Improved general correlation for subcooled boiling heat transfer during flow across tubes and tube bundles

HVAC and R Research

Volumn 11, Issue 2, 2005, Pages 285-303

  Shah, M Mohammed ^a  

^a Engineering Research and Consultation Organization (ERACO)   (United States)

Author keywords

[No Author keywords available]

Indexed keywords

CORRELATION METHODS; HEAT TRANSFER; REFRIGERANTS; REYNOLDS NUMBER; TUBES (COMPONENTS); WATER;

SINGLE TUBES; SUBCOOLED BOILING; TUBE BUNDLES;

BOILING LIQUIDS;

EID: 18944372416     PISSN: 10789669     EISSN: None     Source Type: Journal    
DOI: 10.1080/10789669.2005.10391138     Document Type: Article

References (46)

1. Beecher, N., 1948. Heat transfer to water flowing normal to a single tube. M, S. thesis Chem. Eng. Dept., Massachusetts Institute of Technology.
2. Bennet, D. L., Hertzler, B. L., and Kalb, C. E., 1985. “ Down-flow shell-side forced convective boiling. ”. In Two-Phase Heat Transfer Symposium HTD-Vol. 44, 1–9. New York:ASME.
3. Bitter, R. C., 1973. Zum Warmeubergang von einem querangenstomten Rohr an siedendes R-11 beim Einund Zweiphasenstromung, Dr. Ing. thesis Tech. Univ. Clausthal.
4. Brisbane, T. W. C., Grant, I. D. R., and Whalley, P. B. A., 1980. Prediction method for kettle reboiler performance New York:ASME. Paper 80-HT-42
5. Broussard, R. A., and Westwater, J. W., 1985. Diameter and velocity effects for cross-flow boiling. AIAA Journal, 23 (10):1615–1620.
6. Chen, J. C. A., 1966. Correlation for boiling heat transfer to saturated fluids in convective flow. Ind. Engng. Chem. Proc. Des. Dev., 5 (3):322–329.
7. Churchill, S. W., and Bernstein, M., 1977. A correlating equation for forced convection from gases and liquids to a circular cylinder in crossflow. J. Heat Transfer, Vol. 99:300–306.
8. Cooper, M. G., 1984. Heat flow rates in saturate nucleate pool boiling—A wide ranging examination using reduced properties. Advances in Heat Transfer, Vol. 16:157–239.
9. Cornwell, K., Duffin, N. W., and Schuller, R. B., 1980. An experimental study of the effects of fluid flow on boiling within a kettle reboiler tube bundle New York:ASME. Paper 80-HT-45
10. Cornwell, K., and Leong, L. S., 1979. Heat transfer coefficients in a reboiler tube bundle. The Chemical Engineer,:219–221. April
11. Dieselhorst, T., 1978. Hydrodynamische und oberflachenspezifische Einflusse auf die Siedekrisis beim Behaltersieden, Dr. Ing. thesis Technical Univ. of Munich.
12. Dowlat, R., and Byrne, T., Subcooled flow boiling from the bottom of a large-diameter tube. Proc. 1995 National Heat Transfer Conf. Vol. 12, pp. 153–159. HTD-vol. 314, ASME
13. Elrod, W. C., Clark, J. A., Lady, E. R., and Merte, H., 1966. Boiling heat transfer data at low heat flux. J. Heat Transfer,:235–239.
14. Fand, R. M., and Keswani, K. K., 1972. The influence of property variation on forced convection heat transfer. Int. J. Heat Mass Transfer, Vol. 15:1525–1536.
15. Fand, R. M., Keshwani, K. K., Jotwani, M. M., and Ho, R. C. C., 1976. Simultaneous boiling and forced convection heat transfer from a horizontal cylinder to water. J. Heat Transfer, Vol. 98:395–400.
16. th International Heat Transfer Conf. Munich. pp. 207–212. paper FB5
17. Gupta, A., Saini, J. S., and Varma, H. K., 1995. Boiling heat transfer in small horizontal tube bundles at low cross-flow velocities. Int. J. Heat Mass Transfer, 38 (4):599–605.
18. Holman, J. P., 1968. Heat Transfer, 2d ed New York:McGraw-Hill.
19. Hsu, Y., and Graham, R. W., 1976. Transport Processes in Boiling and Two-Phase Flow Washington:Hemisphere Publishing Corp.
20. Huang, L., and Witte, L. C., 2001. Highly subcooled boiling in crossflow. J. Heat Transfer, Vol. 123:1080–1085. Data tabulations kindly provided by L. Huang.
