Electrospray evaporation and deposition

Journal of Aerosol Science

Volumn 34, Issue 7, 2003, Pages 815-836

  Wilhelm, O ^a   Madler L ^a   Pratsinis, S E ^a  

^a ETH ZURICH   (Switzerland)

Author keywords

Ceramic films; Deposition flux; Electrospray; Rayleigh limit; Satellite droplets

Indexed keywords

DEPOSITION; EVAPORATION; HEAT CONVECTION; HEAT TRANSFER; SPRAYING; SUBSTRATES; THERMAL EFFECTS;

ELECTROSPRAY TRANSPORT;

DROP FORMATION;

SODIUM CHLORIDE;

DEPOSITION; DROPLET; ELECTROCOATING; EVAPORATION; HEAT TRANSFER; INDUSTRIAL APPLICATION; SPRAYING;

ARTICLE; CALCULATION; CONCENTRATION RESPONSE; ELECTRON TRANSPORT; EVAPORATION; FLOW RATE; HEAT TRANSFER; MODEL; PARTICLE SIZE; PRIORITY JOURNAL; TEMPERATURE SENSITIVITY; THERMODYNAMICS; TRANSPORT KINETICS; VAPOR;

EID: 0037487107     PISSN: 00218502     EISSN: None     Source Type: Journal    
DOI: 10.1016/S0021-8502(03)00034-X     Document Type: Article

References (33)

1. Abramzon B., Sirignano W.A. Droplet vaporization model for spray combustion calculations. International Journal of Heat and Mass Transfer. 32:1989;1605-1618.
2. Aihara T., Yamada Y., Endo S. Free convection along downward-facing surface of a heated horizontal plate. International Journal of Heat and Mass Transfer. 15:1972;2535-2541.
3. Beard K.V., Pruppacher H.R. A wind tunnel investigation of the rate of evaporation of small water droplets falling at terminal velocity in air. Journal of Atmospheric Science. 28:1971;1455-1464.
4. Camelot, D. M. A. (1999). The bipolar coagulation process for powder production. An application of the electrohydrodynamic atomization of liquids. Ph.D. Thesis, Delft University of Technology, The Netherlands.
5. Chen C.H., Edmond M.H.J., Kelder E.M., Meester B., Schoonman J. Electrostatic sol-spray deposition of nanostructured ceramic thin films. Journal of Aerosol Science. 30:1999;959-967.
6. Clift R., Grace J.R., Weber M.E. Bubbles, drops, and particles. 1978;Academic Press, New York.
7. Cloupeau M., Prunet-Foch B. Electrostatic spraying of liquids in the cone-jet mode. Journal of Electrostatics. 22:1989;135-159.
8. Cloupeau M., Prunet-Foch B. Electrohydrodnamic spraying functioning modes. A critical review Journal of Aerosol Science. 25:1994;1021-1036.
9. Cranck J. The mathematics of diffusion. 1975;Oxford Science Publications, Oxford.
10. Davis E.J., Bridges M.A. The Rayleigh limit of charge revisited. Light scattering from exploding droplets Journal of Aerosol Science. 25:1994;1179-1199.
11. Frössling N. Ueber die Verdunstung fallender Tropfen. Gerlands Beiträge zur Geophysik. 52:1938;170-216.
12. Gañán-Calvo A.M., Dávila J., Barrero A. Current and droplet size in the electrospraying of liquids. Scaling laws. Journal of Aerosol Science. 28:1997;249-276.
13. Gañán-Calvo A.M., Lasheras J.C., Davila J., Barrero A. The electrostatic spray emited from an electrified conical meniscus. Journal of Aerosol Science. 25:1994;1121-1142.
14. Grace J.M., Dunn P.F. Droplet motion in an electrohydrodynamic fine spray. Experiments in Fluids. 20:1996;153-164.
15. Hartmann R.P.A., Brunner F.J., Camelot D.M.A., Marijnissen J.C.M., Scarlett B. Electrohydrodynamic atomization in the cone-jet mode and physical modelling of the liquid cone and jet. Journal of Aerosol Science. 30:1999;823-849.
16. Hinds W.C. Aerosol technology. 2nd ed. 1998;Wiley, New York.
17. Jones A.R., Thong K.C. The production of charged monodisperse fuel droplets by electrical dispersion. Journal of Physics D: Applied Physics. 4:1971;1159-1166.
18. Kanury A.M. Introduction to combustion phenomena. 1975;Gordon and Breach, New York.
19. Konstantinov K., Stambolova I., Peshev P., Darriet B., Vassilev S. Preparation of ceria films by spray pyrolysis method. International Journal of Inorganic Materials. 2:2000;277-280.
20. Loeb L.B., Kip A.F., Hudson G. Pulses in negative point-to-plane corona. Physics Review. 15:1941;714-722.
21. 3 films prepared by the spray pyrolysis method Physica B. 301:2001;310-317.
22. Nguyen T., Djurado E. Deposition and characterization of nanocrystalline tetragonal zirconia films using electrostatic spray deposition. Solid State Ionics. 138:2001;191-197.
23. Nijman, E. (2002). Dynamic light scattering at low concentration and in turbulent flow. Ph.D. Thesis, Delft University of Technology, the Netherlands.
24. Perednis, D., Honegger, K., & Gauckler, L. J. (2001). Fabrication of thin YSZ electrolyte films using spray pyrolysis technique. H. Yokokawa, & S. C. Singhal (Eds.), Proceedings of the seventh international symposium on solid oxide fuel cells, (SOFC-VII), Tsukuba, Japan (p. 989). Pennington, NJ, USA: The Electrochemical Society.
25. Ranz W.E., Marshall W.R. Evaporation from drops. Chemical Engineering Progress. 48:1952;141-146.
26. Siefert W. Corona spray pyrolysis. A new coating technique with an extremely enhanced deposition efficiency Thin Solid films. 120:1984;267-274.
27. Sirignano W.A. Fuel droplet vaporisation and spray combustion theory. Progress in Energy Combustion Science. 9:1983;291-322.
28. Sirignano W.A. Fluid dynamics and transport of droplets and sprays. 1999;Cambridge University Press, Cambridge.
29. Sparrow E.M., Gregg J.L. The variable fluid-property problem in free convection. Transactions of the ASME. 80:1958;879-886.
30. Tang K., Gomez A. On the structure of an electrostatic spray of monodisperse droplets. Physics of Fluids. 6:1994;2317-2332.
31. 4 by electro spraying Journal of Aerosol Science. 25:1994;1229-1235.
32. 2 production by an electrostatic spray pyrolysis process. Proceedings of the International workshop synthetic measure ultrafine particles, TU Delft, Delft, Netherlands, pp. 71-81.
33. Wilhelm, O. (2003). Electrospray evaporation and deposition of ceramic films. Ph.D. Thesis, ETH Zürich, Switzerland, in preparation.