C. Mezavilla, Direct-contact evaporation: heat and mass transfer during the formation of superheated bubbles, MSc dissertation, PEQ/COPPE/UFRJ, Rio de Janeiro, RJ, 1995 (in Portuguese)
25. C.M. Hackenberg, Heat transfer in bubbles, MSc dissertation, PEQ/COPPE/UFRJ, Rio de Janeiro, RJ, 1965 (in Portuguese)
26. Nigmatulin R.I. Khabeev N.S. Nagiev F.B. Dynamics, heat and mass transfer of vapour-gas bubbles in a liquid Int. J. Heat Mass Transfer 24 6 1981 1033-1044
27. Campos F.B. Lage P.L.C. Simultaneous heat and mass transfer during the ascension of superheated bubbles Int. J. Heat Mass Transfer 43 2 2000 179-189
28. Campos F.B. Lage P.L.C. Heat and mass transfer modelling during the formation and ascension of superheated bubbles Int. J. Heat Mass Transfer 43 16 2000 2883-2894
29. Calderbank P.H. Moo-Young M.B. The continuous phase heat and mass-transfer properties of dispersions Chem. Eng. Sci. 16 1-2 1961 39-54
30. Davidson J.F. Schüler B.O.G. Bubble formation at an orifice in a viscous liquid Trans. Inst. Chem. Eng. 38 1960 144-154
31. Karamanev D.G. Rise of gas bubbles in quiescent liquids AIChE J. 40 8 1994 1418-1421
32. Clift R. Grace J.R. Weber M.W. Bubbles, Drops and Particles 1978 Academic Press New York
33. Behringer H. The flow of liquid-gas mixtures in vertical tubes Z. Ges. Kälte-Ind. 43 1936 55-58
34. Zuber N. Findlay J.A. Average volumetric concentration in two-phase flow systems J. Heat Transfer 87 4 1965 453-468
35. Bhaga D. Weber M.E. Hold-up in vertical two and three phase flow Can. J. Chem. Eng. 50 2 1972 323-336
36. Hills J.H. Darton R.C. The rising velocity of a large bubble in a bubble swarm Trans. Inst. Chem. Eng. 54 4 1976 258-264
37. Zahradnik J. Fialova M. Ruzicka M. Drahos J. Kastanek F. Thomas N.H. Duality of the gas-liquid flow regimes in bubble column reactors Chem. Eng. Sci. 52 21/22 1997 3811-3826
38. Krishna R. Urseanu M.I. Van Baten J.M. Ellenberger J. Rise velocity of a swarm of large bubbles in liquids Chem. Eng. Sci. 54 1999 171-183
39. Collins R. The effect of a containing cylindrical boundary on the velocity of a large gas bubble in a liquid J. Fluid Mech. 28 1 1967 97-112
40. Krishna R. Urseanu M.I. Van Baten J.M. Ellenberger J. Wall effects on the rise of single gas bubbles in liquids Int. Commun. Heat Mass Transfer 26 6 1999 781-790
41. Kawasaki J. Hayakawa T. Direct-contact mass and heat transfer between vapour and liquid with change of phase J. Chem. Eng. Jpn. 5 2 1972 119-124
42. Luedicke A.H. Jr. Hendrickson B. Pigott G.M. A method for the concentration of proteinaceous solutions by submerged combustion J. Food Sci. 44 1979 469-1473
43. Zhu J.W. Saxena S.C. Prediction of gas-phase holdup in a bubble column Chem. Eng. Commun. 161 1997 149-161
44. Reilly I.G. Scott D.S. De Bruijn J.W. Intyre D. The role of gas phase momentum in determining gas hold-up and hydrodynamic flow regimes in bubble column operations Can. J. Chem. Eng. 72 1994 3-12
45. Krishna R. Ellenberger J. Maretto C. Flow regime transition in bubble columns Int. Commun. Heat Mass Transfer 26 4 1999 467-475
46. Kreith F. Principles of Heat Transfer third ed. 1973 Intext Educational New York
47. Shah Y.T. Kelkar B.G. Godbole S.P. Deckwer W.-D. Design parameters estimations for bubble column reactors AIChE J. 28 3 1982 353-379
48. Saxena S.C. Rao N.S. Heat transfer and gas holdup in a two-phase bubble column: air-water system--review and new data Exp. Therm. Fluid Sci. 4 2 1991 139-151
49. P.L.C. Lage, Multicomponent droplet vaporisation in convective and radiant fields, DSc thesis, PEQ/COPPE/UFRJ, Rio de Janeiro, RJ, 1992 (in Portuguese)
50. Reid R.C. Prausnitz J.M. Poling B.E. The Properties of Gases and Liquids fourth ed. 1987 McGraw-Hill New York
51. Holman J.P. Heat Transfer fourth ed. 1976 McGraw-Hill New York
52. Luo X. Lee D.J. Lau R. Yang G. Fan L.-S. Maximum stable bubble size and gas holdup in high-pressure slurry bubble columns AIChE J. 45 4 1999 665-680
53. Ribeiro C.P. Jr. Lage P.L.C. Experimental study on bubble size distributions in a direct-contact evaporator Braz. J. Chem. Eng. 21 1 2004 69-81
54. Bowonder B. Kumar R. Studies in bubble formation--IV: bubble formation at porous discs Chem. Eng. Sci. 25 1970 25-32
55. Sotelo J.L. Benitez F.J. Beltran-Heredia J. Rodriguez C. Gas hold-up and mass transfer coefficients in bubble columns--1. Porous glass-plate diffusers Int. Chem. Eng. 34 2 1994 82-89