21. Hwang, T. H., and Yao, S. C., 1986. Forced convection boiling in tube bundles. Int. J. Heat Mass Transfer, 29 (5):785–795.
22. Hwang, T. H., and Yao, S. C., 1984. Boiling heat transfer of a horizontal cylinder at low quality crossflow HTD-Vol. 38, 9–17. New York:ASME.
23. Jensen, M. K., and Hsu, J. T., 1988. A parametric study of boiling heat transfer in a horizontal tube bundle. J. Heat Transfer, Vol. 110:976–981.
24. Kutateladze, S. C., 1961. Boiling heat transfer. Int. J. Heat Mass Transfer, Vol. 4:31–45.
25. Lee, Y., and Shigechi, T., Conjugated cross flow boiling on a horizontal cylinder. ASME/JSME Thermal Engineering Conf. Proc. Vol. 2, pp. 153–158. ASME
26. Lemmert, M., and Chawla, J. M., 1977. “ Influence of flow velocity on surface boiling heat transfer coefficients. ”. In Heat Transfer in Boiling Edited by:Hahne, E., and Grigull, U., Washington:Hemisphere Publishing Corp.
27. Leong, L. S., and Cornwell, K., 1979. Heat transfer coefficients in a reboiler tube bundle. Chemical Enginner,:219–221. April
28. Leppert, G., Costello, C. P., and Hoglund, B. M., 1958. Boiling heat transfer to water containing a volatile additive. Trans. ASME, Vol. 80:1395–1403.
29. McKee, H. R., 1967. Forced convection boiling from a cylinder normal to the flow, PhD thesis Chemical Engineering Department, Oklahoma State Univ.
30. Michejew, E., Die Grundlagen der Warmeubergang Berlin:VEB Verlag Technik. Quoted by Bitter [14]
31. Mostinski, I. K., 1963. Teploenergetica Vol. 66, 580 English abstract in British Chemical Engng Vol. 8, No. 8, 1963
32. Palen, J. W., Yarden, A., and Taborek, J., 1972. Characteristics of boiling outside large-scale horizontal multitube bundles. AIChE Symp. Ser., 68 (118):50–61.
33. Polley, G. T., Ralston, T., and Grant, I. D. R., 1980. Forced crossflow boiling in an ideal in-line tube bundle New York:ASME. ASME Paper 8-HT-46
34. Rohsenow, W. M., 1953. Heat transfer associated with nucleate boiling 123Stanford Univ. Press. Proc. Heat Transfer & Fluid Flow Institute
35. Saha, P., and Zuber, N., 1974. Point of net vapor generation and vapor void fraction in subcooled boiling. Proc. Fifth International Heat Transfer Conf, Tokyo, Vol. 9:175–179.
36. Sankaran, S., and Witte, L., 1991. Highly subcooled boiling of Freon-113 and Water over Cylinders Vol. 2, 3–9. New York:ASME. ASME-JSME Thermal Engineering Proc
37. Shah, M. M. A., 1977. General correlation for heat transfer during subcooled boiling in pipes. ASHRAE Transactions, 83 (1):205–215.
38. Shah, M. M., 1982. CHART correlation for saturated boiling heat transfer:Equations and further study. ASHRAE Transactions, 88 (1):185–196.
39. Shah, M. M. A., 1983. General correlation for heat transfer during subcooled boiling in annuli. Heat Transfer Engineering, 4 (1):24–31.
40. Shah, M. M. A., 1984. Correlation for heat transfer during subcooled boiling on a single tube with forces crossflow. Int. J. Heat & Fluid Flow, 5 (1):13–20.
41. Singh, R. L., Saini, J. S., and Varma, H. K., 1983. Effect of crossflow in boiling heat transfer. Int. J. Heat Mass Transfer, 26 (12):1882–1885.
42. Singh, R. L., Saini, J. S., and Varma, H. K., 1985. Effect of cross-flow on boiling heat transfer of refrigerant-12. Int. J. Heat Mass Transfer, 28 (2):512–514.
43. Stephan, K., and Abdelsalam, M., 1980. Heat transfer correlations for natural convection boiling. Int. J. Heat Mass Transfer, Vol. 23:73–87.
44. Vliet, C. C., 1962. Local boiling peak heat flux for water flowing normal to cylinder, PhD thesis Mech. Eng. Dept., Stanford Univ.
45. Wege, M. E., and Jensen, M. K., 1984. Boiling heat transfer from a horizontal tube in an upward flowing two-phase crossflow. J. Heat Transfer, Vol. 106:849–855.
46. Yilmaz, S. B., 1979. Effect of velocity on boiling Feon-113, Doctoral thesis Chemical Engineering Dept, Univ. of Illinois.