Preparation of dense BaTiO3 ceramics with submicrometer grains by spark plasma sintering

Journal of the American Ceramic Society

Volumn 82, Issue 4, 1999, Pages 939-943

  Takeuchi, Tomonari ^a   Tabuchi, Mitsuharu ^a   Kageyama, Hiroyuki ^a   Suyama, Yoko ^b  

^a OSAKA NATIONAL RESEARCH INSTITUTE   (Japan)

^b SHIMANE UNIVERSITY   (Japan)

Author keywords

[No Author keywords available]

Indexed keywords

ANNEALING; CERAMIC MATERIALS; DENSIFICATION; GRAIN SIZE AND SHAPE; PERMITTIVITY; PLASMA APPLICATIONS; POWDERS; SINTERING;

SPARK PLASMA SINTERING;

BARIUM TITANATE;

EID: 0032679834     PISSN: 00027820     EISSN: None     Source Type: Journal    
DOI: 10.1111/j.1151-2916.1999.tb01857.x     Document Type: Article

References (23)

1. J. Nowotny and M. Rekas, "Dielectric Ceramic Materials Based on Alkaline Earth Metal Titanates," Key Eng. Mater., 66/67, 45-143 (1992).
2. R. Bacsa, P. Ravindranathan, and J. P. Dougherty, "Hydrothermal Synthesis of Barium Titanate Thin Films on Titanium Metal Substrates," Mater. Res. Soc. Symp. Proc., 243, 431-36 (1992).
3. E. Shi, C. R. Cho, M. S. Jang, S. Y. Jeong, and H. J. Kim, "The Formation Mechanism of Barium Titanate Thin Film under Hydrothermal Conditions," J. Mater. Res., 9, 2914-18 (1994).
4. A. T. Chien, J. S. Speck, F. F. Lange, A. C. Daykin, and C. G. Levi, "Low Temperature/Low Pressure Hydrothermal Synthesis of Barium Titanate: Powder and Heteroepitaxial Thin Films," J. Mater. Res., 10, 1784-89 (1995).
5. 3 Thin Films on Si(100) Substrate by Hydrothermal Synthesis," Jpn. J. Appl. Phys., 33, 4984-90 (1994).
6. K. Kinoshita and A. Yamaji, "Grain-Size Effects on Dielectric Properties in Barium Titanate Ceramics," J. Appl. Phys., 47, 371-73 (1976).
7. D. Hennings, "Barium Titanate Based Ceramic Materials for Dielectric Use," Int. J. High Technol. Ceram., 3, 91-111 (1987).
8. 3," IEEE Trans. Ultrason., Ferroelectr. Freq. Control. 36, 407-12 (1989).
9. 3"; pp. 339-45 in Ceramic Transactions, Vol. 32, Dielectric Ceramics: Processing, Properties, and Applications. Edited by K. M. Nair, J. P. Guha, and A. Okamoto. American Ceramic Society, Westerville, OH, 1993.
10. T. Ota, J. Takahashi, and I. Yamai, "Effect of Microstructure on the Dielectric Property of Ceramics," Key Eng. Mater., 66-67, 185-245 (1992).
11. K. Oonishi, T. Morohashi, and K. Uchino, "HIP Sintering of Fine Grained Barium Titanate," J. Ceram. Soc. Jpn., 97, 473-77 (1989).
12. W. R. Buessem, L. E. Cross, and A. K. Goswami, "Effect of Two-Dimensional Pressure on the Permittivity of Fine- and Coarse-Grained Barium Titanate," J. Am. Ceram. Soc., 49, 36-39 (1966).
13. 3," Phys. Rev., 151, 378-86 (1966).
14. M. Tokita, "Trends in Advanced SPS Spark Plasma Sintering System and Technology," J. Soc. Powder Technol., Jpn., 30, 790-804 (1993).
15. I. Kondoh, T. Tanaka, and N. Tamari, "Usefulness of Spark Plasma Sintering on Densification and Mechanical Properties of Alumina Whisker/Zirconia Composites," J. Ceram. Soc. Jpn., 102, 505-507 (1994).
16. N. Tamari, T. Tanaka, K. Tanaka, I. Kondoh, M. Kawahara, and M. Tokita, "Effect of Spark Plasma Sintering on Densification and Mechanical Properties of Silicon Carbide," J. Ceram. Soc. Jpn., 103, 740-42 (1995).
17. K. Fukai, K. Hidaka, M. Aoki, and K. Abe, "Preparation and Properties of Uniform Fine Perovskite Powders by Hydrothermal Synthesis," Ceram. Int., 16, 285-90 (1990).
18. T. Takeuchi, K. Ado, T. Asai, H. Kageyama, Y. Saito, C. Masquelier, and O. Nakamura, "Thickness of Cubic Surface Phase on Barium Titanate Single-Crystalline Grains," J. Am. Ceram. Soc., 77, 1665-68 (1994).
19. 3 Prepared by a Sol-Crystal Method," J. Mater. Sci., 32, 4053-60 (1997).
20. Powder diffraction File Card No. 5-626. International Centre for Diffraction Data, Newtown Square, PA.
21. J. C. Niepce, "Some Aspects of the Influence of Particle Size on Properties and Behavior of a Dielectric Material: Example of Barium Titanate"; pp. 521-33 in Surface and Interface of Ceramic Materials. Edited by L. C. Dufour, C. Monty, and G. Petot-Ervas. Kluwer, Dordrecht, Netherlands, 1989.
22. G. Arlt, D. Hennings, and G. de With, "Dielectric Properties of Fine-Grained Barium Titanate Ceramics," J. Appl. Phys., 58, 1619-25 (1985).
23. 3 Ceramics," J. Am. Ceram. Soc., 79, 1633-41 (1996).