Comparison of 20 two-phase heat transfer correlations with seven sets of experimental data, including flow pattern and tube inclination effects

Heat Transfer Engineering

Volumn 20, Issue 1, 1999, Pages 15-40

  Kim, Dongwoo ^a   Ghajar, Afshin J ^a   Dougherty, Ronald L ^a   Ryali, Venkata K ^a  

^a Oklahoma State University   (United States)

Author keywords

[No Author keywords available]

Indexed keywords

FLOW PATTERNS; PIPE FLOW; TWO PHASE FLOW;

TWO-PHASE HEAT TRANSFER CORRELATIONS;

HEAT TRANSFER;

EID: 0032637145     PISSN: 01457632     EISSN: 15210537     Source Type: Journal    
DOI: 10.1080/014576399271691     Document Type: Article

References (49)

1. Aggour, M. A., Hydrodynamics and Heat Transfer in Two-Phase Two-Component Flow, Ph.D. thesis, University of Manitoba, Winnepeg, Canada, 1978.
2. Chu, Y.-C., and Jones, B. G., Convective Heat Transfer Coefficient Studies in Upward and Downward, Vertical, Two-Phase, Non-Boiling Flows, AIChE Symp. Ser., vol. 76, pp. 79-90, 1980.
3. Davis, E. J., and David, M. M., Two-Phase Gas-Liquid Convention Heat Transfer, I&EC Fundamentals, vol. 3, no. 2, pp. 111-118, 1964.
4. Dorresteijn, W. R., Experimental Study of Heat Transfer in Upward and Downward Two-Phase Flow of Air and Oil through 70 mm Tubes, Proc. 4th Int. Heat Transfer Conf., vol. 5, B5.9, pp. 1-10, 1970.
5. Dusseau, W. T., Overall Heat Transfer Coefficient for Air-Water Froth in a Vertical Pipe, M.S. thesis, Chemical Engineering, Vanderbilt University, Nashville, TN, 1968.
6. Elamvaluthi, G., and Srinivas, N. S., Two-Phase Heat Transfer in Two Component Vertical Flows, Int. J. Multiphase Flow, vol. 10, no. 2, pp. 237-242, 1984.
7. Groothuis, H., and Hendal, W. P., Heat Transfer in Two-Phase Flow, Chem. Eng. Sci., vol. 11, pp. 212-220, 1959.
8. Hughmark, G. A., Holdup and Heat Transfer in Horizontal Slug Gas Liquid Flow, Chem. Eng. Sci., vol. 20, pp. 1007-1010, 1965.
9. Khoze, A. N., Dunayev, S. V., and Sparin, V. A., Heat and Mass Transfer in Rising Two-Phase Flows in Rectangular Channels, Heat Transfer—Sov. Res., vol. 8, no. 3, pp. 87-90, 1976.
10. King, C. D. G., Heat Transfer and Pressure Drop for an Air-Water Mixture Flowing in a 0.737 Inch I.D. Horizontal Tube, M.S. thesis, University of California, Berkeley, CA, 1952.
11. Knott, R. F., Anderson, R. N., Acrivos, A., and Petersen, E. E., An Experimental Study of Heat Transfer to Nitrogen-Oil Mixtures, Ind. Eng. Chem., vol. 51, no. 11, pp. 1369-1372, 1959.
12. Kudirka, A. A., Grosh, R. J., and McFadden, P W., Heat Transfer in Two-Phase Flow of Gas-Liquid Mixtures, I&EC Fundamentals, vol. 4, no. 3, pp. 339-344, 1965.
13. Martin, B. W., and Sims, G. E., Forced Convection Heat Transfer to Water with Air Injection in a Rectangular Duct, Int. J. Heat Mass Transfer, vol. 14, pp. 1115-1134, 1971.
14. Oliver, D. R., and Wright, S. J., Pressure Drop and Heat Transfer in Gas-Liquid Slug Flow in Horizontal Tubes, Bri. Chem. Eng., vol. 9, no. 9, pp. 590-596, 1964.
