Effect of strain rate on the formation of fine-grained microstructure in a cast aluminum alloy 7475 upon high-temperature upsetting

Physics of Metals and Metallography

Volumn 99, Issue 1, 2005, Pages 106-117

  Sitdikov, O Sh ^a,c   Goloborod'ko, A N ^b,c   Kaibyshev, R O ^c   Miura, H ^b   Sakai, T ^b  

^a NATIONAL INSTITUTE FOR MATERIALS SCIENCE   (Japan)

^b UNIVERSITY OF ELECTRO COMMUNICATIONS   (Japan)

^c INSTITUTE FOR METALS SUPERPLASTICITY PROBLEMS   (Russian Federation)

Author keywords

[No Author keywords available]

Indexed keywords

COLD ROLLING; CRYSTAL MICROSTRUCTURE; DEFORMATION; HIGH TEMPERATURE APPLICATIONS; PLASTIC FLOW; RECRYSTALLIZATION (METALLURGY); STRAIN RATE; UPSETTING (FORMING);

DEGREE OF DEFORMATION; FINE GRAINS; MISORIENTATIONS; SOFTENING;

ALUMINUM ALLOYS;

EID: 14744272132     PISSN: 0031918X     EISSN: None     Source Type: Journal    
DOI: None     Document Type: Article

References (31)