15. Ravipudi, S. R., and God bold, T. M., The Effect of Mass Transfer on Heat Transfer Rates for Two-Phase Flow in a Vertical Pipe, Proc. 6th Int. Heat Transfer Conf., Toronto, vol. 1, pp. 505-510, 1978.
16. Rezkallah, K. S., and Sims, G. E., An Examination of Correlations of Mean Heat Transfer Coefficients in Two-Phase and Two-Component Flow in Vertical Tubes, AIChE Symp. Ser., vol. 83, pp. 109-114,1987.
17. Serizawa, A., Kataoka, I., and Michiyoshi, I., Turbulence Structure of Air-Water Bubbly Flow—III. Transport Properties, Int. J. Multiphase Flow, vol. 2, pp. 247-259, 1975.
18. Shah, M. M., Generalized Prediction of Heat Transfer during Two Component Gas-Liquid Flow in Tubes and Other Channels, AIChE Symp. Ser., vol. 77, no. 208, pp. 140-151, 1981.
19. Ueda, T., and Hanaoka, M., On Upward Flow of Gas-Liquid Mixtures in Vertical Tubes: 3rd. Report, Heat Transfer Results and Analysis, Bull. Jpn. Soc. Mech. Eng., vol. 10, pp. 1008-1015, 1967.
20. Vijay, M. M., Aggour, M. A., and Sims, G. E., A Correlation of Mean Heat Transfer Coefficients for Two-Phase Two-Component Flow in a Vertical Tube, Proc. 7th Int. Heat Transfer Conf., vol. 5, pp. 367-372, 1982.
21. Sieder, E. N., and Tate, G. E., Heat Transfer and Pressure Drop of Liquids in Tubes, Ind. Eng. Chem., vol. 28, no. 12, p. 1429, 1936.
22. Akimenko, A. D., Zemskov, G. A., and Skvortsov, A. A., Study of Heat Transfer to Water-Air Flow, Heat Transfer—Sov. Res., vol. 2, no. 2, pp. 47-49, 1970.
23. Barnea, D., and Yacoub, N., Heat Transfer in Vertical Upwards Gas-Liquid Slug Flow, Int. J. Heat Mass Transfer, vol. 26, no. 9, pp. 1365-1376,1983.
24. Davis, E. J., Hung, S. C., and Arciero, S., An Analogy for Heat Transfer with Wavy/Stratified Gas-Liquid Flow, AIChE J., vol. 21, no. 5, pp. 872-878, 1975.
25. Domanskii, I. V., Tishin, V. B., and Sokolov, V. N., Heat Transfer during Motion of Gas-Liquid Mixtures in Vertical Pipes, J. Appl. Chem. USSR, vol. 42, no. 4, pp. 809-813,1969.
26. Fedotkin, I. M., and Zarudnev, L. P., Correlation of Experimental Data on Local Heat Transfer in Heating of Air-Liquid Mixtures in Pipes, Heat Transfer—Sov. Res., vol. 2, no. 1, pp. 175-181, 1970.
27. Fried, L., Pressure Drop and Heat Transfer for Two-Phase, Two-Component Flow, Chem. Eng. Prog. Symp. Ser., vol. 50, no. 9, pp. 47-51, 1954.
28. Ivanov, M. Y, and Arustamyan, E. S., Study of Heat Transfer in an Ascending Gas-Liquid Flow, Heat Transfer—Sov. Res., vol. 3, no. 2, pp. 149-153, 1971.
29. Johnson, H. A., Heat Transfer and Pressure Drop for Viscous-Turbulent Flow of Oil-Air Mixtures in a Horizontal Pipe, ASME Trans., vol. 77, pp. 1257-1264, 1955.
30. Johnson, H. A., and Abou-Sabe, A. H., Heat Transfer and Pressure Drop for Turbulent Flow of Air-Water Mixture in a Horizontal Pipe, ASME Trans., vol. 74, pp. 977-987, 1952.
31. Kapinos, V. M., Slitenko, A. F., Chirkin, N. B., and Povolotskiy, L. V., Heat Transfer in the Entrance Section of a Pipe with a Two-Phase Flow, Heat Transfer—Sov. Res., vol. 7, no. 2, pp. 126-128, 1975.