1. F. J. Humphreys and M. Hatherly, Recrystallization and Related Annealing Phenomena (Pergamon, Oxford, 1996).
2. J. A. Wert, N. E. Paton, C. H. Hamilton, and M. W. Mahoney, "Grain Refinement in 7075 Aluminum by Thermomechanical Processing," Metall. Trans. A 12 (7), 1267-1276 (1981).
3. S. P. Belyaev, V. A. Likhachev, M. M. Myshlyaev, and O. N. Sen'kov, "Dynamic Recrystallization of Aluminum," Fiz. Met. Metalloved. 52 (3), 617-626 (1981).
4. M. R. Drury and F. J. Humphreys, "The Development of Microstructure in A1-5% Mg during High Temperature Deformation," Acta Metall. 34 ( 11 ), 2259-2271 ( 1986).
5. S. J. Haies and T. R. McNelley, "Microstructural Evolution by Continuous Recrystallization in a Superplastic Al-Mg Alloy," Acta Metall. 36 (5), 1229-1239 (1988).
6. J. K. Solberg, H. J. McQueen, N. Ryum, and E. Nes, "Influence of Ultra-High Strains at Elevated Temperatures on the Microstructure of Aluminum. Part I," Philos. Mag. A 60 (4), 447-471 (1989).
7. H. Gudmundsson, D. Brooks, and J. A. Wert, "Mechanisms of Continuous Recrystallization in an Al-Zr-Si Alloy," Acta Metall. Mater. 39 (1), 19-35 (1991).
8. J. P. Lin, T. C. Lei, and X. Y. An, "Dynamic Recrystallization during Hot Compression in Al-Mg Alloy," Scr. Metall. Mater. 26 (12), 1869-1874 (1992).
9. Q. Liu, H. Huang, M. Yao, and J. Yang, "On Deformation-Induced Continuous Recrystallization in a Superplastic Al-Li-Cu-Mg-Zr Alloy," Acta Metall. Mater. 40 (7), 1753-1762 (1992).
10. H. Yamagata, "Dynamic Recrystallization and Dynamic Recovery in Pure Aluminum at 583 K," Acta Metall. Mater. 43 (2), 723-729 (1995).
11. J. Liu and D. J. Chakrabarti, "Grain Structure and Microtexture Evolution during Superplastic Forming of a High Strength Al-Zn-Mg-Cu Alloy," Acta Mater. 44 (12), 4647-4661 (1996).
12. D. Ponge, M. Bredehoft, and G. Gottstein, "Dynamic Recrystallization in High Purity Aluminum," Scr. Mater. 37 (11), 1769-1775 (1997).
13. T. R. McNelley and M. E. McMahon, "Microtexture and Grain Boundary Evolution during Microstructural Refinement Processes in SUPRAL 2004," Metall. Mater. Trans. A 28 (9), 1879-1887 (1997).
14. T. Sakai, H. Yang, and H. Miura, "Dynamic Evolution of Fine Grained Structure and Superplasticity of 7075 Aluminum Alloy," Mater. Sci. Eng. A 234-236, 857-860 (1997).
15. T. G. Nieh, L. M. Hsiung, J. Wadsworth, and R. Kaibyshev, "High Strain Rate Superplasticity in a Continuously Recrystallized Al-6%Mg-0.3%Sc Alloy," Acta Mater. 46 (8), 2789-2800 (1998).
16. S. Gourdet and F. Montheillet, "An Experimental Study of the Recrystallization Mechanism during Hot Deformation of Aluminum," Mater. Sci. Eng. A 283 (1-2), 274-288 (2000).
17. R. Kaibyshev, O. Sitdikov, A. Goloborodko, and T. Sakai, "Grain Refinement in As-Cast 7475 Aluminum Alloy under Hot Deformation," Mater. Sci. Eng. A 344 (1-2), 348-356 (2003).
18. O. A. Kaibyshev, Superplasticity of Commercial Alloys (Metallurgiya, Moscow, 1984) [in Russian].
19. T. Sakai and C. Takahashi, "Flow Softening of 7075 Aluminum Alloy under Hot Compression," Mater. Trans. JIM 32 (4), 375-382 (1991).
20. X. Yang, H. Miura, and T. Sakai, "Dynamic Evolution of New Grains in Magnesium Alloy during Hot Deformation," Mater. Trans. JIM 44 (1), 197-203 (2003).
21. T. Sakai and J. J. Jonas, "Overview No. 35-Dynamic Recrystallization: Mechanical and Microstructural Considerations," Acta Metall. 32 (2), 189-209 (1984).
22. A. Belyakov, W. Gao, H. Miura, and T. Sakai, "Strain-Induced Grain Evolution in Polycrystalline Copper during Warm Deformation," Metall. Mater. Trans. A 29 (12), 2957-2965 (1998).
23. X. Yang, H. Miura, and T. Sakai, "Continuous Dynamic Recrystallization in a Superplastic 7075 Aluminum Alloy," Mater. Trans. JIM 43 (10), 2400-2407 (2002).
24. B. Bay, N. Hansen, D. A. Hughes, and D. KuhlmannWilsdorf, "Overview No. 96-Evolution of FCC Deformation Structures in Polyslip," Acta Metall. Mater. 40 (2), 205-219 (1992).
25. A. Belyakov, T. Sakai, H. Miura, and K. Tsuzaki, "Grain Refinement in Copper under Large Strain Deformation," Philos. Mag. A 81 (11), 2629-2643 (2001).
26. O. Sh. Sitdikov, R. O. Kaibyshev, I. M. Safarov, and I. A. Mazurina, "Evolution of the Microstructure and Mechanisms of Formation of New Grains upon Severe Plastic Deformation of the 2219 Aluminum Alloy," Fiz. Met. Metalloved. 92 (3), 65-76 (2001) [Phys. Met. Metallogr. 92, 270-280 (2001)].
27. O. Sh. Sitdikov, R. O. Kaibyshev, I. M. Safarov, and I. A. Mazurina, "Evolution of the Microstructure and Mechanisms of Formation of New Grains upon Severe Plastic Deformation of the 2219 Aluminum Alloy," Fiz. Met. Metalloved. 92 (3), 65-76 (2001) [Phys. Met. Metallogr. 92, 270-280 (2001)].
28. O. Sitdikov and R. Kaibyshev, "Dislocation Glide and Dynamic Recrystallization in LiF Single Crystals," Mater. Sci. Eng. A 328 (1-2), 147-155 (2002).
29. A. N. Goloborod'ko, "Dynamic Recrystallization of AsCast Aluminum Alloy of 7XXX Series", Degree Thesis (UGATU, Ufa, 1999).
30. B. I. Smirnov, V. V. Shpeizman, T. V. Privalova, and T. V. Samoilova, "Migration of Low-Angle Boundaries at the Steady-State Stage of Metal Creep," Fiz. Tverd. Tela 18 (8), 2432-2434 (1976).
31. M. Biberger and W. Blum, "Subgrain Boundary Migration during Creep of LiF: I. Recombination of Subgrain Boundaries," Philos. Mag. A 65 (3), 757-770 (1992).