32. Lunde, K. E., Heat Transfer and Pressure Drop in Two-Phase Flow, Chem. Eng. Prog. Symp. Ser., vol. 57, no. 32, pp. 104-110, 1961.
33. Michiyoshi, I., Heat Transfer in Air-Water Two-Phase Flow in a Concentric Annulus, Proc. 6th Int. Heat Transfer Conf., Toronto, vol. 6, pp. 499-504, 1978.
34. Novosad, Z., Heat Transfer in Two-Phase Liquid-Gas Systems, Collection Czecholav Chem. Commun., vol. 20, pp. 477-499, 1955.
35. Oliver, D. R., and Young Hoon, A., Two-Phase Non-Newtonian Flow. Part II: Heat Transfer, Trans. INSTN Chem. Eng., vol. 46, pp. T116-T112,1968.
36. Ovchinnikov, Y V, and Khoze, A. N., Heat and Mass Transfer in Two-Component, Two-Phase Flows Inside of Cylinders, Heat Transfer—Sov. Res., vol. 2, no. 6, pp. 130-135, 1970.
37. Ozbelge, T. A., and Somer, T. G., A Heat Transfer Correlation for Liquid-Solid Flows in Horizontal Pipes, Chem. Eng. J., vol. 55, pp. 39-44, 1994.
38. Shaharabanny, O., Taitel, Y., and Dukler, A. E., Heat Transfer during Intermittent/Slug Flow in Horizontal Tubes: Experiments, Proc. 2nd CSNI Specialists Meeting, June 12-14, Paris, pp. 627-649, 1978.
39. Shoham, O., Dukler, A. E., and Taitel, Y., Heat Transfer during Intermittent/Slug Flow in Horizontal Tubes, Ind. Eng. Chem. Fundamentals., vol. 21, pp. 312-319, 1982.
40. Vijay, M. M., A Study of Heat Transfer in Two-Phase Two-Component Flow in a Vertical Tube, Ph.D. thesis, University of Manitoba, Winnepeg, Canada, 1978.
41. Rezkallah, K. S., Heat Transfer and Hydrodynamics in Two-Phase Two-Component Flow in a Vertical Tube, Ph.D. thesis, University of Manitoba, Winnepeg, Canada, 1987.
42. Pletcher, R. H., An Experimental and Analytical Study of Heat Transfer and Pressure Drop in Horizontal Annular Two-Phase, Two-Component Flow, Ph.D. thesis, Cornell University, Ithaca, NY, 1966.
43. Lockhart, R., and Martinelli, R. C., Proposed Correlation of Data for Isothermal Two-Phase, Two-Component Flow in Pipes, Chem. Eng. Prog., vol. 45, no. 1, pp. 39-48, 1949.
44. Govier, G. W., and Aziz, K., The Flow of Complex Mixtures in Pipes, Van Nostrand Reinhold, New York, 1973.
45. Griffith, P., and Wallis, G. B., Two-Phase Slug Flow, J. Heat Transfer, Trans. ASME, Ser. C83, pp. 307-320, 1961.
46. Hewitt, G. F., and Hall-Taylor, N. S., Annular Two-Phase Flow, Pergamon Press, Oxford, UK, 1970.
47. Taitel, Y., Barnea, D., and Dukler, A. E., Modeling Flow Pattern Transitions for Steady Upward Gas-Liquid Flow in Vertical Tubes, AIChE J., vol. 26, no. 3, pp. 345-354, 1980.
48. Taitel, Y., and Dukler, A. E., A Model for Predicting Flow Regime Transitions in Horizontal and Near Horizontal Gas-Liquid Flow, AIChE J., vol. 22, no. 1, pp. 47-54, 1976.
49. Kim, D., Sofyan, Y., Ghajar, A. J., and Dougherty, R. L., An Evaluation of Several Heat Transfer Correlations for Two-Phase Flow with Different Flow Patterns in Vertical and Horizontal Tubes, in S. G. Kandlikar, C. H. Amon, M. E. Ulucakli, and J. O’Brien (eds.) Fundamentals of Bubble and Droplet Dynamics; Phase Change and Two-Phase Flow, HTD-Vol. 342, pp. 119-130, ASME, New York, 1997.